User manual SEGA INITIAL D3 TWIN

[. . . ] 420-6799-02UK REV 0 SERVICE MANUAL TWIN TYPE Before using this product, read this SERVICE MANUAL carefully to understand the contents stated herein. After reading this manual, be sure to keep it available nearby the product or somewhere convenient in order to be able to refer to it whenever necessary. Manufactured in the UK by CONTENTS 1. 1. 1. BEFORE USING THIS PRODUCT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 INSPECTIONS IMMEDIATELY AFTER TRANSPORTING THE PRODUCT TO THE LOCATION . . . . . . . . . 3. 7. INTRODUCTION TO THIS SERVICE MANUAL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 INSTALLATION AND SERVICE INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 HANDLING AND INSTALLATION PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] This message is displayed when various operations fail because of dirty rollers or heads. 48 Continued from previous page ERROR DISPLAY There is a problem with the card reader/writer. Check the card reader/writer is connected properly, turn off the power and start again. Check that the card reader/writer is connected properly, turn off the power and start again. CAUSE This message is displayed when there is a problem with the Card Reader/Writer and it sends improper signals. This message is displayed at powerup during advertisements when the Card Reader/Writer is not connected properly or when it is broken and unresponsive. This message is displayed when a communication error occurs between the Card Reader/Writer and the game board. This message is displayed when various operations fail because of dirty rollers or heads. COUNTERMEASURES Verify there are no problems with the shutter and that the top cover is closed and then restart the unit. (See 3. 9. 2) Verify that the Card Reader/Writer is connected properly and then restart the unit. (See Schematic Section 9. 2) Verify that the Card Reader/Writer is connected properly and then restart the unit. (See Schematic Section 9. 2) If this error occurs several times, check the immediate area for sources of possible interference. Leave the card in place and press the Start button and Change View button to retry the operation. Remove the card and press the Start button and Change View button at the same time to restore or end the game (refer to 3. 9. 2). If this error occurs several times, use Test Mode to perform manual cleaning. (See Section 5. 3. 8) Press the Start button and Change View button at the same time after removing the card or correcting the problem to restore the game. (See 3. 9. 2) This message is displayed when a card jam is suspected when there should be no card in the Card. 49 The following error messages are displayed when problems are detected during unit power-up (during initialization of the Card Reader/Writer). Perform the appropriate maintenance based on the content of the error message displayed. CAUSE This message is displayed at power-up when the Card Reader/Writer is not connected properly or when it is broken and unresponsive. This message is displayed when the conditions prompting an automatic Card Reader/Writer cleaning are met. PLEASE WAIT This message is displayed during network setup while the other unit is being initialized. CAN'T EJECT This message is displayed at power-up when, after