User manual YAMAHA YZF-R1-2008

[. . . ] OWNER'S MANUAL YZFR1X(C) LIT-11626-21-41 4C8-28199-11 EAU10041 INTRODUCTION EAU10080 Congratulations on your purchase of the Yamaha YZFR1X(C). This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. This manual will give you an understanding of the operation, inspection, and basic maintenance of this motorcycle. [. . . ] 6 CAUTION: Do not use any tools to remove or install the spark plug cap, otherwise the ignition coil coupler may get damaged. The spark plug cap may be difficult to remove because the rubber seal on the end of the cap fits tightly. To remove the spark plug cap, simply twist it back and forth while pulling it out; to install it, twist it back and forth while pushing it in. This model is equipped with a canister to prevent the discharging of fuel vapor into the atmosphere. Before operating this vehicle, make sure to check the following: G Check each hose connection. G Make sure that the canister breather is not blocked, and if necessary, clean it. 6-13 PERIODIC MAINTENANCE AND MINOR REPAIR NOTE: The engine oil should be between the minimum and maximum level marks. Start the engine, warm it up for several minutes, and then turn it off. Remove the engine oil filler cap and drain bolt to drain the oil from the crankcase. 1. 4. Engine oil level check window Maximum level mark Minimum level mark Engine oil filler cap 1. Engine oil drain bolt NOTE: An oil filter wrench is available at a Yamaha dealer. Apply a thin coat of engine oil to the O-ring of the new oil filter cartridge. 4. If the engine oil is at or below the minimum level mark, add sufficient oil of the recommended type to raise it to the correct level. To change the engine oil (with or without oil filter cartridge replacement) 1. (See page 6-9. ) NOTE: Skip steps 5­7 if the oil filter cartridge is not being replaced. Remove the oil filter cartridge with an oil filter wrench. 6-14 PERIODIC MAINTENANCE AND MINOR REPAIR Recommended engine oil: See page 8-1. Oil quantity: Without oil filter cartridge replacement: 2. 90 L (3. 07 US qt) (2. 55 Imp. qt) With oil filter cartridge replacement: 3. 10 L (3. 28 US qt) (2. 73 Imp. qt) 1. Install the new oil filter cartridge with an oil filter wrench, and then tighten it to the specified torque with a torque wrench. Tightening torque: Oil filter cartridge: 17 Nm (1. 7 m·kgf, 12 ft·lbf) NOTE: Be sure to wipe off spilled oil on any parts after the engine and exhaust system have cooled down. ECA11620 CAUTION: 8. Install the engine oil drain bolt, and then tighten it to the specified torque. NOTE: Check the washer for damage and replace it if necessary. Tightening torque: Engine oil drain bolt: 43 Nm (4. 3 m·kgf, 31 ft·lbf) G G 9. Add the specified amount of the recommended engine oil, and then install and tighten the oil filler cap. 6-15 In order to prevent clutch slippage (since the engine oil also lubricates the clutch), do not mix any chemical additives. Do not use oils with a diesel specification of "CD" or oils of a higher quality than specified. In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. [. . . ] You choose the plan that's right for you: 12 months, 24 months, 36 months or, on certain models, even 48 months beyond your warranty period. is designed and administered by the same Yamaha people who handle your warranty ­ and it shows in the comprehensive coverage benefits. Coverage isn't limited to "moving parts" or the "drive train" like many other plans. See the sample contract at your Yamaha dealer to see how comforting uninterrupted factorybacked protection can be. [. . . ]