User manual GERICOM 340S2 SERVICE MANUAL

[. . . ] 24 Pei Yuan Road Chung Li Industrial Park, Chung Li City Tao Yuan Hsien, Taiwan R. O. C. TEL: 886-3-461-6000 FAX: 886-3-461-6317 URL: http:// www. uniwill. com. tw/ 340S2 1 Rev : B Chapter 1 General System Description UNIWILL TECHNOLOGY CORP. 14F, 67 & 69, Section 1, Chung San RD. , Hsin Chuang City, Taipei Hsien, Taiwan, R. O. C. TEL: 886-2-8991-6888 FAX: 886-2-8991-5666 URL: http:// uniwill. com. tw/ 1. 1 System features 1. 1. 1 General features a. [. . . ] Yes Board-level Trouble shooting No Correct it Check PCMCIA slot mounting in M/B is cold soldering No Yes Re-soldering Check O2Micro OZ 6812 Chipset for cold soldering? Yes Re-solder No Replace O2Micro OZ6812 chipset 340S2 71 Rev : B Chapter 5 Troubleshooting Guidelines 5. 18 IR Port can't transfer data. IR failure & no response Check BIOS setup OK?Yes Check driver install OK No Correct it No Correct it Yes No Check another one IR device is meet IrDa 1. 0 Yes Board-level trouble shooting Try another IR device Check PC87393 for cold soldering No Replace Super I/O PC97393 Chipset Yes Re-soldering 340S2 72 Rev : B Index 5. 19 Modem failure Modem Failure Check Driver install & Telephone Line is OK? No Correct it Yes Check IRQ, COM port setting is OK?No Correct it AT command test modem function is OK No Re-install Drivers Yes Board-level trouble shooting Check modem DAA board is connected properly and wiring with the phone jack No Connect it Yes Replace another known good modem DAA module. 340S2 Rev : B Index UNIWILL COMPUTER CORP. 24 Pei Yuan Road Chung Li Industrial Park, Chung Li City Tao Yuan Hsien, Taiwan R. O. C. TEL: 886-3-461-6000 FAX: 886-3-461-6317 URL: http:// www. uniwill. com. tw/ 340S2 Rev : B Index 6. 1 LCD I. IV. 14. 1" TFT, XGA - Vendor ­ HYUNDAI, CHI MEI, CPY 12. 1" DSTN, SVGA ­ Vendor ­ SHARP 13. 3" TFT, XGA ­ Vendor ­ ACER, IMES 12. 1" TFT SVGA ­ Vendor - Sanyo 6. 2 FDD External / Swappable FDD: 3. 5" format Capacity : 720KB / 1. 44MB / 1. 2MB (3 mode) 6. 3 HDD Dimension Vendor : 2. 5", 8. 5 / 9. 5 mm height : Toshiba and Fujitsu 6. 4 CD-ROM Vendor : QMATE, TEAC Dimension : 12. 7-mm height, 12/8 cm CD-ROM disc PIO Mode 4, 24X Average 3. 1W, Sleep 0. 05W ATAPI Interface DVD : TORISAN, TOSHIBA : 12. 7mm height, 12/8cm CD-ROM disc Vendor Dimension PIO Mode 4 Average 3. 1W, Sleep 0. 05W ATAPI Interface 6. 5 BATTERY: Li-ION Vendor : PANASONIC , GS Battery type : Li-Ion, 8 cells (4S2P) Battery capacity : 14. 8V, 3200mAH, (47. 36Whrs) 1. 1. 2. Charge Voltage : 16. 8V +2. 5% -1. 0% Charge temperature : 0~45o C Discharge temperature : -20~60o C End of Discharge : 11V Cycle life= 500 times Overcharge protection : when battery voltage reach 17. 2 ±0. 2V Over-discharge protection : when battery voltage decrease to 10 ± 1V Pre-charge current: 0. 2A Charge current : When system is power off : 2A When system is powered ON : 1A Ni-MH Vendor : PANASONIC, TOSHIBA Battery Type : Ni-MH, 10 cells (10S) Battery Capacity : 12. 0V, 4500mAh (54. 0 watts) Charge voltage : 16. 8V +2. 5% -1. 0% Charge temperature : 0~45o C 340S2 Rev : B Index Discharge temperature : -20~60o C End of Discharge : 10V Cycle life= 500 times Pre-charge current: 0. 2A Charge current : When system is power off When system is powered ON 6. 6 TOUCH PAD Synaptic Capacitor sensor Support edge motion Support virtual scroll bar Support 2 or 3 button mode ESD withstand: 15KV Power Consumption: 2. 75mA / 5V X/Y resolution: 500 points/inch Interface: PS/2 6. 7 KEYBOARD Supplier Travel Support Key pitch Dimension : 2A : 1A : KC Matrix-290 : 3. 0 ±0. 2mm : 3 window keys : 19mm : 249mm x 100. 85mm x 7. 8 mm 6. 8 MODEM/FAX MODULE Modem chip : LUCENT DSP1645 + CSP1034AH + CSP1027 Meet PC99 Window modem requirement Support : 3. 