User manual DMC DAYSTAR FI

[. . . ] OWNER S MANUAL IMPORTANT NOTICE WELCOME Thank you for purchasing an Daelim vehicle. OPERATOR AND PASSENGER This motorcycle is designed to carry the operator and one passenger. WARNING Attempting to change the pre-set maximum speed may cause danger and will void the Daelim warranty. ON-ROAD USE This motorcycle is designed to be used only on the road. READ THIS OWNER'S MANUAL CAREFULLY Pay special attention to statements preceded by the following words: WARNING Indicates a strong possibility of severe personal injury or death if instructions are not followed. CAUTION Indicates a possibility of personal injury or equipment damage if instructions are not followed. NOTE Gives helpful information. keep it with your vehicle at all times, even though your vehicle is resold. CONTENTS SPECIFICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] Stop engine and remove the key prior to the vehicle maintenance service. If you are unable to correct trouble even after you make adjustment or correction, contact authorized maintenance shops, dealers or designated repair shops for necessary inspection and repairs. 21 INSPECTION OF CONCERNED AREA Check areas which caused for concern when last operating the vehicle. BRAKES The front brake is the hydraulic disk type, and the rear brake is the drum brake type. There are no adjustments to perform, but fluid level and pad wear must be inspected periodically. The system must be inspected frequently to ensure there are no fluid leaks. [FRONT WHEEL] <BRAKE LEVER FREE PLAY> Lightly squeeze the brake levers until tension is felt to check for an appropriate amount of free play. No free play in the brake levers or overly loose brake levers are indication of a problem in the brake system. BRAKE LEVER FREE PLAY : 10~20mm <BRAKE FLUID LEVEL> WARNING Brake fluid may cause irritation. In case of contact, flush thoroughly with water and call a doctor if your eyes were exposed. Put main stand in upright position on a flat ground and operate steel wheel, and check fluid when the top of master cylinder cap is level. If fluid significantly low, it may indicate fluid leakage on brake system. If this happens, check fluid leaks or damage on system and inspect joints and clamps for looseness. FUEL CHECK Check gasoline to see if there is a sufficient amount of gasoline to reach your destination. Refer to page 16 for refueling. 22 In addition, check hose and pipe protective part to sec if they make contact with other parts when you make left or right turn due to vibration during travel. LOWER LEVEL ENGINEC STOP <REPLENISHING BRAKE FLUID> Move steering wheel and set the top of reserve tank level. Clean dust and other foreign matter from around master cylinder and take caution not to allow foreign matter to fall inside master cylinder Open cap screw and remove diaphragm. Replenish recommended brake fluid to upper level inside master cylinder. Tighten cap accurately, paying attention to the direction of diaphragm assembling, and avoid ingress of foreign matter. RECOMMENDED BRAKE FLUID IS DOT 3 SCREW MASTER CYLINDER CAP DIAPHRAGM PLATE DIAPHRAGM UPPER LEVEL CAUTION Brake is an important part which protects your life. Make sure to inspect brake prior to daily use. 23 CAUTION Do not fill brake fluid above upper level as it may cause brake fluid to leak outside. Exercise full caution, when replenishing brake fluid, not to allow dust or water to mix inside master cylinder. If the amount of brake fluid decreases considerably, it is an indication of brake system trouble. To prevent occurrence of chemical change, do not use brake fluid of different manufacturer. Do not let brake fluid contact vehicle parts because it causes damage to painted parts. <BRAKE PAD INSPECTION> Operate brake and, if the brake pad wear limit line reaches the brake disc side, it indicates the pad has reached wear limit. WEAR LIMIT LINE [REAR WHEEL] Push the brake pedal with hands for resistance and check if the pedal movement appropriate. If brake pedal movement is inappropriate, adjust the pedal free play using the rear wheel brake adjuster nut. [. . . ] Arms : Relieve the tension and bend arms to inside and let them act as the spring. Hands : Grip the handle the position away from the inside end of the handle with distance of one finger to facilitate the operation of the switch and lever. Wrist : Keep the state to act freely without applying excessive force to the shoulder and arms. Feet : Place the feet to face the front parallel and make the step bar be placed in the center of feet. 48 PRECAUTION WHEN DRIVING Secure the safe distance. [. . . ]