User manual FORD CONTOUR-1998

[. . . ] Contents Before driving Introduction Instrumentation Controls and features Seating and safety restraints Starting and driving Starting Driving Roadside emergencies Servicing Maintenance and care Capacities and specifications Reporting safety defects (U. only) Index 128 186 192 193 1 2 4 17 47 79 87 110 Introduction ICONS Indicates a warning. Indicates that vehicle information related to recycling and other environmental concerns will follow. Correct vehicle usage and the authorized disposal of waste cleaning and lubrication materials are significant steps toward this aim. WARNINGS How can you reduce the risk of personal injury and prevent possible damage to others, your vehicle and its equipment? [. . . ] For your safety and to maximize vehicle performance, be sure to use the proper equipment while towing. 103 Driving Follow these guidelines to ensure safe towing procedure: · Stay within your vehicle's load limits. · Do not tow a trailer until your vehicle has been driven at least 800 km (500 miles). · Refer to the instructions included with towing accessories for the proper installation and adjustment specifications. 104 Driving Do not exceed the maximum loads listed on the Safety Compliance Certification Label. For load specification terms found on the label, refer to Loading your vehicle in this chapter. Remember to figure in the tongue load of your loaded vehicle when figuring the total weight. Towing trailers beyond the maximum recommended gross trailer weight exceeds the limit of the vehicle and could result in engine damage, transaxle damage, structural damage, loss of control, and personal injury. Preparing to tow Use the proper equipment for towing a trailer and make sure that it is properly attached to your vehicle. See your dealer or a reliable trailer retailer if you require assistance. Auxiliary coolers are recommended for the power steering system and automatic transaxle system if you are planning on: · Traveling farther than 80 km (50 miles). · Towing frequently. 105 Driving Using a hitch Do not use hitches that: · Clamp onto the vehicle bumper. Distribute the load so that only 10 to 15% of the total weight of the trailer is on the tongue. Tie down the load so that it does not shift and change weight on the hitch. Follow the instructions of a reputable rental agency. Using trailer lamps See your local trailer retailer or rental agency for proper instructions and equipment for hooking up trailer lamps. Do not hook the trailer lamps directly into the vehicle's wiring system. If the trailer lamps are not working properly, the warning lights in the instrument cluster may not work properly. 106 Driving Using trailer brakes Use electric brakes or manual, automatic or surge type hydraulic brakes that meet Federal and local regulations. Install and adjust brakes according to the manufacturer's instructions. Do not connect a trailer's hydraulic brake system directly to your vehicle's brake system. Your vehicle may not have enough braking power and your chances of having a collision greatly increase. Using safety chains Always connect the trailer's safety chains to the vehicle. To connect the chains, cross the chains under the trailer tongue and attach to the vehicle frame or hook retainers (not the bumper). Make sure there is enough slack to allow the vehicle to turn corners. 107 Driving Driving while towing a trailer Do not drive faster than 72 km/h (45 mph) while towing a 454 kg (1 000 lb) trailer. Do not drive faster than 72 km/h (45 mph) with any weight trailer while towing in hilly terrain or on hot days. Speed control (if equipped) may not work properly while towing on long, steep grades. If driving with an automatic transaxle: · Use D (Drive) or a low gear rather than D (Overdrive) while towing up or down steep inclines. If driving with a manual transaxle: · Select a gear that avoids jerking or excessive engine speed. [. . . ] Cleaning and caring for your vehicle Refer to the "Customer Assistance Guide" for a list of Ford-approved cleaners, polishes and waxes. 185 Capacities and specifications Motorcraft parts Part number Component Spark plug* Air filter Passenger compartment air filter Fuel filter Oil filter Battery PCV valve Crankcase ventilation filter 2. 0 litre engine AZFS-22F # 1+2** AZFS-22FE# 3+4 2. 5 litre engine AWSF-32F FA-1612 FP4 FG-800A FL-2005 BXT-40R EV-224 FA-1621 FA-1613 FP4 FG-800A FL-820 BXT-40R EV-152 -- * Refer to Vehicle Emission Control Information (VECI) decal for spark plug and gap specifications. ** If a spark plug is removed for examination, it must be reinstalled in the same cylinder. If a spark plug needs to be replaced, use only spark plugs with the service part number suffix letter "FE" as shown on the engine decal. 186 Capacities and specifications Capacities Engine oil - with filter - without Manual transaxle Automatic transaxle with oil cooler Power steering Cooling system with heating Windshield washer fluid Fuel tank Braking system * Total capacity ** with automatic transaxle 2. 0 litre engine 4. 25 l (4. 5 qts) 3. 75 l (4. 0 qts) 2. 5 litre engine 5. 5 l (5. 8 qts) 5. 0 l (5. 3 qts) 2. 6 l (2. 7 qts) 8. 5 l (9. 0 qts. ) 9. 6 l (10. 2 qts) Fill to MAX mark 6. 6 l (7. 0 qts)* 7. 1 l (7. 5 qts)** 9. 5 l (10. 0 qts)* 9. 7 l (10. 2 qts)** Fill to top of reservoir 61. 5 l (16. 2 gallons) Fill to MAX mark 187 Capacities and specifications Lubricant Specifications Item Brake fluid Engine coolant Ford part name or equivalent High performance DOT 3 brake fluid Premium engine coolant Motorcraft motor oil 5W-30 super premium MERCON® power steering fluid Motorcraft MERCON® ATF Ultra-clear windshield washer concentrate Ford part number C6AZ-19542-AB E2FZ-19549-AA CXC-8-B* XO-5W30-QSP Ford specification ESA-M6C25-A WSE-97B44-A American Petroleum Institute Certification Mark and WSS-M2C153-G Engine oil Power steering fluid Transaxle fluid automatic/ 5-speed manual Windshield washer fluid E6AZ-19582-AA MERCON® XT-2-QDX MERCON® C9AZ-19550-AA or C9AZ-19550-BA ESR-M17P5-A 188 Capacities and specifications Engine data Engine Capacity Power output Max. intermittent engine speed Idle speed (manual transaxle) Mixture preparation Firing order Spark plug gap Ignition system Valve clearances 0. 14 mm Inlet Exhaust 0. 30 mm mm rpm rpm rpm 6150 6375 800±50 (880±50) cm3 kW (HP) at rpm Nm (lb-ft) at rpm 2. 0 litre Engine 1988 96 (125) 5500 176 (130) 4000 2. 5 litre Engine 2544 125 (170) 6250 220 (162) 4250 87 Octane 6700 6925 725±50 (725±50) Injection system 1-3-4-2 1. 3 Electronically controlled 0. 11-0. 18* 0. 27-0. 34* Hydraulic valve adjusters 1-4-2-5-3-6 * Mechanical valve adjuster 189 Capacities and specifications D A C E B Dimensions A = Maximum length B = Overall width (without mirrors) C = Overall height (curb weight) D = Wheelbase E = Track Front Rear * Dependent on tire size mm (inches) 4556 (179. 4) 1751 (68. 9) 1380 - 1427 (54. 3 - 56. 2) 2704 (106. 5) 1499 - 1518* (59. 0 - 59. 8) 1483 - 1502* (58. 4 - 59. 1) 190 Capacities and specifications VEHICLE IDENTIFICATION NUMBER The vehicle identification number (VIN) is attached to a metal tag and is located on the front driver's side of the instrument panel. [. . . ]