User manual HATCO GRMWM-0505(1)

[. . . ] Friday) Telephone: (800) 558-0607; (414) 671-6350 Fax: (800) 690-2966 (Parts & Service) (414) 671-3976 (International) 24-Hour 7-Day Parts & Service Assistance available in the United States and Canada by calling (800) 558-0607. Additional information can be found by visiting our web site at www. hatcocorp. com INTRODUCTION The Hatco Glo-Ray® GRMW Series Warmers are perfect for holding prepared foods at kitchen work areas. These warmers hold hot prepared food products and keep them at optimum serving temperatures without affecting quality. Prefocused infrared heat from above and a thermostatically controlled heated base extends the holding times of the food product. [. . . ] If the plug and receptacle do not match, contact a qualified electrician to determine the proper voltage and size and install the proper electrical outlet. NEMA 5-15P Figure 1. Plug Configuration DIMENSIONS Model GRMW-. 5 Width (A) 15-7/8" (403 mm) 26-5/8" (676 mm) 34-1/2" (876 mm) Depth (B) 17-7/8" (454 mm) 17-7/8" (454 mm) 17-7/8" (454 mm) Height (C) 15-1/8" (384 mm) 15-1/8" (384 mm) 15-1/8" (384 mm) A C GRMW-3 GRMW-4 B Figure 2. GRMWM-0505 2 MODEL DESCRIPTIONS ALL MODELS All models are constructed of aluminum and stainless steel, featuring a power on/off switch, a thermostatically controlled hardcoated heated base, infrared upper heating element, polycarbonate front access door, and a 6' (1829 mm) cord and plug set. GRMW-. 5 MODEL The GRMW-. 5 model features a sliding pullout drawer assembly and comes with a pan holder equipped to hold one half-size pan, 2-1/2" (64 mm) deep. Figure 3. Glo-Ray GRMW-4 GRMW-3 MODEL The GRMW-3 series features a sliding pullout drawer and comes equipped with two pan dividers designed to hold up to three 1/3 size pans, 2-1/2" (64 mm) deep. NOTE: Pans not supplied by Hatco. Pans must be suitable for high temperature applications. GRMW-4 MODEL The GRMW-4P model features a sliding pullout drawer and comes equipped with three pan dividers designed to hold up to four 1/3 size pans, 2-1/2" (64 mm) deep. 3 Form No. GRMWM-0505 INSTALLATION UNPACKING Glo-Ray® Multi-Staging Warmers are shipped with most components pre-assembled. Care should be taken when unpacking shipping carton to avoid damage to unit and components enclosed. To prevent delay in obtaining warranty coverage, fill out and mail in the warranty card. Installing Pan Dividers WARNING For safe and proper operation, the unit must be located a reasonable distance from combustible walls and materials. If safe distances are not maintained, discoloration or combustion could occur. CAUTION To avoid any injury or damage locate the unit at the proper counter height, in an area that is convenient for use. The location should be level to prevent the unit or its contents from accidentally falling, and strong enough to support the weight of the unit and food. LOCATION NOTE: Unit must be transported in the upright position. For proper operation and maximum performance, locate the Multi-Staging Warmer in an area where the ambient air temperature is constant and is a minimum of 70°F (21°C). Areas which are susceptible to active air movements or currents should be avoided, i. e. , near exhaust fans, hoods and air conditioning ducts. For safe and proper operation the unit must be located indoors where the ambient air temperature is a minimum of 70°F (21°C) and a maximum of 85°F (29°C). Form No. Plug unit into a properly grounded electrical outlet of the correct voltage, size and plug configuration (see SPECIFICATIONS for details). To begin operation, place the ON/OFF toggle switch in the ON position. WARNING To avoid any injury or damage to the unit do not pull unit by power cord. Front Door "Middle" Screw/Slide Adjustment Screw CAUTION - HOT WARNING To prevent any injury, discontinue use if power cord is frayed or worn. NOTE: The unit comes equipped with a thermostat that is factory preset. If an adjustment is necessary please follow the instructions listed below. Figure 5. Thermostat Adjustment Procedure (GRMW-3 and GRMW-4 only) DRAWER OPERATION 1. The access door stays completely open by itself when the drawer is pulled all of the way out. [. . . ] San Francisco COLORADO Hawkins Commercial Appliance Englewood 303-781-5548 DELAWARE Food Equipment Service Wilmington 302-996-9363 FLORIDA Whaley Foodservice Repair Jacksonville 904-725-7800 Universal Restaurant Services Miami 305-593-5488 Nass Service Co. , Inc. Pompano Beach 954-971-0456 650-635-1900 CANADA 405-528-8883 BRITISH COLUMBIA Key Food Equipment Service Vancouver 604-433-4484 MANITOBA Denko Mechanical Ltd. Toronto Choquette CKS Ottawa QUÉBEC Choquette CKS Montreal Choquette CKS Québec City 514-722-2000 418-681-3944 416-422-5580 613-739-8458 Comm. Appliance Service Tampa 813-663-0313 GEORGIA TWC Services Smyrna Heritage Service Group Norcross 866-388-9837 Southeastern Rest. [. . . ]