User manual HATCO GRPWSM-1001

[. . . ] Friday) Telephone: (800) 558-0607; (414) 671-6350 (800) 690-2966 (Parts & Service) (414) 671-3976 (International) Additional information can be found by visiting our web site at www. hatcocorp. com. INTRODUCTION The Hatco Glo-Ray® GRPWS Pizza Warmers are perfect for holding boxed or bagged pizza on a buffet line or at temporary serving areas. These warmers hold hot wrapped pizzas and keep them at optimum serving temperatures without affecting quality. A thermostatically controlled heated base extends the holding times of most wrapped food. These units also feature incandescent lights along with a cord and plug set(s). [. . . ] (81 kg) ELECTRICAL RATING CHART ­ GRPWS MODELS - TRIPLE SHELF Model GRPWS-2418T GRPWS-3618T GRPWS-4818T GRPWS-2424T Voltage 120 120 120 120/208-240 120 220-230 (CE) 230-240 (CE) 120 120/208-240 200 220-230 (CE) 230-240 (CE) 120/208-240 220-230 (CE) 230-240 (CE) Watts 1125 1602 2055 2055 1425 1276-1395 1395-1518 2013 2013 1776 1800-1967 1967-2143 2574 2301-2514 2514-2738 Amps 9. 4 13. 4 17. 1 11. 4 11. 9 5. 8-6. 1 6. 1-6. 3 16. 8 11. 2 8. 9 8. 2-8. 6 8. 6-8. 9 14. 3 10. 5-10. 9 10. 9-11. 4 Plug Configuration NEMA 5-15P NEMA 5-15P* NEMA 5-20P NEMA 14-20P NEMA 5-15P CEE 7/7 Schuko BS-1363 NEMA 5-20P NEMA 14-20P AS 3112 CEE 7/7 Schuko BS-1363 NEMA 14-20P CEE 7/7 Schuko BS-1363 Shipping Weight 98 lbs. (103 kg) GRPWS-3624T GRPWS-4824T * NEMA 5-20P for Canada ELECTRICAL RATING CHART ­ GRPWS MODELS - QUADRUPLE SHELF Model GRPWS-2418Q GRPWS-3618Q GRPWS-4818Q GRPWS-2424Q GRPWS-3624Q GRPWS-4824Q * NEMA 5-20P for Canada Voltage 120 120 120/208-240 120/208-240 120 120/208-240 120/208-240 Watts 1500 2136 2136 2740 1900 2684 3432 Amps 12. 5 17. 8 8. 9 11. 4 15. 8 11. 2 14. 3 Plug Configuration NEMA 5-15P* NEMA 5-20P NEMA 14-20P NEMA 14-20P NEMA 5-20P NEMA 14-20P NEMA 14-20P Shipping Weight 119 lbs. GRPWSM-1001 SPECIFICATIONS DIMENSIONS - GRPWS MODELS Model GRPWS-2418D Width (A) 24" (61 cm) GRPWS-3618D 36" (91 cm) 48" (122 cm) 24" (61 cm) 36" (91 cm) 48" (122 cm) Depth (B) 18" (46 cm) 18" (46 cm) 18" (46 cm) 24" (61 cm) 24" (61 cm) 24" (61 cm) DUAL SHELF Height (C) 22½" (57 cm) 22½" (57 cm) 22½" (57 cm) 23½" (60 cm) 23½" (60 cm) 23½" (60 cm) C A GRPWS-4818D GRPWS-2424D B GRPWS-3624D GRPWS-4824D Height includes 4" (10 cm) for legs. Model GRPWS-2418T Width (A) 24" (61 cm) Depth (B) 18" (46 cm) 18" (46 cm) 18" (46 cm) 24" (61 cm) 24" (61 cm) 24" (61 cm) TRIPLE SHELF Height (C) 29¾" (76 cm) A 29¾" (76 cm) 29¾" (76 cm) 30¾" (78 cm) 30¾" (78 cm) 30¾" (78 cm) C GRPWS-3618T 36" (91 cm) 48" (122 cm) 24" (61 cm) 36" (91 cm) 48" (122 cm) GRPWS-4818T GRPWS-2424T B GRPWS3624T GRPWS4824T Height includes 4" (10 cm) for legs. Form No. GRPWSM-1001 4 SPECIFICATIONS Model GRPWS-2418Q Width (A) 24" (61 cm) GRPWS-3618Q 36" (91 cm) 48" (122 cm) 24" (61 cm) 36" (91 cm) 48" (122 cm) Depth (B) 18" (46 cm) 18" (46 cm) 18" (46 cm) 24" (61 cm) 24" (61 cm) 24" (61 cm) QUADRUPLE SHELF Height (C) 