User manual YAMAHA XMAX125-2007

[. . . ] OWNER'S MANUAL YP125R 1B9-F8199-E1 INTRODUCTION EAU10110 Welcome to the Yamaha world of motorcycling!As the owner of the YP125R, you are benefiting from Yamaha's vast experience and newest technology regarding the design and manufacture of high-quality products, which have earned Yamaha a reputation for dependability. Please take the time to read this manual thoroughly, so as to enjoy all advantages of your YP125R. The owner's manual does not only instruct you in how to operate, inspect and maintain your scooter, but also in how to safeguard yourself and others from trouble and injury. [. . . ] G Items marked with an asterisk should be performed by a Yamaha dealer as they require special tools, data and technical skills. ODOMETER READING (x 1000 Km) NO. 1 * Fuel line 2 Spark plug ITEM CHECK OR MAINTENANCE JOB 1 · Check fuel and vacuum hoses for cracks or damage. 6 Every 20000 Km Every 20000 Km Whenever worn to the limit Whenever worn to the limit 12 18 24 ANNUAL CHECK 6 3 * Valves 4 Air filter element 5 * V-Belt 6 * Front brake 7 * Rear brake 6-3 PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING (x 1000 Km) NO. ITEM CHECK OR MAINTENANCE JOB 1 8 * Brake hoses 9 * Wheels 10 * Tires 11 * Wheel bearings 12 * Steering bearings 13 * Chassis fasteners 14 Sidestand, centerstand · Check for cracks or damage. 6 12 18 24 Every 4 years ANNUAL CHECK · Check bearing for looseness or damage. · Make sure that all nuts, bolts and screws are properly tightened. (See page 6-8) · Check oil level/top up. Every 20000 km 6 15 * Sidestand switch 16 * Front fork Shock absorber 17 * assemblies 18 * Fuel injection 19 20 Engine oil When the oil change indicator light comes on (every 6000 km) Every 3000 km Every 3 years Engine oil filter element · Replace. 6-4 21 * Cooling system PERIODIC MAINTENANCE AND MINOR REPAIR ODOMETER READING (x 1000 Km) NO. ITEM CHECK OR MAINTENANCE JOB 1 22 23 Final gear oil * V-belt case air filter elements · Check vehicle for oil leakage. 6 Every 6000 km Every 20000 km 12 18 24 ANNUAL CHECK Front and rear brake 24 * switches 25 Moving parts and cables · Lubricate. · Adjust headlight beam. 26 * Throttle grip housing and cable 27 * Muffler and exhaust pipe · Check the screw clamp for looseness. Lights, signals 28 * and switches 6 EAU18660 NOTE: G The air filter needs more frequent service if you are riding in unusually wet or dusty areas. G Hydraulic brake service · Regularly check and, if necessary, correct the brake fluid level. · Every two years replace the internal components of the brake master cylinder and caliper, and change the brake fluid. · Replace the brake hoses every four years and if cracked or damaged. 6-5 PERIODIC MAINTENANCE AND MINOR REPAIR EAU18712 Removing and installing cowlings and panels The cowlings and panels shown need to be removed to perform some of the maintenance jobs described in this chapter. Refer to this section each time a cowling or panel needs to be removed and installed. EAU18790 Cowling B To remove the cowling EAUM1250 Panel A To remove the panel 1. (See page 3-12. ) Cowling A To remove the cowling Screws 6 1 1 Remove the screws, and then take the cowling off. To install the cowling Place the cowling in the original position, and then install the screws. Screws 1. Close the storage compartment. 6-6 PERIODIC MAINTENANCE AND MINOR REPAIR EAUS1280 Checking the spark plug The spark plug is an important engine component, which is easy to check. Since heat and deposits will cause any spark plug to slowly erode, the spark plug should be removed and checked in accordance with the periodic maintenance and lubrication chart. In addition, the condition of the spark plug can reveal the condition of the engine. Remove the storage compartment under the seat by removing the bolts. To check the spark plug 1. [. . . ] To prevent corrosion, it is recommended to apply a corrosion protection spray on all metal, including chrome- and nickel-plated, surfaces. Let the scooter dry completely before storing or covering it. EWA10940 s WARNING G Make sure that there is no oil or wax on the brakes or tires. If necessary, clean the brake discs and brake linings with a regular brake disc cleaner or acetone, and wash the tires with warm water and a mild detergent. G Before operating the scooter test its braking performance and cornering behavior. ECA10800 CAUTION: G Apply spray oil and wax sparingly and make sure to wipe off any excess. [. . . ]