User manual WORCESTER 40CDI GC

[. . . ] The Greenstar range in particular is extremely energy efficient, converting up to 97% of gas consumed into heat, offering you economical running costs and value for money. It sits in SEDBUK Band A, and is therefore amongst the top energy rated appliances available. There is also the reassurance of our nononsense 2 years parts and labour guarantee - backed up by Worcester Total Cover, an optional complete maintenance scheme to keep your boiler operating at peak condition and efficiency. To find out more about Worcester Bosch log onto www. worcesterbosch. co. uk. 4 EXCELLENCE COMES WORCESTER BOSCH GREENSTAR 25CDi/30CDi/35CDi/40CDi AS STANDARD 6 720 611 928a (02/05) IF YOU SMELL GAS: DON'T SMOKE OR STRIKE DON'T TURN ELECTRICAL SWITCHES ON OR OFF DO PUT OUT NAKED FLAMES DO OPEN DOORS AND WINDOWS MATCHES BENCHMARK STANDARD `Benchmark' is a code of practice for correctly installing, commissioning and servicing of domestic water heating appliances. [. . . ] If the appliance is fitted into a cupboard or a compartment is built around the appliance after installation, then the compartment must be separated from the boiler space by a perforated non-combustible partition as described in BS 6798. Notwithstanding the requirements of BS 6798 and BS 5440 there is no need for ventilation openings to be provided in the compartment because of the low heat loss from the appliance casing, if the clearances shown are maintained. Do not operate the appliance if the flue terminal fitted on the outside wall or roof is obstructed or damaged. PUMP ANTI-SEIZURE If there has been no heating demand for 24 hours the boiler will run the system pump for a few seconds to reduce the possibility of pump seizure during long periods of inactivity, which is usually more frequent during the summer months. WORCESTER BOSCH GREENSTAR 25CDi/30CDi/35CDi/40CDi 6 720 611 928a (02/05) GENERAL NOTES 11 INTRODUCTION GENERAL NOTES CONTROLS J USING YOUR APPLIANCE I A D F L K E H M 5 C min G 6 720 611 928-01. 1O B A - MASTER SWITCH FOR ON/OFF B - MAINS ON/OFF INDICATOR + FAULT DIAGNOSTIC LIGHT C - CENTRAL HEATING TEMPERATURE CONTROL D - BURNER ON INDICATOR LIGHT (GREEN) E - FAULT RESET BUTTON F - SERVICE BUTTON G - DOMESTIC HOT WATER TEMPERATURE CONTROL H - ECO BUTTON (DOMESTIC HOT WATER PRE-HEAT ON/OFF) IJSYSTEM PRESSURE GAUGE POSITION FOR OPTIONAL PROGRAMMER K - DISPLAY L - CENTRAL HEATING BOOST BUTTON M - HOLIDAY BUTTON 12 CONTROLS WORCESTER BOSCH GREENSTAR 25CDi/30CDi/35CDi/40CDi 6 720 611 928a (02/05) OPERATING THE APPLIANCE SWITCHING THE APPLIANCE ON/OFF Switching on USING YOUR APPLIANCE B Switch on the appliance by pressing the master switch. The indicator light shows blue · The boiler runs for 15 minutes at minimum heating output to fill the condensate trap, the display (K) alternates between "-II-" and the central heating flow temperature. Switching off B Switch off the appliance by pressing the master switch. SETTING THE CENTRAL HEATING TEMPERATURE B Turn the central heating temperature control to the desired level, between 40 °C and 90 °C. The gas supply to the burner is controlled according to the level of demand for heat. The boiler continues to operate with a low flame if the demand for heat reduces. Modulating control reduces temperature fluctuations and provides even distribution of heat throughout the home. This means that the boiler may stay on for relatively long periods but will use less gas than an appliance that continually switches on and off. Central heating systems with room thermostats/thermostatic radiator valves The central heating control on the boiler should be set to the maximum rated temperature of the central heating system. The temperature of each room can be set individually (except primary room with the room thermostat) using the thermostatic radiator valves. Roof insulation Around 30% of the heat loss from a property is through the roof. Replace any old insulation with new insulation, preferably of around 200 mm thickness or more. Window frames Single glazed windows, particularly those with steel frames, can lose a great deal of heat. Consideration should be given to replacement with PVCu or wooden framed double glazed units. Curtains Lined curtains, or heavier full length curtains can provide excellent insulation. However, always ensure that the curtains do not drape over radiators. ENERGY SAVING 16 TIPS ON ENERGY SAVING WORCESTER BOSCH GREENSTAR 25CDi/30CDi/35CDi/40CDi 6 720 611 928a (02/05) TIPS ON ENERGY SAVING Draughts Try to ensure that draughts around doors, windows, letterboxes and keyholes etc. Warning - Do not block or seal any air vents that are installed to ensure the central heating boiler operates safely. Room thermostats Reducing the setting of the room thermostat by 1 °C can reduce fuel consumption by up to 10%. New control systems Upgrade your heating control system if necessary with the latest equipment available. [. . . ] B The householder may be asked to prove the date of installation, that the appliance was correctly commissioned and, where appropriate, the first year's service has been carried out to the satisfaction of BBT Thermotechnology UK Ltd. B Any product or part returned for servicing under the guarantee must be accompanied by a claim stating the model, serial number & date of installation. will not accept responsibility for damage caused by faulty installation, neglect, misuse or accidental damage or the nonobservance of the instructions contained in the Installation and Servicing Manual and User Instructions. B The appliance has been used only for the normal domestic purposes for which it was designed. [. . . ]