User manual HUSQVARNA LT 120

[. . . ] LT 1 2 0 Owner’s Manual SAFETY RULES Safe Operation Practices for Ride-On Mowers IMPORTANT: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROWING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. I. • • • • • • • • • • • • • • • GENERAL OPERATION Read, understand, and follow all instructions in the manual and on the machine before starting. Only allow responsible adults, who are familiar with the instructions, to operate the machine. Clear the area of objects such as rocks, toys, wire, etc. , which could be picked up and thrown by the blade. [. . . ] Replace belts if they begin to slip from wear. OIL FILL CAP/DIPSTICK TRANSAXLE COOLING Keep transaxle free from build-up of dirt and chaff which can restrict cooling. ENGINE LUBRICATION Only use high quality detergent oil rated with API service classification SF or SG. Select the oil’s SAE viscosity grade according to your expected operating temperature. SAE VISCOSITY GRADES SAE 30 5W-30 °F °C -20° -30° -20° 0° -10° 30° 32° 40° 0° 10° 60° 20° 80° 30° 100° 40° OIL DRAIN PLUG FIG. Clean the foam pre-cleaner after every 25 hours of operation or every season. Service paper cartridge every 100 hours of operation or every season, whichever occurs first. • Carefully remove cartridge to prevent debris from entering carburetor. • Reinstall cartridge, nut, precleaner, cover and secure with knob(s). IMPORTANT: PETROLEUM SOLVENTS, SUCH AS KEROSENE, ARE NOT TO BE USED TO CLEAN THE CARTRIDGE. DO NOT USE PRESSURIZED AIR TO CLEAN OR DRY CARTRIDGE. TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE NOTE: Although multi-viscosity oils (5W30, 10W30 etc. ) improve starting in cold weather, these multi-viscosity oils will result in increased oil consumption when used above 32°F. Check your engine oil level more frequently to avoid possible engine damage from running low on oil. Change the oil after the first two hours of operation and every 25 hours thereafter or at least once a year if the tractor is not used for 25 hours in one year. Check the crankcase oil level before starting the engine and after each eight (8) hours of operation. Tighten oil fill cap/dipstick securely each time you check the oil level. • After oil has drained completely, replace oil drain plug and tighten securely. For approximate capacity see “PRODUCT SPECIFICATIONS” on page 3 of this manual. Keep oil at “FULL” line on dipstick. 16 CUSTOMER RESPONSIBILITIES MUFFLER COVER KNOB CARTRIDGE NUT COVER Inspect and replace corroded muffler and spark arrester (if equipped) as it could create a fire hazard and/or damage. SPARK PLUGS PAPER CARTRIDGE FOAM PRE-CLEANER BASE Replace spark plugs at the beginning of each mowing season or after every 100 hours of operation, whichever occurs first. Spark plug type and gap setting are shown in “PRODUCT SPECIFICATIONS” on page 3 of this manual. IN-LINE FUEL FILTER (See Fig. If fuel filter becomes clogged, obstructing fuel flow to carburetor, replacement is required. • Place new fuel filter in position in fuel line with arrow pointing towards carburetor. • Be sure there are no fuel line leaks and clamps are properly positioned. 16) Air screen must be kept free of dirt and chaff to prevent engine damage from overheating. Clean with a wire brush or compressed air to remove dirt and stubborn dried gum fibers. ENGINE COOLING FINS (See Fig. 16) Remove any dust, dirt or oil from engine cooling fins to prevent engine damage from overheating. • Remove screws from blower housing and lift housing and dipstick tube assembly off engine. [. . . ] 954 1400-02 DECALS 3 9 4 2 10 20 1 8 7 6 5 14 KEY NO. 532 13 68-32 532 14 64-51 532 15 45-15 532 15 45-16 532 13 83-11 532 15 71-64 532 15 71-65 DESCRIPTION Decal V-Belt Schematic Decal Bat Dan/Psn Pad Footrest LH STLT Pad Footrest RH STLT Decal Handle Lft Height Adjust Manual Owner's (English) Manual Owner's (French) 532 14 08-37 Decal Saddle Parking 532 15 63-69 Decal Fender STLT Oper. English/French 532 15 13-20 Decal Hood LH 532 15 13-21 Decal Hood RH 532 27 24-40 Decal HP Engine 532 12 56-90 Decal 100 DBA 532 14 54-37 Decal Europe Stand CE 532 14 54-94 Decal Mower Cut/Finger 532 15 06-17 Decal Fender Husq 532 14 54-98 Decal Read Owner's Man Syms Available accessories not included with tractor: --MK380 C38 Mulcher Kit with Blades Grass Catcher WHEELS & TIRES 1 2 5, 8 4, 10 7 3, 9 6 11 KEY NO. 532 05 91-92 532 06 51-39 532 10 62-22 532 05 99-04 532 13 83-36 532 12 49-57 532 12 49-59 532 13 83-37 532 12 46-35 532 12 49-26 532 10 47-57 532 14 43-34 DESCRIPTION Cap Valve Tire Stem Valve Tire F Ts 15 X 6 0 - 6 Service Tube Front (Service Item Only) Rim Asm 6"front Silver Service Fitting Grease (Front Wheel Only) Bearing Flange (Front Wheel Only) Rim Asm 8"rear Silver Service Tire R Ts 18x8 5-8 C Service Tube Rear (Service Item Only) Cap Axle Blk 1 50 X 1 00 Sealant, Tire ( 10 oz. [. . . ]