attempting to do so, the Card Reader/Writer is unable to eject a card for some reason. This message is displayed at power-up when the shutter cannot be opened/closed properly. [. . . ] TOF-4501UK 840-0091D-12 APC-4002 105-5435 LB1111 610-0617 610-0624-0033 253-5508-0384 400-5397-01 400-5421-07512 OS1071 354081 354083 280-A00964-WX LB1101 000-P00416-W 012-P03516 012-P00410-F 000-P00408-W TOF-60002UK TOF-60003UK TOF-60004UK TOF-60005UK TOF-60006UK 600-7247-500 QTY 1 1 1 1 1 1 1 1 1 1 1 4 4 6 1 11 4 4 4 1 1 1 1 1 1 DESCRIPTION MAIN BD BASE ASSY CASE NAT RT/232C &COM EXP SW REG BRKT GD DRIVE BRKT STD STICKER PLEASE RECYCLE GD-ROM DRIVE UNIT NAOMI GD SOFT KIT TOS ENG KEY CHIP SW REGU FOR JVS VA SW REGU LCA75S-12 FEET P. C. B PKT OF 4 TWIST LOK BHKL-450-4 (A)TWIST N LOK BHKL-750-4 ROUTER TWIST D09 SO6. 4 WOOD X STICKER WARNING BATTERY M4X16 MSCR PAN W/FS PAS N6X5/8" S/TAP PAN PAS N8X3/8" S/TAP FLG PAS M4X8 MSCR PAN W/FS PAS WH MAIN BD AC WH JVS PWR 6P W/CARD WH JVS PWR 8P W/GD WH MAIN BD I/O PWR WH MAIN BD SOUND CABLE SCSI ST-L TYPE2 500MM 125 COMPONENT REF. (102)-4 FEET GAME BD (2)-4, (4)-3, (3)-4 (102)-4 (6)-4 (101)-4 8. 15. TOT-4600UK ASSY ELEC BD ITEM PART NO. QTY DESCRIPTION COMPONENT REF. 1 3 102 103 104 105 107 108 109 201 203 206 301 302 303 306 307 308 309 310 311 312 313 314 315 316 317 318 TOF-4601UK 837-13551-92 560-5394UK 838-13578 838-14174 838-11856CE-02 354081 354083 280-A00964-WX 012-P00325 000-P00416-W 068-441616 600-7141-100 600-6985-006UK FRI-61003UK TOF-60104UK NCR-61002UK NCR-61003UK NCR-61004UK TOF-60001UK TOF-60007UK TOF-60008UK TOF-60009UK TOF-60105UK POD-61057UK FRI-61030UK TOF-60011UK 440036 1 1 1 1 1 1 11 10 12 14 4 4 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 WOODEN BASE ELEC I/O CONTROL BD FOR JVS TRANSFORMER DUT TW PWR AMP 2CH & MIXER SERVO MOTOR DRIVE BD MIDI CONNECT BD W/FUSE 6. 3A CE TWIST LOK BHKL-450-4 (A)TWIST N LOK BHKL-750-4 ROUTER TWIST D09 SO6. 4 WOOD X N4X1" S/TAP PAN PAS M4X16 MSCR PH W/FS M4 WSHR 16OD FLT PAS CABLE JVS TYPE A-B 100CM WIRE HARN 100V OUT WIRE HARN CONN BD B PWR AMP 14V AC IN WH AMP VR WH AMP AUDIO WH AMP SP F WH CONN BD OUT A WH MIDI WH ELEC BD I/O PWR WH I/O BD WH I/O BRD A/D WH EARTH AC UNIT WIRE HARN EXT MOTOR A WH EXT ENCODER A FERRITE 74271221 (3)-4, (103)-4, (104)-4, (105)-2 (102)-4 (102)-4 126 8. 16. TOS-10001UK ASSY COCKPIT 1P ITEM 1 2 3 4 5 6 7 8 9 10 12 14 15 17 18 19 20 PART NO. ORT-1120UK FZR-1550UK FZR-1555UK TOF-2000XUK POD-1023UK TOT-1200UK POD-1021UK DUT-1008UK POD-1022 SPG-1005 TOS-1600UK TOS-4500UK TOT-4600UK FRI-1510UK RAL-2007 RAL-2008 TOF-1502UK QTY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 DESCRIPTION ASSY SUB MAIN BASE ASSY MONITOR COVER L 2P ASSY MONITOR COVER R 2P ASSY CONTROL PANEL MONITOR STAND ASSY PEDAL BASE TOT MONITOR SUPPORT ROOF LID DUT MONITOR MASK MASK HOLDER ASSY SEAT TWIN 1P ASSY MAIN BD ASSY ELEC BD ASSY BASE LID R RUBBER HOLDER R TWIN RUBBER HOLDER L TWIN STICKER BASE L (12)-1 (12)-1 COMPONENT REF. Continued on next page 127 Continued from previous page ITEM 21 22 23 24 25 26 27 30 31 33 101 105 106 107 108 109 110 111 112 113 114 115 116 117 201 202 203 204 205 206 207 208 209 210 211 212 213 214 215 216 217 218 219 220 221 PART NO. TOF-1503UK TOS-1504UK POD-1026UK DUT-2031UK SRT-1009UK SRT-2031UK OS1004 440-WS00220UK 421-8075-81 421-11409-12 200-5949 280-5112 280-5113 068-652516 280-L00716-OS 601-6231-C100 601-6231-D100 260-0011-02 440-WS0220UK FN1012 OS1195 280-A00900-A 280-A00748-PM 280-A02048-PM 030-000840-SB 008-B00825-0B 060-S00800-0B 060-F00800-0B 030-000850-SB 068-852216-0B 030-000616-SB 068-651616-0B 000-P00408-WB 000-T00530-0B 000-T00512-0B 068-552016-0B 000-F00512 030-000820-SB 032-000425 068-441616 008-T00512-0B 050-F00600 000-P00320 012-HB0512 060-F00500 QTY 1 1 4 1 1 0. 