User manual SEGA VIRTUA COP 2 DX

[. . . ] INTRODUCTION TO THIS SERVICE MANUAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 3. INSTALLATION AND SERVICE INSTRUCTIONS. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 3. 1. HANDLING AND INSTALLATION PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 3. 2. COIN HANDLING. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 3. 3. [. . . ] · Only replace fuses with ones of the same value and type. There are a number of fuses used on this machine to protect the user and the machine from damage. Detailed below is a list of the fuses used, their location and if relevant PCB reference: PART NUMBER 514-5078-6300 514-5078-6300 514-5078-5000 LOCATION 838-11856CE-02 (F1) 838-13616 (F1) IEC INLET (EP1302) TYPE & DETAILS 5x20 HRC SB 6300mA 5x20 HRC SB 6300mA 5x20 HRC SB 5000mA QTY PER COCKPIT 1 1 1 There are also fuses located on the Monitor PCB. Refer to the relevant Monitor manual supplied to reference these fuses. 32 3. 12. REPLACEMENT OF FLUORESCENT LAMP AND OTHER LAMPS · Never touch places other than those specified. Touching places other than those specified can cause electric shock and short circuit. Disconnect the machine from the supply before attempting the replacement of any lamp. Allow the Lamp to cool before touching it. · Only QUALIFIED SERVICE PERSONNEL should replace lamps. 3. 12. 1. FLUORESCENT LAMP REPLACEMENT 1. Then withdraw the Lamp from the two clips, using care to avoid breakage. Replacement of Lamp is in reverse order of removal. 33 3. 12. 2. LAMP REPLACEMENT 1. Remove the control panel cover as shown by removing the 8 screws holding it in position. Carefully lift the control panel cover up until it is possible to disconnect the wire harness plugs attaching the start switches to the cabinet. The controller's internal components are mounted on the right shell, so work with the gun lying on its right side. To replace the Weapon Change Button microswitch, first remove the Weapon Change Button from the right shell. Remove the 10 screws to separate the two shells. 3. With the right shell lying flat, carefully lift the left shell from the right shell. SCREW (10), black / M3 x 10, W/small flat & spring washers 37 4. Remove the trigger microswitch from the right shell. MICROSWITCH / 509-5080 Remove the soldering and detach the microswitch. 5. 6. Remove the Change Button from the right shell. 7. Remove the spring from the right shell. 38 8. Remove 1 screw and detach the microswitch (with SW bracket attached) from the right shell. SCREW (1) / M3 x 8, W/flat & spring washers 9. Disconnect the microswitch wire connector. 10. SCREW (2) / M2 x 10, W/flat & spring washers 39 11. Remove the soldering and extract the microswitch. 12. 