User manual HEARTLAND APPLIANCES CLASSICGASRANGESMAN

[. . . ] (519) 650-5501 Fax (519) 650-3773 Toll Free Phone 1-800-361-1517 Toll Free Fax 1-800-327-5609 INSTALLATION AND OPERATING INSTRUCTIONS Save these instructions for future use Note: Please read these instructions thoroughly before attempting to install this unit. WARNING: Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. For assistance or additional information, consult a qualified installer, service agency, manufacturer (dealer) or the gas supplier. Model 7100 Note: This appliance can only be installed in the state of Massachusetts by a Massachusetts licensed plumber or gasfitter. The oven door thermometer does not sense temperature. It is for aesthestics only and is nonfunctional. ® CERTIFIED Model 9100 C US These symbols on the nameplate mean the product has been design certified by American Gas Association Laboratories and Canadian Gas Association Laboratories. Manual #7715 REV 111204 MODEL 9100/7100 GAS RANGE ATTENTION INSTALLER: Leave this manual with appliance © 2004 HEARTLAND APPLIANCES INC. Gas Models 9100/7100 CONSUMER WARRANTY ENTIRE PRODUCT ­ LIMITED ONE YEAR WARRANTY HEARTLAND warrants the replacement or repair of all parts, including gas components of this Cookstove which prove to be defective in material or workmanship, with the exception of the painted or porcelain enamel finish or plated surfaces, for one year from the date of original purchase. Such parts will be repaired or replaced at the option of Heartland without charge, subject to the terms and conditions set out below. [. . . ] H) Broiler - Broiler drawer located under the oven, glides open for easy access, for all your broiling needs. I) More Storage - (model 7100 only) lift and open the cast door to gain access to more storage area. J) Cabinet Door - the minute minder, exhaust fan control and overhead light switch are concealed behind the cabinet door. K) Three position switch - Controls high and low for exhaust fan centre position is "OFF". L) On -off switch - controls overhead light in exhaust hood. 12 Control Panel Layout Model 7100 Control Panel 0 The control panel is laid out in a straight line and each control is identified by a graphic on the right side of the knob. 6 1 Left Rear Burner Control(Medium) Model 9100 Control Panel 5 2 4 0 3 6 1 Left Front Burner Control (Large) 5 2 4 0 3 0 6 1 Centre Rear Burner Control (Medium) 6 1 5 2 4 0 3 5 2 4 0 3 Left Rear Burner Control(Medium) 6 1 Centre Front Burner Control (Medium) 6 1 5 2 4 0 3 5 2 Right Rear Burner Control(Medium) 4 0 3 6 1 Right Rear Burner Control(Medium) 6 1 5 2 4 0 3 5 2 Left Front Burner Control (Large) 4 0 3 6 1 Right Front Burner Control(Large)) 6 1 5 2 4 3 5 2 Right Front Burner Control(Medium) 4 F 200 95 3 C 2 50 1 20 Oven Control 30 0 1 45 35 0 17 0 Oven Control 50 40 0 20 5 2 65 45 0 23 5 The operation of the controls are described in the following pages. 13 OPERATION Top Burner Operation Lighting the Top Burners Your range is equipped with a spark ignition system that is electrically operated. You need only to push in and turn the knob to any position and the burner will light. Note: when lighting any one burner, all burners will spark, but only the burner that you have selected will light. All models feature "auto-reignition", which means if for any reason the flame goes out, it automatically begins to spark to re-ignite the burner!See page 16 for manual lighting procedure. 0 6 (HI) - Quick start for cooking, brings water to boil. 5 (MED HI) - Fast fry, pan broil, maintain fast boil on large amount of food. 6 4 (MED) - Saute and brown; maintain slow boil on large amount of food. 1 5 3 (MED LOW) - Cook after starting at MAX; cook with little water in covered pan. 2 4 3 2-1 (LOW) - Steam rice, cereal; maintain serving temperature of most foods. Top Burner Control For safety reasons, always adjust the burner controls so that flames do not extend beyond the edges of pots, pans or other cooking utensils. Large pots or other over-sized cooking utensils may cause random sparking from the burner. To avoid this condition lower the flame size or use smaller-sized cooking utensils. To avoid random sparking, please use the Heartland Griddle Pan Kit for Classic Ranges part #7602 (complete with griddle pan support) may be purchased from your dealer or directly from Heartland. Push in and hold down the oven knob and select the desired oven temperature. You must continue to keep oven knob depressed for 5-6 seconds after the oven ignition has occurred. The extra 5-6 seconds is to heat up the safety thermocouple to allow proper oven control. (releasing the knob too early will extinguish the flame) All units feature flame sensing auto shutoff, so if for any reason the flame goes out, the gas supply to the oven is shut off automatically!Please note: the first time the oven is used, the oven lighting procedure may have to be repeated 2-4 times to push out any air in the gas lines. Release oven knob, this will prevent any further gas from going into the oven. If you are still not successful see "trouble shooting guide". Range Thermostat The temperature in the oven is transmitted to the thermostat by the sensor tube located at the rear of the oven. It must always be in position on its mounting clips and should not be bent. The sensor causes the burner to maintain the desired oven temperature. F 0 C 2 00 95 250 120 300 145 35 0 170 500 265 400 205 450 235 Oven Control Knob Broil When broiling, the oven control knob should be set at 550°F (290°C). [. . . ] Cooktop versions for both Metro 3825 and Legacy 3820 models are available. Also available with a self clean oven feature, as model 9730 4200- 30" Gas / Electric kitchen range - 4 sealed gas burners, electric convection oven fits in a 30" opening! Model 3110: shown with the Optional cowl (available only with the Classic Series) Also available with a self clean oven feature, as model 4210 5200- 48" Gas / Electric kitchen range- 6 sealed gas burners, electric convection oven, dual fuel!Also available with the convenience of a self clean oven, as model 5210 6200- 48" Electric kitchen range- 5 solid element burners, convection oven. Also available with the convenience of a self clean oven, as model 6210 8200- 30" Electric kitchen range- 4 solid element burners, convection oven fits in a 30" opening! [. . . ]