User manual MAYTAG HRE21250PC

[. . . ] Series Twelve PC INTELLIGENT ELECTRIC WATER HEATER USER'S GUIDE Model Numbers HRE21250PC HRE21282PC FOR POTABLE WATER HEATING ONLY GAMA certification applies to all residential electric water heaters with capacities of 20 to 120 Gallons. Input rating of 12 Kw or less at a voltage no greater than 250 V. NOT SUITABLE FOR SPACE HEATING Caution: Read and Follow All Safety Rules and Operating Instructions Before First Use of This Product. Part No. 66001714 184744-000 WARNING READ THE GENERAL SAFETY SECTION BEGINNING ON INSIDE COVER AND THEN THIS ENTIRE MANUAL BEFORE INSTALLING OR OPERATING THIS WATER HEATER. 0104 Safety Instructions WARNING Improper installation, adjustment, alteration, service or maintenance can cause DEATH, SERIOUS BODILY INJURY, OR PROPERTY DAMAGE. [. . . ] Connector will install in one direction only as shown. WALL ANCHORS BACK OF THERMOSTAT ORANGE/WHITE THERMOSTAT CABLE BLUE BLUE/WHITE GREEN TERMINAL CONNECTOR MOUNTING SCREWS ORANGE GREEN/WHITE 30. Strip the ends 1/4 inch on each of the six colored wires. . 250 ORANGE/WHITE GREEN/WHITE BLUE/WHITE 33. Place thermostat over wall plate, press firmly, and thermostat will snap into place on the wall plate. ORANGE GREEN BLUE 1. 250 31. Using the terminal connector removed in Step 12, insert the six colored insulated wires in the remote thermostat cable into the numbered slots in the terminal connector and tighten each screw to secure each wire. Be sure to arrange wires in exact color sequence as shown. 6-WIRE CABLE ORANGE/WHITE ORANGE GREEN/WHITE GREEN BLUE/WHITE BLUE 34. Turn "ON" electric power to water heater. 6 54 321 TERMINAL CONNECTOR TERMINAL CONNECTOR THERMOSTAT CABLE 35. Read Temperature Regulation Warning and Temperature Settings, then proceed to Programming the Thermostat. 21 Instructions for Installation (cont'd) Installation Checklist 1. Whether or not the element conversion is made, the model rating plate must be marked. Using a hard point ink pen, check the appropriate block within the model rating plate, which is located adjacent to the lower access panel. Is the fuse or circuit breaker size correct as shown in the chart in the "Product Specifications" section?Are the wires from the circuit breaker or fuse service to the water heater's junction box on the correct wire size (gauge) as shown in the chart in the "Product Specifications" section?Is the new temperature-pressure relief valve properly installed, and piped to an adequate drain?See "Temperature-Pressure Relief Valve" in the "Instructions for Installation" section. See "Filling the Water Heater" instructions in the "Instructions for Installation" section. See "Locating the New Water Heater" in the "Instructions for Installation" section. Are the cold and hot water lines connected to the water heater correctly?See "Water Piping" instructions in the "Instructions for Installation" section. If the programmable thermostat has been moved to a remote location, has the wiring been done correctly?Do you need to call your electric company to check your wiring? 6 AIR GAP HOT COLD HOT CONDUIT COLD TEMPERATUREPRESSURE RELIEF VALVE DISCHARGE PIPE (Do not cap or plug) FLOOR DRAIN MODEL RATING PLATE 22 Instructions for Operation Temperature Regulation WARNING HOTTER WATER CAN SCALD: Water heaters are intended to produce hot water. Water heated to a temperature which will satisfy clothes washing, dish washing, and other sanitizing needs can scald and permanently injure you upon contact. Some people are more likely to be permanently injured by hot water than others. [. . . ] DO NOT replace the water heater until a full inspection of all possible water sources is made and necessary corrective steps taken. Leakage from other appliances, water lines, or ground seepage should also be checked. 35 E G F H Notes 36 Repair Parts List MAYTAG ELECTRIC WATER HEATERS MAYTAG/STATE PART NUMBER CONVERSION KEY MAYTAG STATE 66001010 9002403 66001011 9001609 66001012 9001608 66001013 ETC2X 66001014 ETC5X 66001021 9001584 66001053 9000308 66001054 9000309 66001055 9001591 66001056 9002439 66001061 9002408 66001068 9001453 66001105 9002769 66001106 9000225 66001107 9000396 66001353 9003034 66001354 9003035 66001355 9003036 66001356 9003037 66001357 9003038 66001358 9003039 66001701 9003929 66001702 9003919 66001703 9003900 66001708 9003717 66001709 9003716 66001714 184744-000 66001727 9003928 66001739 9003935 66001745 9003936 66001746 9003932 66001747 9004001 37 Repair Parts List (cont'd) MAYTAG ELECTRIC WATER HEATERS MODEL NUMBERS HRE21250PC HRE21282PC 50 GALLON 80 GALLON NOTE: UPPER ELEMENT: These water heaters are equipped with 3800 watt elements. LOWER ELEMENT: These water heaters are equipped with factory installed convertible elements, which can be operated at 3800 watts or 5500 watts. [. . . ]