User manual YAMAHA YZF1000RJ SERVICE MANUAL

[. . . ] If you have any questions concerning the operation or maintenance of your motorcycle, please consult a Yamaha dealer. The design and manufacture of this Yamaha motorcycle fully comply with the emissions standards for clean air applicable at the date of manufacture. Yamaha has met these standards without reducing the performance or economy of operation of the motorcycle. To maintain these high standards, it is important that you and your Yamaha dealer pay close attention to the recommended maintenance schedules and operating instructions contained within this manual. IMPORTANT MANUAL INFORMATION EAU10131 Particularly important information is distinguished in this manual by the following notations: The Safety Alert Symbol means ATTENTION! [. . . ] Fit the tabs on the panel into the slots and slide it backward. EAU19652 Checking the spark plugs The spark plugs are important engine components, which should be checked periodically, preferably by a Yamaha dealer. Since heat and deposits will cause any spark plug to slowly erode, they should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plugs can reveal the condition of the engine. The porcelain insulator around the center electrode of each spark plug should be a medium-to-light tan (the ideal color when the vehicle is ridden normally), and all spark plugs installed in the engine should have the same color. If any spark plug shows a distinctly different color, the engine could be operating improperly. If a spark plug shows signs of electrode erosion and excessive carbon or other deposits, it should be replaced. Specified spark plug: NGK/CR9EK, CR10EK 6-10 Before installing a spark plug, the spark plug gap should be measured with a wire thickness gauge and, if necessary, adjusted to specification. 1. Install the bolts. Spark plug gap: 0. 6­0. 7 mm (0. 024­0. 028 in) Clean the surface of the spark plug gasket and its mating surface, and then wipe off any grime from the spark plug threads. Tightening torque: Spark plug: 12. 5 Nm (1. 25 m·kgf, 9. 0 ft·lbf) PERIODIC MAINTENANCE AND MINOR REPAIR EAU19681 EAU19932 NOTE: If a torque wrench is not available when installing a spark plug, a good estimate of the correct torque is 1/4­1/2 turn past finger tight. However, the spark plug should be tightened to the specified torque as soon as possible. ECA10840 Canister (for California only) Engine oil and oil filter cartridge The engine oil level should be checked before each ride. In addition, the oil must be changed and the oil filter cartridge replaced at the intervals specified in the periodic maintenance and lubrication chart. Place the vehicle on a level surface and hold it in an upright position. NOTE: Make sure that the vehicle is positioned straight up when checking the oil level. In addition, the coolant must be changed at the intervals specified in the periodic maintenance and lubrication chart. EAU38171 CAUTION: If the oil level warning light flickers or remains on, immediately turn the engine off and have a Yamaha dealer check the vehicle. Turn the engine off, and then check the oil level and correct it if necessary. Place the vehicle on a level surface and hold it in an upright position. NOTE: G The coolant level must be checked on a cold engine since the level varies with engine temperature. G Make sure that the vehicle is positioned straight up when checking the coolant level. NOTE: The coolant should be between the minimum and maximum level marks. CAUTION: G 6 G In order to prevent clutch slippage (since the engine oil also lubricates the clutch), do not mix any chemical additives. Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. 6-14 PERIODIC MAINTENANCE AND MINOR REPAIR G If water has been added to the coolant, have a Yamaha dealer check the antifreeze content of the coolant as soon as possible, otherwise the effectiveness of the coolant will be reduced. EWA10380 WARNING 1. Coolant reservoir cap Never attempt to remove the radiator cap when the engine is hot. Install the reservoir cap, and then install the coolant reservoir cover by installing the bolts. [. . . ] has an up-to-date registration record in accordance with federal law. 9 9-8 CONSUMER INFORMATION EAU26750 YAMAHA EXTENDED SERVICE (Y. E. S. ) Keep your Yamaha protected even after your warranty expires with genuine Yamaha Extended Service (Y. E. S. ). is designed and administered by Yamaha Motor Corporation to provide maximum owner satisfaction. You get uninterrupted factory-backed coverage for extra peace of mind. You choose the plan that's right for you: 12 months, 24 months, 36 months or, on certain models, even 48 months beyond your warranty period. [. . . ]