User manual SUB-ZERO BBQ INSTALL GUIDE

[. . . ] Record the model and serial numbers before installing the gas BBQ grill. Both numbers are listed on the product rating plate, located on the rear panel of the grill. Model Number If the information in this book is not followed exactly, a fire or explosion may result, causing property damage, personal injury or death. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. [. . . ] The radiants are supported on each end by a pin located just above the grill burner. Be sure the heat radiants are oriented so that the triangular cut-out is positioned to the rear of the grill. The Wolf BBQ grill design eliminates the use of briquettes or lava rocks. The grill burners produce 10, 000 Btu/hr (2. 9 kW) per burner. The battery-powered ignition uses a AAA battery, provided with the BBQ grill, to be installed behind each ignition button. To install or replace, remove the ignition button by unscrewing in a counterclockwise direction. Insert the AAA battery into the cavity with the positive end in first and replace the ignition button. To make sure the sparker is operating, press the ignition button and listen for a spark. Grill Grate Radiant Burner Insert battery behind ignition button BBQ grill components Dimensions in parentheses are in millimeters unless otherwise specified. Radiant positioning Location of battery 13 WO L F GAS BBQ GRILLS N AT U R A L G A S H O O K - U P LP GAS H O O K - U P For Wolf natural gas BBQ grill models, hook-up is made from the rear right side with the fittings and regulator shown. Make sure the flow arrow on the regulator points in the direction of the gas flow from the gas supply to the BBQ grill. Wolf BBQ grills set up for use with LP gas come equipped with a 5' (1. 5 m) hose, regulator and an unfilled 20-pound LP gas cylinder. LP (liquefied petroleum) gas is sometimes called propane, butane or bottled gas. It is a flammable gas which becomes liquid when stored under high pressure inside a cylinder and it vaporizes when released. Leaking LP gas tends to collect in low areas and could cause a fire or explosion. It is important there are no leaking connections on your gas BBQ grill. Refer to the Gas Leak Testing on page 17. Manifold Pipe Regulator To Grill Vent Regulator Shut-Off Valve Adapter Close Nipple From Gas Supply Natural gas hook-up Natural gas regulator 14 I N S TA L L AT I O N I N S T R U C T I O N S LP GAS C Y L I N D E R C Y L I N D E R S P E C I F I C AT I O N S Any LP gas cylinder used with this BBQ grill must be approximately 12" (305) diameter and 18" (457) high. The full cylinder weight should be approximately 38 lbs (17. 2 kg), which is 43. 7 lbs (19. 8 kg) nominal water capacity. The LP gas cylinder must be provided with an approved overfilling preventive device (OPD). All LP gas cylinders used with this appliance must be constructed and marked in accordance with the specifications for LP gas cylinders. Always use the cylinder dust cap on the cylinder valve outlet during transport and when the cylinder is not connected to the BBQ grill. The LP gas cylinder provided with the grill is equipped with a quick connect closing (QCC-1) cylinder valve. The valve contains a backcheck which is designed to prevent gas flow until it is connected to the regulator. Keep the cylinder valve closed when it is not in use or attached to the grill. Allow only a qualified LP gas dealer to fill or repair your LP gas cylinder. After filling, have the gas dealer check for leaks to see that the relief valve remains free to function. [. . . ] Follow troubleshooting procedures as described in the Wolf Gas BBQ Grills Use & Care Information. If the BBQ grill still does not work, contact a Wolf authorized service center. Wolf is not responsible for service required to correct a faulty installation. Be sure to disconnect the electrical and gas supply before servicing. Use extreme caution. 18 I N S TA L L AT I O N I N S T R U C T I O N S I F Y O U N E E D S E RV I C E If service is necessary, maintain the quality built into your gas BBQ grill by calling a Wolf authorized service center. [. . . ]