User manual GAS GAS MC65 2006

[. . . ] MANUAL DEL USUARIO USER MANUAL MANUEL D'ENTRETIEN LIBRETTO D'USO BETRIEBSANLEITUNG USER MANUAL ENGLISH USER MANUAL GAS GAS thanks you for the trust you have placed in us. We are delighted that you have selected the MC 65 motorcycle and we would like to welcome you to the GAS GAS family. This bike incorporates our accumulated competition experience and that which we have gained from the achievement of many important titles. You now possess a motorcycle with which, as well as feeling comfortable, you are offered infinite possibilities of driving at the highest level of your skill while maintaining a maximum of security. [. . . ] Have the brake system checked by a GAS GAS dealer before using the motorcycle. Checks each time you start the motorcycle (Cont. ) 6 Cables Check the adjustment and working of the accelerator cable. 7 Coolant fluid When the engine is cold, check the level of the coolant fluid. -12- INSTRUCTIONS FOR MAINTENANCE A A Starting when the engine is cold 1- Open the fuel tap. - Pull the choke control upwards (A) 4- Kick the starter pedal vigorously without opening the accelerator. -13- Fuel tap This has three positions: 1- Reserve 2- Open 3- Closed The diagrams below show the position of the fuel tap (A) for each case. 1 2 3 A Starting when the engine is cold (Cont. ) Caution!Your foot may slip off the starter pedal or the engine may kickback if the kick was not hard enough. Exhaust fumes are highly toxic and may result in loss of consciousness or even loss of life. When the engine is running, ensure that there is always adequate ventilation. Driving the motorcycle while the engine is cold is not recommended as the piston heats up more quickly than the water cooled cylinder. Allow the engine to warm up while idling or driving at low speeds. Starting when the engine is warm 1- Open the fuel tap. 3- Kick the starter pedal vigorously without opening the accelerator. What to do when the engine is "flooded" 1- Close the fuel tap. 3- When the engine starts again, re-open the fuel tap. -14- Setting off Pull on the clutch lever, engage first gear and slowly release the clutch lever while also accelerating. Always remove the stand before your child starts to ride the motorcycle. Caution!After a fall with the motorcycle, all the functions should be checked before starting the bike again. A high engine speed when the engine is cold will have a negative effect on the engine life. It is better to warm the engine at medium speed for several kilometres, and never reduce gear with the throttle fully open, if the engine races, this may cause damage. In addition, this may cause the rear wheel to lock, with the resultant loss of control of the motorcycle. If, during long descents, the engine is working without accelerating, open and shut the throttle quickly from time to time to ensure that the lubricant-petrol mixture reaches the engine. In the event of an unusual noise or vibration while driving the motorcycle, stop immediately, switch off the engine and contact a GAS GAS dealer. Changing gears, driving First gear is the gear used to set off. Conditions permitting (traffic, slope, etc), a higher gear may be engaged. For this, close the throttle, pull on the clutch lever, engage the next gear, release the clutch lever and accelerate. When the choke is used, make sure that it is pushed back once the engine is warm. When reducing gear, use the brake if necessary and close the throttle grip at the same time. Slowly release the clutch lever and accelerate or reduce gear again. -15 - Fuel ­ Petrol/oil mixture The motorcycle is fitted with a two-stroke internal combustion engine. [. . . ] During the first six months subsequent to the delivery of the repaired vehicle, the seller will be responsible for any unwarranted faults arising out of the repair. Any defects detected in the product must be brought to the attention of a GG authorised dealer within the Warranty Period. If the last day of this period is a Sunday or an official holiday, the Warranty period will be extended such that the last day of the period covered will be the first working day after the Sunday or official holiday. Those claims under Warranty for defects not brought to the attention of a GG authorised dealer before the end of the Warranty Period will be excluded. -39 - Obligation of the purchaser GG will have the right to reject any claims under Warranty in the event that: a) The purchaser has failed to submit the vehicle to any of the inspections and/or maintenance work required in the Users' Manual, or has exceeded the date set for such inspections or maintenance work. [. . . ]