User manual DUCATI S2R 1000

[. . . ] Use and maintenance manual E S2R 1000 1 E 2 We would like to welcome you among Ducati enthusiasts, and congratulate you for choosing a Ducati motorcycle. We are sure that you will use your Ducati motorcycle for longer journeys as well as short daily trips, but however you use your motorcycle, Ducati Motor Holding S. p. A wishes you an enjoyable ride. We are continuously working to improve our Technical Assistance service. For this reason, we recommend that you follow strictly the instructions in this manual, especially those regarding the running-in period. [. . . ] 36) Contains: 3) spark plug wrench; 4) tommy bar for spark plug wrench; 5) double-ended screwdriver; 6) helmet fastening cable. 1 E 2 fig. 36 45 Main Maintenance Operations 1 E Removing the fairing panels (fig. 37) Some parts of the motorcycle fairing have to be removed for certain maintenance or repair operations. Warning If parts that have been removed are not refitted correctly they may become loose suddenly while riding and cause you to lose control of your motorcycle. Removal of the headlight fairing Unscrew and remove the two bolts (1) securing the headlight shell to the headlight support. 2 fig. 37 Notes Be careful not to lose the nuts for the bolts (1) located on the inside of the headlight shell. 38) Warning To prevent fuel from spilling out through the filler cap breather hole, the quantity of fuel in the tank should be less than 5 litres. To replace the tank, perform the above operations in the reverse order. E 1 Warning When lowering the fuel tank, take care to position the hoses correctly so they are not pinched or crushed. fig. 40) The air filter must be renewed at the intervals indicated in the periodic maintenance table shown in the Warranty Booklet. To remove the filter, release the clips (1) on both sides of the airbox cover and remove the cover (2, fig. 41) and fit a new one. 2 E Important A dirty filter reduces the amount of intake air, which increases fuel consumption, reduces engine power and causes deposits to form on the spark plugs. Do not use the motorcycle without a filter; as impurities in the air could get into the engine and cause damage. Reinstall the filter correctly in its housing in the airbox, as shown in the figure, and refit all the parts originally removed. 1 fig. 40 3 Important If using the machine on wet or dusty roads, the air filter cartridges should be renewed more frequently than the intervals in the periodic maintenance table in the Warranty Booklet. fig. 42) The levels should not fall below the MIN marks on the respective reservoirs. If the level is too low it can allow air to get into the circuit, thus impairing the efficiency of the relative system. Brake and clutch fluid must be topped up and changed at the intervals specified in the periodic maintenance table (see Warranty Booklet) by a Ducati Dealer or Authorized Service Centre. E Important It is recommended that all brake and clutch hoses be renewed every four years. Clutch system If there is too much play at the control lever and the motorcycle jumps or stops when a gear is engaged, this indicates air in the system. Contact a Ducati Dealer or Authorized Service Centre to have the system inspected and the air bled from the system. 42 Brake system If there is excessive play at the brake lever or pedal even though the brake pads are still in good condition, contact a Ducati Dealer or Authorized Service Centre to have the system inspected and any air expelled from the circuit. Warning The level of clutch fluid tends to increase in the reservoir as the friction material on the clutch plates wears out. Do not exceed the specified level (3 mm above the minimum level). Warning Brake and clutch fluid is harmful to paintwork and plastic parts, so do not allow it to come into contact with them. Check that the seals are in good condition. 49 Checking the brake pads for wear (fig. 43) Front brake The brake pads are marked with wear indicators so that they can be checked without removing them from the calipers. [. . . ] Limitations This Emission Control System Warranty shall not cover any of the following: A. Repair or replacement required as a result of (1) accident, (2) misuse, (3) repairs improperly performed or replacements improperly installed, (4) use of replacement parts or accessories not conforming to Ducati specifications which adversely affect performance and/or (5) use in competitive racing or related events. Inspections, replacement of parts and other services and adjustments required for routine maintenance. Any motorcycle on which odometer mileage has been changed so that actual mileage cannot be readily determined. [. . . ]