User manual GAS GAS K2 QUAD 50

[. . . ] 4 STROKE 50 MANUAL DEL USUARIO USER MANUAL MANUEL D'ENTRETIEN LIBRETTO D´USO BETRIEBSANLEITUNG 50 4 STROKE SERVICE MANUAL ENGLISH INTRODUCTION Congratulations on your purchase of QUAD 50 - 4 STROKE it represents the result of many years of our experience in the production of fine machines. You can now appreciate our craftsmanship and reliability of the master piece. This manual will provide you with a good basic understanding of the features and operation of this machine. Failure to follow the warnings contained in this manual can result in serious injury or death. [. . . ] Only squeeze the left hand brake lever once again the parking brake will be released in free motion. Always keep the disc plate clean, refrain from grease. d. Mechanical disc rear brake The mechanical disc rear brake is operated with the lever on the left handlebar. When braking, grasp this lever which applies the brake to the rear wheels. -12- e. The cap of the switch tied to a rope is normally connected to the safety switch when riding the vehicle. The supervisor should hold the safety switch behind the vehicle and pull the rope to activate the safety switch if necessary. The engine will stop automatically when the switch cap is off from the switch. OFF Switch mark " " If the lever is in this position. fuel will not flow, Alaways turn the lever to this position when the engine is not runing. · ON Switch mark " " If the lever is in this position, fuel flows to the carburetor. Fuel valve The three way fuel valve is on the left side of the vehicle. -13- Res Switch mark " " After refueling return the fuel cock lever to the "ON" position. when your QUAD run out of fuel while riding, Turn the fuel cock from "ON" to "Res", you can run your QUAD for a few minutes. b. Do not refuel-right after the engine has been running and still very hot. ENGINE OIL Four-stroke engine oil must be added to the Cramkoorp periodically. If oil supply to engine is not enough, the machine will be out of order. it can not work again. you can refill the oil into the cramkcase behind the engine. -14- The pressure should be checked when the tires are "cold" before running the vehicle. Tire wear limit When the tire groove decreases to 3mm (0. 1" ) due to wear. when the switch is on the mark " ", it means to turn off light. the light is turned on. · TIRES Check tire pressure frequently with the air pressure gauge. Recommended: FRONT: 20kpa, (0. 2 kgf/ cm2), 2. 8 psi REAR: 20kPA, (0. 2 KGF/CM2), 2. 8 psi Minimum: FRONT:17Kpa, (0. 17 kgf/cm2), 2. 4 psi REAR: 17Kpa, (0. 17 kgf/cm2), 2. 4 psi OPERATION INSPECTION Inspect your vehicle every day before you run it. Check oil level in crankcase The oil level should be between the maximum and mini mum marks. -15- Check brake operation. If any problem cannot be corrected by the adjustment, have the QUAD inspected by leader. Push the throttle lever slightly. RIDING Begin by finding a safe area free of obstacles with a level surface. Under normal riding conditions it is not necessary to touch the ground for balance. After the engine has been warmed up, release the parking brake The vehicle is ready for riding. Increase engine speed by opening the throttle gradually. RUN-IN During the first two weeks of riding. run your new vehicle tenderly. [. . . ] During the first six months subsequent to the delivery of the repaired vehicle, the seller will be responsible for any unwarranted faults arising out of the repair. Any defects detected in the product must be brought to the attention of a GG authorised dealer within the Warranty Period. If the last day of this period is a Sunday or an official holiday, the Warranty period will be extended such that the last day of the period covered will be the first working day after the Sunday or official holiday. Those claims under Warranty for defects not brought to the attention of a GG authorised dealer before the end of the Warranty Period will be excluded. -26- Obligation of the purchaser GG will have the right to reject any claims under Warranty in the event that: a) The purchaser has failed to submit the vehicle to any of the inspections and/or maintenance work required in the Users' Manual, or has exceeded the date set for such inspections or maintenance work. [. . . ]