36¾" (93 cm) 36¾" (93 cm) 36¾" (93 cm) 37¾" (96 cm) 37¾" (96 cm) 37¾" (96 cm) B C A GRPWS-4818Q GRPWS-2424Q GRPWS-3624Q GRPWS-4824Q Height includes 4" (10 cm) for legs. INSTALLATION ALL MODELS Glo-Ray Pizza Warmers are shipped with most components pre-assembled. Care should be taken when unpacking shipping carton to avoid damage to unit and components enclosed. To prevent delay in obtaining warranty coverage, fill out and mail in the warranty card. Carefully lay unit on its side and install the four legs as shown in Figure 3. CAUTION The National Sanitation Foundation (NSF) requires that GRPWS Series units over 36" (91 cm) in length or weighing more than 80 lbs. Use caution when touching these areas to avoid injury. ON/OFF Switch Thermostat Control Figure 6. GRPWSM-1001 6 MAINTENANCE GENERAL Hatco Glo-Ray Pizza Warmers are designed for maximum durability and performance, with minimum maintenance. WARNING To avoid any injury, turn the power switches off, unplug the unit from the power source and allow to cool before performing any maintenance. WARNING To avoid electrical shock or personal injury, do not steam clean or use excessive water on the unit. Breakage of light bulbs not specially coated could result in personal injury and/or food contamination. WARNING If service is required on this unit, contact your Authorized Hatco Service Agent, or contact the Hatco Service Department at 800-558-0607 or 414-671-6350; fax 800-690-2966 or International fax 414-671-3976. To avoid damage to the unit or injury to personnel, use only Authorized Hatco Service Agents and Genuine Hatco Replacement Parts when service is required. WARNING Genuine Hatco Replacement Parts are specified to operate safely in the environments in which they are used. Some aftermarket or generic replacement parts do not have the characteristics that will allow them to operate safely in Hatco equipment. It is essential to use Hatco Replacement Parts when repairing Hatco equipment. Failure to use Hatco Replacement Parts may subject operators of the equipment to hazardous electrical voltage, resulting in electrical shock or burn. CLEANING CAUTION Use only non-abrasive cleaners. Abrasive cleaners could scratch the finish marring its appearance and making it susceptible to dirt accumulation. To preserve the bright finish of the Glo-Ray Pizza Warmer, it is recommended that the exterior and interior surfaces be wiped daily with a damp cloth. Hard to reach areas should be cleaned with a small brush and mild soap. [. . . ] Las Vegas 702-649-4616 NEW JERSEY Jay Hill Repair Fairfield Service Plus Flanders SOUTH CAROLINA Whaley Foodservice Repair W. Columbia 803-791-4420 TENNESSEE Camp Electric Memphis 901-527-7543 973-575-9145 973-691-6300 NEW YORK Acme American Repairs, Inc. Brooklyn 718-386-2515 Appliance Installation Buffalo 716-884-7425 Northern Parts Dist. Syracuse 315-422-9271 NORTH CAROLINA Authorized Appliance Charlotte 704-377-4501 OHIO Akron/Canton Comm. [. . . ]