User manual YAMAHA EF3000ISE

[. . . ] Generator OWNER'S MANUAL EF3000iSE EF3000iSEB LIT-19626-01-20 7CH-28199-10 AE00002 INTRODUCTION Congratulations on your purchase of your new Yamaha. This manual will provide you with a good basic understanding of the operation and maintenance of this machine. If you have any questions regarding the operation or maintenance of your machine, please consult a Yamaha dealer. CODE AE00012 SERIAL No. IDENTIFICATION NUMBER RECORDS Record your Primary I. D. , and serial numbers in the spaces provided, to assist you in ordering spare parts from a Yamaha dealer. [. . . ] Connect the positive lead 1 to the positive battery terminal 2, then the negative lead 3 to the negative battery terminal 4. NOTE: 9 Clamp the red wire to the positive (+) terminal first, then the black wire to the negative (-) terminal of the battery. 9 For EF3000iSEB, tighten the two positive battery leads (one from the starter relay and one from the DC-DC converter) to the same positive terminal and the two negative battery leads (one from the engine and one from the DC-DC converter) to the same negative terminal. EF3000iSEB to STARTER RELAY to ENGINE to DC-DC CONVERTER 762-045a ­ 13 ­ 8. Install the battery box 5 and tighten the bolts 6. y y t y y 788-007a 10. Install the cover 7 and tighten the bolts 8. i i u i i 788-006a w Battery electrolyte is poisonous and dangerous, causing severe burns, etc. Eyes: Flush with water for 15 minutes and get prompt medical attention. KEEP OUT OF REACH OF CHILDREN. 762-012 ­ 14 ­ AE00955 OPERATION q 700-006a NOTE: The generator has been shipped without engine oil. Fill with oil or it will not start. 1 Upper level AE01073 STARTING THE ENGINE NOTE: 9 Before starting the engine, do not connect any electric devices. 9 Turn the economy control switch to the "3" (OFF) position. 1 q 763-126b 761-080 3 "OFF" q ON 1. Turn the fuel cock knob to the "ON" position. 1 "ON" OFF 705-073 2. Pull the choke knob fully out. 1 Choke knob q 701-049b NOTE: The choke is not required to start a warm engine. Turn the engine switch to the "6" (START) position. 1 6 "START" q 763-120e ­ 15 ­ cC 9 Take your hand off the switch immediately after the engine starts. 9 If the engine fails to start, release the switch, wait a few seconds, then try again. After the engine starts, warm up the engine until the engine does not stop when the choke knob is returned to the original position. NOTE: When starting the engine in areas where the ambient temperature is below 0°C (32°F), the engine automatically operates at the rated r/min (3, 800 r/min) for three minutes to warm up the engine regardless of the economy control switch position. The economy control unit operates normally afterwards if the economy control switch is turned to "I" (ON). 701-049c q Manual Starting: 3. Turn the engine switch to the "7" (ON) position. 1 7 "ON" 763-120a 4. Pull slowly on the recoil starter until it is engaged, then pull it briskly. After the engine starts, warm up the engine until the engine does not stop when the choke knob is returned to the original position. Push the choke knob back to the original position. 704-018 ­ 16 ­ AE01000 APPLICATION RANGE AC DC Power factor 1 0. 8­0. 95 0. 4­0. 75 (Efficiency 0. 85) Rated voltage 12V Rated current 12A EF3000iSE EF3000iSEB ­2, 800W ­2, 240W ­950W NOTE: 9 "­" means below. 9 The simultaneous usage of AC and DC power is possible but total wattage should not exceed the rated output. EX: Generator rated output Frequency Power factor 1. 0 AC 0. 8 DC -- 2, 800VA ­2, 650W ­2, 100W 144W (12V/12A) q 760-026 9 The overload indicator light 1 comes on when total wattage exceeds the application range. [. . . ] 9 To prevent ELECTRIC SHOCK do not hold spark plug lead with hand while testing. L Incorrect Replace or Adjust Gap. M OK Clean the spark plug. I Engine does not start. J Engine starts. N Check the following O Clogged 9 Fuel line clogging 9 Air cleaner element P OK clogging. Q Clean or Replace; Consult Yamaha dealer. Consult a Yamaha dealer. a R ­ 33 ­ AE00601 STORAGE Long term storage of your machine will require some preventive procedures to guard against deterioration. AE01056 DRAIN THE FUEL 1. Drain the fuel from the fuel tank into an approved gasoline container using a commercially available hand siphon. Then, install the fuel tank cap. w 9 Fuel is highly flammable and poisonous. [. . . ]