User manual SEGA MAZE OF THE KING DELUXE

[. . . ] 420-6702-01UK REV 0 SERVICE MANUAL DELUXE TYPE Before using this product, read this SERVICE MANUAL carefully to understand the contents stated herein. After reading this manual, be sure to keep it available nearby the product or somewhere convenient in order to be able to refer to it whenever necessary. Manufactured in the UK by CONTENTS BEFORE USING THIS PRODUCT. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 INSPECTIONS IMMEDIATELY AFTER TRANSPORTING THE PRODUCT TO THE LOCATION . . 2 2. INTRODUCTION TO THIS SERVICE MANUAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 3. [. . . ] Refer to the relevant Monitor manual supplied to reference these fuses. 22 3. 10. REPLACEMENT OF FLUORESCENT LAMP AND OTHER LAMPS · Never touch places other than those specified. Touching places other than those specified can cause electric shock and short circuit. Disconnect the machine from the supply before attempting the replacement of any lamp. · Only QUALIFIED SERVICE PERSONNEL should replace lamps. 3. 10. 1. FLUORESCENT LAMP REPLACEMENT 1. Remove Pop Panel (if fitted) and associated bracket by removing 3 x M4 Truss Screws. 2. Then withdraw the Lamp from the two clips, using care to avoid breakage. Replacement of Lamp is in reverse order of removal. 23 3. 10. 2. LAMP REPLACEMENT 1. Remove the control panel cover as shown by removing the 8 screws holding it in position. Carefully lift the control panel cover up until it is possible to disconnect the wire harness plugs attaching the start switches to the cabinet. Turn the control panel cover over and remove the micro switch from the start switch as shown below. TROUBLESHOOTING · Only QUALIFIED SERVICE PERSONNEL should carry out these procedures. If a problem occurs, first check the wiring connections. PROBLEMS When the main switch is turned ON, the machine is not activated CAUSE The power is not ON. COUNTERMEASURES Firmly insert the plug into the outlet. Incorrect power source/voltage. fuse) was activated due to an instantaneous overcurrent. Make sure that the power supply/voltage are correct. First, remove the cause of overcurrent and reinstate the circuit protection device to its original status. Then identify the cause of the fault on the item that caused the overcurrent & fix. The colour image on the screen is incorrect The on-screen image of the monitor sways and/or shrinks Sound is not emitted Incorrect monitor adjustment. Make appropriate adjustments. Connector connection is incorrect Make sure that the power supply and voltage are correct. Check connector connection from Base to Speaker Adjust the gun sighting alignment. SEE SECTION 3. 10 Check connector connections in the billboard case. Controller operation is not satisfactory Sighting is inaccurate due to environmental conditions, etc. Micro-switch malfunctioning Sensor BD is malfunctioning The fluorescent lamp does not light up Fluorescent lamp needs replacement The connector is disconnected 25 3. 12. CONTROLLER · Only QUALIFIED SERVICE PERSONNEL should carry out these procedures. In cases where the controller's operation is not satisfactory or the controller sight deviates from the direction in which it is pointed, the controller's interior parts may have been damaged. Replace the parts by disassembling the controller by the following procedure. [. . . ] For Germany (DM), France (Fr) & Switzerland (SFr), use the appropriate existing setting shown above (from another country) that matches the coin ratios programmed into your coin mech. Set SW 3 on the VTS /Excel board as shown in the table above corresponding to the country required. Rev 1Updated:- 23/11/01 65 6. 1. 1. PRICE OF PLAY SETTINGS UK Price Bonus 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 10p No Bonus 10p 6 = 50p 20p No Bonus 20p 3 = 50p 30p No Bonus 30p 1. 66 = 50p 30p 2 = 50p 30p AMLD * 40p No Bonus 40p 1. 25 = 50p 50p No Bonus 50p 50p 60p No Bonus 60p 80p No Bonus 80p 1. 25 = £1 £1 No Bonus £1 £1 £1. 50 No Bonus £1. 50 £2 No Bonus £2 £3 No Bonus £3 £5 No Bonus £5 £7. 50 No Bonus £7. 50 £10 No Bonus Free Play DIL Switch 1 6 = £1 4 = £1 4 = £1 3 = £1 3 = £1 3 = £1 2 = £1 2 = £1 2 = £1. 50 3 = £2 2 = £2 2 = £2 12 =£2 8 = £2 6 = £2 6 = £2 6 = £2 5 = £2 4 = £2 2. 5 = £2 5 = £4 Switch 1 Switch 2 Switch 3 Switch 4 Switch 5 OFF OFF OFF OFF OFF OFF OFF OFF OFF ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF ON ON ON OFF ON ON ON ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF OFF ON ON ON OFF 3 = £5 2 = £5 3 = £10 2 = £10 OFF ON OFF ON ON OFF OFF ON ON ON OFF OFF OFF OFF OFF OFF OFF ON OFF ON OFF ON ON OFF ON OFF ON OFF ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON Rev 1Updated:- 23/11/01 66 6. 1. 2. PRICE OF PLAY SETTINGS EURO Price Bonus DIL Switch 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 10¢ No Bonus 10¢ 6 = 50¢ 20¢ No Bonus 20¢ 3 = 50¢ 30¢ No Bonus 30¢ 1. 66 = 50¢ 30¢ 2 = 50¢ 30¢ AMLD * 40¢ No Bonus 40¢ 1. 25 = 50¢ 50¢ No Bonus 50¢ 50¢ 60¢ No Bonus 60¢ 80¢ No Bonus 80¢ 1. 25 = £1 1 No Bonus 1 1 1. 50 No Bonus 1. 50 2 No Bonus 2 3 No Bonus 3 5 No Bonus 5 7. 50 No Bonus 7. 50 10 No Bonus Free Play Switch 1 Switch 2 Switch 3 Switch 4 Switch 5 OFF OFF OFF OFF OFF OFF OFF OFF OFF ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF ON ON ON OFF ON ON ON ON OFF OFF OFF OFF ON OFF OFF OFF ON ON OFF OFF OFF ON ON OFF OFF ON ON ON OFF OFF OFF ON ON 6 = 1 4 = 1 4 = 1 3 = 1 3 = 1 3 = 1 2 = 1 2 = 1 2 = 1. 50 3 = 2 2 = 2 2 = 2 12 =2 8 = 2 6 = 2 6 = 2 6 = 2 5 = 2 4 = 2 2. 5 = 2 5 = 4 ON OFF 3 = 5 2 = 5 3 = 10 2 = 10 OFF ON OFF ON ON OFF OFF ON ON ON OFF OFF OFF OFF OFF OFF OFF ON OFF ON OFF ON ON OFF ON OFF ON OFF ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON ON 67 6. 1. 3. [. . . ]