User manual THERMADOR 08-04-373C

[. . . ] Care & Use Manual for Thermador Char Glo Outdoor Barbecues ® Models: CGB30RCULP · CGB36RU CGB48RU · CGB48RSBU Page 27 A Special Message to Our Customers Thank you for selecting the Thermador® Char Glo® outdoor barbecue. We recommend that you take time to read this entire booklet before using your new appliance for the first time. This booklet contains suggestions we believe will be helpful as well as directions for using all the features of your appliance. Keep it in a handy place as it has the answers to questions that may occur when you start to cook. [. . . ] Open the hood to allow any accumulated gas to dissipate and wait five minutes before trying to light the unit. If the smell of gas is still present, turn off the gas supply to the unit at the manual shut off valve. Check the unit for leaks by following the instructions in Section 6 in the Installation Instructions or call your authorized servicer or the gas company. Before the First Use 1. Record model and serial number of your barbecue for future contacts with Thermador® or an authorized servicer (Located on left-side LP storage drawer). Follow Main Burner Lighting Instructions: Turn all burners on HI setting for 15 - 20 minutes with hood/lid down. Optional step: Line drip tray with heavy-duty aluminum foil and a thin layer of sand or bird gravel. Protect the finish with a stainless steel cleaner or protective polish. See care suggestions Page 23. Page 11 SECTION 3: USING YOUR CHAR GLO® BARBECUE LIGHTING INSTRUCTIONS WITH AUTOMATIC IGNITION ­ Read Before Lighting ­ Main and Smoker Burners: 1. Always turn control knob to the "Lite" position and immediately press and hold the ignition switch. Refer to the Grill Cooking Chart Pages 16 and 17. Infrared Rotisserie Burner: 1. IMPORTANT NOTE: Make sure the control knob is set to the "LITE" position when lighting the infrared burner. Allow the burner to operate on "HI" until it begins to glow orange/red (typically 2-3 minutes) before adjusting the control knob to the desired flame setting. Turn control knob to the "Lite" and immediately press ignition switch. Adjust control knob to the desired flame setting. Page 12 SECTION 3: USING YOUR CHAR GLO® BARBECUE MANUAL LIGHTING INSTRUCTIONS** ­ Read Before Lighting ­ Follow these steps to light the Main Burners manually: 1. Wait 5 minutes to allow any accumulated gas to dissipate. Middle section of radiant Access Hole for Manual Lighting Use a long stem match to light manually: 3. Find the ports on top of the burner by looking through the opening at the end of the radiant. Place the lighted long-stem match through the hole in the radiant (see illustration above). The burner will light within 4 to 10 seconds. Follow these steps to light the Smoker manually: 1. Place the lighted match through the opening for the smoker tray and next to the burner ports. ** NOTE: The infrared rotisserie burner cannot be lit manually. Page 13 SECTION 4: THE GRILL GENERAL GRILL INFORMATION · · · · · · · · · · Thaw food items before grilling. After preheating, reduce the flame to setting listed on Grilling Chart. The degree of doneness is influenced by the type of meat, cut of meat (i. e. [. . . ] For handy reference, copy the information below from the data rating label. Keep your invoice for warranty validation. Lighting Instructions (Etched on Control Panel) Data Rating Label __________________________________ Model Number __________________________________ Serial Number __________________________________ Date of Purchase __________________________________ Dealer's Name __________________________________ Dealer's Phone Number __________________________________ Service Center's Name __________________________________ Service Center's Phone Number Warning Label on Drip Tray Handle To Obtain Replacement Parts, order from the dealer where the unit was purchased or dial the telephone number listed below. HOW TO OBTAIN SERVICE For authorized service or parts information, phone 800/735-4328. If a problem does come up that cannot be resolved to your satisfaction, please let us know. Write: Thermador® Customer Call Center, 5551 McFadden Avenue, Huntington Beach CA 92649 or phone 800/735-4328. [. . . ]