9 0. 705 1 1 1 1 4 4 4 3 2 2 1 1 2 8 20 4 12 12 4 4 16 8 12 6 6 6 2 3 5 4 4 4 4 4 4 3 8 8 DESCRIPTION STICKER BASE R STICKER BASE LID CRT SPACER (POD) FRONT FLOOR UK DUT MONITOR SPASHGUARD SRT TW NEOPRENE RUBBER STRIP 10X3mm DRAFT EXCLDR 4 X7MM BLK x 10M WARNING STICKER TRAP HAZARD JASRAC STICKER TOT STICKER JASRAC V TOT ASSY CLR DSPL 29 TYPE 31K UK BUSH FOR TV COLLAR FOR TV M6 WSHR 25OD FLT PAS STANDOFF 7OD 4ID 16L EDGING NEW TYPE EDGING NEW TYPE AXIAL FLOW FAN AC100V 50-60Hz WARNING STICKER TRAP HAZARD MESH GUARD METAL 120mm FAN RIVET SNAP MOSS SR1811 ROUTER TWIST D9 ADH ROUTER TWIST D7 SO4. 8PA ROUTER TWIST D20 SO4. 8PA M8X40 BLT W/S BLK M8X30 TMP PRF BH BLK M8 WSHR SPR BLK M8 WSHR FORM A FLT BLK M8X50 BLT W/S BLK M8 WSHR 22OD FLT BLK M6X16 BLT W/S BLK M6 WSHR 16OD FLT BLK M4X8 MSCR PAN W/FS BLK M5X30 MSCR TH BLK M5X12 MSCR TH BLK M5 WSHR 20OD FLT BLK M5X12 MSCR CSK PAS M8X20 BLT W/S BLK M4X25 W/BLT PAS M4 WSHR 16OD FLT PAS M5X12 TMP PRF TH BLK M6 NUT FLG SER PAS M3X20 MSCR PAN PAS N10X1/2" S/TAP HEX B PAS M5 WSHR FORM A FLT PAS (101)-4 (101)-4 (101)-4 (17)-1 (5)-2, (7)-2 COMPONENT REF. FIX DOWN AT NEXT LEVEL UP FIX TO (10) (24)-0. 5, (1)-0. 4 4X10cm STRIPS (9)-705mm ON FRONT LIP (101)-3 REMOTE BD TOP OF WIRE COVER -2 INSIDE OF PEDAL BASE -2 NEXT TO STEERING GEARS (111)-2 (113)-8 MONITOR STAND HORIZONTAL BAR WIRE COVER BOX 2X4 CORNER DROP (2)-4, (3)-4, (7)-4 (4)-4 (4)-4 (2)-4, (3)-4, (4)-4, (7)-4 (5)-8 (5)-8, (12)-4 (6)-6 (6)-6 (8)-4, (6)-2 (9)-2 (9)-3 (9)-5 (10)-4 (12)-4 (14)-2, (15)-2 (14)-2, (15)-2 (17)-4 (101)-4 (101)-3 REMOTE BD (111)-8 (111)-8 Continued on next page 128 Continued from previous page ITEM 301 304 306 307 308 309 310 312 313 314 315 316 317 318 319 320 321 322 323 324 325 326 PART NO. TOF-60100UK NCR-61034UK 600-6373-77-91 TOF-60101UK FRI-61042UK NCR-61011UK 600-7009-2500 FRI-61041UK FRI-61027UK TOF-60021UK TOF-60052UK POD-61012UK TOF-60015UK NCR-61008UK POD-61026UK TOF-60103UK TOF-60010UK 600-6275-0150 600-9020-44K 600-9100-44K 600-9020-44K 600-9060-46K QTY 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 2 1 2 1 1 DESCRIPTION WH EXT VIEW BUTTON A WIRE HARN EXT COIN WIRE HARNESS PLAYER SEL EXT B WH EXT FRONT SP B WIRE HARN EXT VR B WIRE HARN VIEW BUTTON B ASSY RGB CA D-SUB 15P 2500MM WIRE HARN EXT MOTOR B WIRE HARN EXT AC100V A WH EXT AC100V B WH EARTH FOR DRIVER MAIN BASE WIRE HARN 100V EXT COCKPIT WH EXT ENCODER B WH EXT FRONT SP A WIRE HARN EXT AC UNIT WH VTS EXT WH EXT CARD R/W A ASSY FIBER OPTIC 5 0150CM WIRE HARN EARTH 200mm M4/M4 K WIRE HARN EARTH 1000mm M4/M4 K WIRE HARN EARTH 200mm M4/M4 K WIRE HARN EARTH 600mm M4/M6 K COMPONENT REF. MON STAND TO WIRE COVER BOX MON STAND TO MON SUPPORT & C. PNL MON SUPPORT TO ROOF LID MON STAND TO LH BOT OF 101 129 8. 17. APC-1561 130-5156 000-P00512-W QTY 1 1 2 DESCRIPTION SPEAKER BRKT SPEAKER BOX 8OHM 20W M SCR PH W/FS M5X12 COMPONENT REF. [. . . ]