3V PCI bus / V. 80 (for H. 324) / DSVD( V. 70) / half duplex speaker phone V. 34bis / AT command set / V. 42 (LAPM) and MNP error correction V. 42bis and MNP5 data compression / 56Kflex protocol / V. 17, V. 29, V. 27ter, V. 21ch2 / VI Group III fax / telephony answering machine / DTMF generation and detection / V11. Local handset, telephone and microphone record / telephone line and headset or VIII. Peaked playback / voice view / caller ID / host base DSVD Power : active=450mW idle=160mW sleep=10mW 340S2 Rev : B Index UNIWILL COMPUTER CORP. 24 Pei Yuan Road Chung Li Industrial Park, Chung Li City Tao Yuan Hsien, Taiwan R. O. C. TEL: 886-3-461-6000 FAX: 886-3-461-6317 URL: http:// www. uniwill. com. tw/ 340S2 Rev : B Index 7. 1 TOP CABINET ASSEMBLY NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 PART NUMBER 71-002901-00 50-352924-00 40-102902-00 50-312927-00 74-08U204-00 41-720120-06 7915034020 50-212904-00 40-102901-00 41-720120-04 50-312903-00 41-720120-03 22-300513-00 50-352922-00 50-352921-00 41-720120-03 50-352924-00 50-432911-00 DESCRIPTION K/B US COVER HINGE (L) 340 SPRING SPK 340 TOP CAB. ASSY ­ ID2 T/P M2. 0*6 FPC T/P PAD ADHESIVE TAPE SPRING FOR K/B 340 M2. 0*4 TOP HOUSING (MG) 340 M2. 0*3 SPEAKER FG-36N081 COVER HINGE (R ) 340 COVER HINGE FRAME M2. 0*3 COVER CABLE FOR 340 LATCH K/B FOR (BLACK) 7. 2 PCB (MOTHERBOARD) ASSEMBLY 340S2 Rev : B Index NO. 1 2 3 4 5 6 7 8 PART NUMBER 7914129030 41-720120-08 41-300002-04 41-720120-04 76-0U0137-00 581510385AP 41-300002-21 41-720120-06 DESCRIPTION MYLAR CD-ROM 340 SCREW M2. 0*8 HEX M2. 0*3(HEX*3)CU M2. 0*4 MODEM CARD M/B ASSY HEX D4. 8*10. 2L SCREW M2. 0*6 7. 3 BASE CABINET ASSEMBLY 340S2 Rev : B Index NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 PART NUMBER 50-322903-00 40-102904-00 50-202907-00 50-202908-00 40-302913-00 5810503401P 50-212902-00 50-502902-00 41-760230-03 41-720120-04 50-202906-00 41-720120-04 29-102907-00 52-002901-00 50-202905-00 791C250452 27-322911-00 23-523200-21 5810603401P 5810603402P 29-163403-00 40-302914-00 41-720725-08 DESCRIPTION BOTTOM CAB ASSY W/OUT TV OUT SPRING PCMCIA DOOR DOOR PCMCIA (U) 340 DOOR PCMCIA (L) 340 BRACKET CDROM 340 CD-ROM ASSY 24X QUANTA HDD MYLAR HDD 340 PLATE HDD 340 SCREW M3. 0*3 SCREW M2. 0*4 DOOR HDD 340 SCREW M2. 0*4 CABLE HDD 340 RUBBER FOOT 340 DOOR CPU 340 SCREW M2. 5*4. 5 PAN THERMAL MODULE FOR 340S2 BATTERY Li-Ion 3200mAH PAN. FDD ASSY MITSUMI FDD ASSY TEAC FFC FDD BRACKET FDD 340 SCREW M2X0. 45X8 7. 4 LCD ASSEMBLY 340S2 Rev : B Index NO. 13 14 15 340S2 PART NUMBER 41-720525-06 52-012919-00 40-302905-00 40-152907-00 41-720525-06 50-332921-00 52-012911-00 41-720120-04 40-152909-00 29-102901-00 76-030533-00 40-302906-00 PART NUMBER 50-212900-00 50-242910-00 50-412906-00 DESCRIPTION SCREW M2. 5*6 RUBBER FOR DISPLAY (T) 340 BRACKET (L) FOR LCD HINGE (L) A-TYPE 340 SCREW M2. 5*6 FRONT CAB 14. 1 RUBBER FOR DISPLAY (B) SCREW M2. 0*4 HINGE ( R) A-TYPE 340 CABLE FOR LCD INVERTER 14. 1 INVERTER FOR 14. 1" BRACKET ( R) FOR LCD DESCRIPTION MYLAR FOR INVERTER 340 HOOK LCD (R ) 340 KNOB LCD (340) Rev : B Index 16 17 18 19 20 21 50-342961-00 40-101603-00 50-412906-00 50-242910-00 29-012900-30 58103A55D1P BACK CABINET SPRING LCD GE-6200 KNOB LCD 340 HOOK LCD (L) 340 CABLE FOR LCD LCD 14. 1"T CHI UNIWILL COMPUTER CORP. 24 Pei Yuan Road Chung Li Industrial Park, Chung Li City Tao Yuan Hsien, Taiwan R. O. C. TEL: 886-3-461-6000 FAX: 886-3-461-6317 URL: http:// www. uniwill. com. tw/ 340S2 Rev : B Index Global Support UNIWILL COMPUTER CORP. Taiwan: 24, Pei-Yuan Rd. , Chungli Industrial Park, Tao-Yuan Hsien, TAIWAN, R. O. C. NetherLands: Tarweweg 5, 6534 AM Nijmegen, The Netherlands Tel: 31-24-388-3255, Fax: 31-24-356-5343 UNIWILL COMPUTER (US): 46716 Lakeview Blvd. , Fremont, CA94538, USA Tel: 1-510-580-6888, Fax: 1-510-580-5666 Remark: Any pertinent information you can provide us to expedite our response will be greatly appreciated. When filling up information in the "failure symptoms" space, please note the following: 1. Any results from regenerating the problem on the other types of system (e. g. , IBM products, any other models of Uniwill machines, etc. ) 4. [. . . ] 5. 10 CMOS test error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5. 11 SIO port test error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5. 12 PIO port test error . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5. 13 Audio drive failure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]