13. Solder in the new microswitch and reassemble the Gun Controller. Test the trigger (or Weapon Change Button) to make sure that the new microswitch functions properly. 40 3. 14. 2. 2. REPLACING THE SENSOR UNIT 1. Follow instructions (1) ­ (3) of "Replacing the Microswitch" to remove the left shell. GAMEBOARD · Turn off the mains power and remove the power cord before opening the machine. [. . . ] SAFETY M5X30 MSCR TH BLK M5 WSHR 20OD FLT BLK M4X16 MSCR TH CRM Component Reference NEXT TO AC UNIT NEAR AC, CCT ON MAIN LID (2)-4 (2)-4 (8)-4 83 8. 2. VCT-0500UK - ASSY PTV Item 1 2 4 5 6 101 201 203 204 205 206 Component Part SPX-0530UK VCT-0511UK HOD-1101 SPX-0532UK SPX-0533UK 200-5788-31 000-T00520-0B 000-T00525-0B 068-552016-0B 000-P00516-W 000-F00414 Qty. 1 2 2 1 2 1 4 2 2 4 4 Description ASSY MASK STICKER PTV SIDE PTV HOLDER PROTECT SCREEN PTV RETAINING BRKT HORIZ PTV PROJECTION DSPL T 50TYPE 31K M5X20 MSCR TH BLK M5X25 MSCR TH BLK M5 WSHR 20OD FLT BLK M5X16 MSCR PAN W/FS PAS M4X14 MSCR CSK PAS Component Reference (101)-1 (5)-2 (1)-4 (1)-2 (1)-2 (4)-4 (1)-4 84 8. 3. VCT-0520UK - ASSY BILLBOARD DX 85 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 102 103 104 105 106 201 202 203 204 205 206 207 208 209 210 301 302 303 304 305 306 Component Part VCT-0521UK VCT-0522UK VCT-0523UK VCT-0524UK VCT-0525UK VCT-0526 VCT-0527 VCT-0528UK VCT-0529UK VCT-0530 VCT-0531UK 253-5460-1 LB1102 LB1104 390-5695-40CUK 390-5695-40DUK 280-5009-01 838-14281-02 280-5247 280-5248-10 838-14371 000-T00408-0B 068-441616-0B 068-552016-0B FAS-290034 050-C00500-3B 000-P00320-W 050-F00400 030-000616-SB 068-652016-0B 000-P00430-W NCR-60420UK VCT-60002UK VCT-60004UK VCT-60014UK VCT-60015UK VCT-60016UK Qty 1 1 2 1 1 1 1 1 1 2 1 1 1 1 1 1 8 2 6 6 1 11 4 14 14 14 10 8 8 8 2 1 1 1 1 1 1 Description BILLBOARD BOX BILLBOARD SASH BILLBOARD LID BD BASE BILLBOARD PLATE VCT BILLBOARD PLATE L VCT BILLBOARD PLATE R VCT PLATE HOLDER L PLATE HOLDER R LED BD HOLDER STICKER BILLBOARD VCT AIR VENT BLACK STICKER DANGEROUS VOLTAGE STICKER CAUTION, HOT SURFACE FL TRAY 110V 40W (T12) FL TUBE 40W 600L 1. 5" DIA CORD CLAMP 21 LED BAR BD RGB ONE TOUCH BUSHING ONE TOUCH COLLAR M3 L=10 OUTPUT CONTROL BD FOR JVS M4X8 M SCR TH BLK FLT WSHR BLK 4. 4-16X16 FLT WSHR BLK 5. 5-20X1. 6 HEX SKT LH CAP SCR STN M5X15 CAP NUT TYPE3 BLK M5 M SCR PH W/FS M3X20 FLG NUT M4 HEX BLT W/WS BLK M6X16 FLT WSHR BLK 6. 5-20X 1. 6 M4X30 MSCR PAN W/F WIRE HARN FL WH-PWR BILLBOARD WH-BILLBOARD PWR EXT WH-BILLBOARD PWR EXT 2 WH-BILLBOARD LED WH-BILLBOARD PWR Component Reference KD PART KD PART ARTWORK UK (12)-4, (3)-4, (2)-3 (3)-4 (8)-7, (9)-7 (8)-7, (9)-7 (8)-7, (9)-7 (4)-4, (10)-6 (4)-4, (10)-4 (8)-4, (9)-4 (8)-4, (9)-4 (15)-2 86 8. 