User manual SEGA CASH CUBE SHOOTOUT POOL PRIZE

[. . . ] RND-0049 REV 1 SERVICE MANUAL CASH CUBE Before using this product, read this SERVICE MANUAL carefully to understand the contents stated herein. After reading this manual, be sure to keep it available nearby the product or somewhere convenient in order to be able to refer to it whenever necessary. Manufactured in the UK by CONTENTS BEFORE USING THIS PRODUCT . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 INSPECTIONS IMMEDIATELY AFTER TRANSPORTING THE PRODUCT TO THE LOCATION 4 2. [. . . ] Detach the metalwork surrounding the hopper by removing the 2 screws and 3 nuts that hold it in place. Rotating the disc manually first anti-clockwise then clockwise to free the coin. Do not return damaged coins to bowl. OR Remove any debris from the disc bed assembly. Hopper over-current protective device tripped (Wait 30 seconds while supply off). Over payout of coins 1. Poor connection (check common return wires) to hopper. 25 Dismantling the Hopper 1. Slide the bowl forward until the locating lugs, at the front of the bowl, are clear of the slots in the base. Connect the cable to the motor assembly, ensuring that the 4-pin connector is the correct way round. Lower the motor assembly into the base, ensuring that the coin exit is in the rear exit position. Locate the lugs, on the front of the bowl, into the slots at the front of the base. Gently press down until the securing clips, on the base, click into the slots in the bowl. Routine cleaning: All accessible parts of the coin route should be cleaned periodically using a mild detergent on a damp cloth. Particular attention should be paid to the opto sensor at the coin exit to remove any build up of dirt. 26 3. 12. COIN MECHANISMS The machine uses a Coin Controls SR5 Coin Mechanism. 3. 12. 1. COIN MECHANISM OPERATION (FOR UK MACHINES). COINS ACCEPTED: 5P, 10P, 20P, 50P, £1, £2 COIN ROUTING The coin mech automatically routes all coins other than £1 coins to the cash box (exit C). £1 coins are routed to the hopper (exit A) until the float is achieved, afterwards they are diverted to the cash box (exit B). The float is maintained by software counting the number of £1 coins entered. The coin mech exits are as follows: A Hopper B Cash Box C Cash Box D Not Used. SR5 ­ COIN CONTROL ROUTING PLUG: 18 WAY Pt No PUB-64101UK 5-7, 8-15, 1à13, 10à13, 12à13, 16à13, 17à13, 18à13 The diode direction is shown as `à'. Note: Cash Payout - £1 Hopper only fitted. 3. 12. 2. COIN MECHANISM FAULT FINDING There is a green diagnostic LED used to provide a visual indication of the mechanisms current operation and error condition. LED ON = Power ON LED OFF = Power OFF LED will flash OFF once when Coins or Tokens are accepted or if reject Lever is pressed. LED will flash OFF three times if validator or machine has inhibited Coin or Token. LED will flash continuously when in Token Teaching Mode. For further information on the operation of the coin mechanism, please refer to the Money Controls website: www. moneycontrols. com/support/ 27 3. 13. Touching places other than those specified can cause electric shock and short circuit. Disconnect the machine from the supply before attempting the replacement of any fuse. · Only QUALIFIED SERVICE PERSONNEL should replace FUSES. · Only replace fuses with ones of the same value and type. There are a number of fuses used on this machine to protect the user and the machine from damage. [. . . ] ] * [ 9M30S - 9M59S ] * [ OVER -10M00S ] * 0 0 0 0 0 PRESS TEST BUTTON TO EXIT ---------------------------------------------------TIME HISTOGRAM shows the number of plays and the respective play times. The asterisk (*) indicates the distribution state. Income-related data (1 of 2) is displayed on the following screen. 69 <For POUND, DOLLAR, EURO, or ANY CASH Settings> ---------------------------------------------------BOOKKEEPING 4/* - INCOME DATA (1/2) PLAYED GAMES BET WIN P/O SETUP PAYOUT RATIO DIFFERENCE FROM SETUP AVERAGE BET AVERAGE WIN = = = = 0 0. 00 0. 00 0. 00% = * [%] = ± * [%] = 0. 00 = 0. 00 PRESS TEST BUTTON TO CONTINUE ---------------------------------------------------<For TOKEN Setting> ---------------------------------------------------BOOKKEEPING 4/* - INCOME DATA (1/2) PLAYED GAMES BET WIN P/O =0 =0 =0 = 0. 00% = * [%] = ± * [%] = 0. 00 = 0. 00 SETUP PAYOUT RATIO DIFFERENCE FROM SETUP AVERAGE BET AVERAGE WIN PRESS TEST BUTTON TO CONTINUE ---------------------------------------------------PLAYED GAMES: TOTAL BET: TOTAL WIN: P/O: SETUP PAYOUT RATIO: DIFFERENCE FROM SETUP: AVERAGE BET: AVERAGE WIN: Total number of games played. Payout ratio deviation (between set ratio and the actual resulting ratio). Average number of coins per win. 70 Income related data is displayed on the second screen. [. . . ]