4. SPX-0530UK ASSY MASK ITEM 1 2 101 201 202 203 301 302 303 304 PART NUMBER HOD-1151 JPT-1082 838-13145-02 050-U00300 068-330808-PN 050-F00400 SPY-60024 SPY-60025 SPY-60026 600-9120-44K QTY 1 10 10 20 20 1 7 2 1 1 DESCRIPTION MASK BASE IR COVER LED BD GUN SENSE HOD M3 NUT NYLOK PAS M3 WSHR 8OD FLT NYLON M4 NUT FLG SER PAS WIRE HARN MASK SHORT WIRE HARN MASK LONG WIRE HARN MASK INTO WIRE HARN EARTH 1200MM M4/M4 COMPONENT REF (101)-20 (101)-20 EARTH-1 MASK TO AC BRKT 87 8. 5. VCT-1000UK ASSY PTV CABI DX 88 Item 1 2 3 4 5 6 9 11 12 13 14 15 26 27 28 29 30 31 101 102 201 203 206 207 208 209 210 211 212 213 301 Component Part VCT-1002UK HOD-1020UK VCT-1060UK VCT-1070UK VCT-4000UK HOD-1070UK SPX-1010UK HOD-1003 VCT-1530UK 253-5460-01 253-5396-91 VCT-4100UK HOD-1007 HOD-1008 VCT-1008UK VCT-1009UK 839-1221 839-176-01 354081 280-A00964-WX 000-T00420-0B 000-P00420-W 000-P00425-W 050-F00400 068-441616-0B 000-P00430-W 030-000840-SB 068-852216-0B 032-000530 068-551616 SPY-60011UK Qty 1 1 1 1 1 2 2 1 1 2 2 1 1 1 1 1 1 1 5 12 22 2 2 2 8 4 8 4 2 2 1 Description PTV CABINET ASSY AC UNIT UK ASSY LID UPPER ASSY LID LOWER ASSY MAIN BD DX ASSY SPEAKER UK SPEAKER COVER LOCKING BRKT HOD FAN UNIT DC UK AIR VENT BLACK CABINET HANDLE ASSY PWR SPLY JOINT BRKT R JOINT BRKT L STICKER CABI TOP L STICKER CABI TOP R RGB LED DECODER BD CONN BD JVS TWIST LOK BHKL-450-4 ROUTER TWIST D09 SO6. 4 WOOD X M4X20 MSCR TH BLK M4X20 MSCR PAN W/FS PAS M4X25 MSCR PAN W/FS PAS M4 NUT FLG SER PAS M4 WSHR 16OD FLT BLK M4X30 MSCR PAN W/FS PAS M8X40 BLT W/S BLK M8 WSHR 22OD FLT BLK M5X30 BLT WING PAS M5 WSHR 16OD FLT PAS WIRE HARN TOWER EXT 1 Component Reference (2)-4, (3)-2, (13)-8, (6)-8 (4)-2 (11)-2 (11)-2 (11)-2, (15)-4, (5)-2 (15)-4 (26, 27)-4 (26, 27)-4 (5)-2 (5)-2 89 8. 6. HOD-1020UK ASSY AC UNIT INDENT 1 3 102 104 105 106 107 109 201 202 203 301 302 303 PART NO. HOD-1021UK LB1096 EP1379 SW1109 EP1302 514-5078-5000 310-5029-D508 421-6595-5000-T 000-P00308 060-F00300 050-F00400 600-6911-049UK 600-7118-002UK 600-9040-45U QTY 1 1 1 1 1 1 0. 04 1 4 4 2 1 1 DESCRIPTION AC BRKT UK STICKER PROTECTIVE EARTH FILTER EMI 10A ARCOTRONICS SWITCH ROCKER 250V AC EUROSOCKET FUSED 1OA 250Vac FUSE 5X20 CERAMIC SB 5000mA HEAT SHRINK SLEEVING 50. 8DIA STICKER FUSE 5000mA TYPE T M3X8 MSCR POSI PAN PAS M3 WSHR FORM A FLT PAS M4 NUT FLG WIRE HARN AC BRKT (JPT) WIRE HARN AC OUT (PRIMARY) 1 WIRE HARN EARTH 400mm M4/M5 COMPONENT REF (EARTH STUD) (102)-4 (102)-4 EARTH STUD AC BRKT - XFMR 90 8. 7. VCT-1060UK ASSY LID UPPER Item 1 2 3 101 Component Part HOD-1051-A VCT-1061UK TH1015UK 220-5575UK Qty. 1 1 1 1 Description FRONT LID U BLANK STICKER LID UPPER LOCKING TONGUE UK LOCK Component Reference 91 8. 8. VCT-1070UK ASSY LID LOWER Item 1 2 201 202 Component Part HOD-1061-AUK HOD-1062-A 050-F00400 060-F00400-0B Qty. [. . . ]