User manual DAELIM VS125

[. . . ] IMPORTANT NOTICE OPERATOR AND PASSENGER This motorcycle is designed to carry the operator and one passenger. < ON-ROAD USE This motorcycle is designed to be used only on the road. < READ THIS OWNER'S MANUAL CAREFULLY Pay special attention to statements preceded by the following words: Indicates a strong possibility of severe personal injury or death if instructions are not followed. Indicates a possibility of personal injury or equipment damage if instructions are not followed. Gives helpful information. This manual should be considered a permanent part of the motorcycle and should remain with the motorcycle when resold or othe rwise transferred to a new owner or operator. -fiۿ~ 2005. 12. 29 4:55 PM á^1 CONTENTS SPECIFICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 SAFETY PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CORRECT ATTIRE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] <BREAK-IN OPERATION> Maintain engine revolution at a level less than 6, 000rpm for first 1, 000km to break in vehicle. If vehicle is broken in as above, the life span of equipment is prolonged. Select a safe place free of traffic and park vehicle. Park vehicle in places where there is no danger for people to contact with vehicle. <PARKING WHEN SIDE STAND IS USED> Stop vehicle on level ground and park with the steering wheel turned to left. If the vehicle is parked in the following way, vehicle may fall to side. < If the vehicle is parked with the steering wheel turned to right, or if parked on a slope, sandy places, uneven ground or soft ground, vehicle may fall. < If is necessary to park in an unstable ground under unavoidable situation, take su fficient s afety measures to prevent vehicle from falling or moving. A brupt downshift may cause the shake of rear parts. 20 -fiۿ~ 2005. 12. 29 5:6 PM á^21 SELF INSPECTIONS BEFORE OPERATION Self i nsp ect th e mot orcycle an d have regu lar mai nt enance in spect ion s for increased s afet y and the p revention of accidents. Self inspections before operation should be perfo rm ed an a d aily b asi s prio r t o operating the vehicle. < Fuel check < Brake inspection < Tire inspection < Battery acid level inspection < Throttle grip Inspection < Clutch inspection. < Exhaust gas contains harmful s ubs tan ce su ch as carb on mono x-ide. Do n ot carry out inspections on vehicle in closed places, or in poorly ventilated places, with engine running. < Con duct ins pection s on flat, s oli d gro und wit h th e s tand erected. < Be careful of burns when conducting inspections immediately after engine is stopped because the engine and muffler are hot. < Stop engine and remove the key prior to the vehicle maintenance service. < If y ou are u nab le t o correct trou ble ev en after y ou make ad jus tmen t or co rrecti on , contact authorized maintenance sh ops , dealers or d es ign at ed repai r sh op s for n ecess ary inspection and repairs. INSPECTION OF CONCERNED AREA Check areas which caused for concern when last operating the vehicle. 21 -fiۿ~ 2005. 12. 29 5:6 PM á^22 BRAKE CHECK a FRONT WHEELb <BRAKE OIL INSPECTION> Put main stand in upright position on a flat ground and operate steel wheel, and check flui d w hen th e to p o f master cylinder cap is level. If fluid significantly is in low level, it may indicate fluid leakage on brake system. If this happens, check fluid leaks or damage on system and inspect joints and clamps for looseness. In add iti on, check h ose and p ipe protective part to sec if they make contact with other parts when you make left or right turn due to vibration during travel. Make sure to inspect brake prior to daily use. SCREW ME C L D C P AT R Y E A S IN R DIAPHRAGM PLATE DIAPHRAGM UE PPR LEVEL REPLENISHING BRAKE OIL Move steering wheel and set the top of reserve tank level. < Clean dust and oth er foreign matter from around master cylinder and take caution not to allow foreign matter to fall inside master cylinder < Open cap screw and remove diaphragm. < Replenish recommended brake fluid to u pp er level in sid e mas ter cyl ind er. Tighten cap accurately, paying attention t o t he d irecti on of diap hragm assembling, and avoid ingress of foreign matter. [. . . ] Do not store the mo torcycle in direct sunlight. <REMOVAL FROM STORAGE> < Uncover and clean the motorcycle. Test ride the motorcycle at low speeds in a safe riding area away from traffic. 41 -fiۿ~ 2005. 12. 29 5:15 PM á^42 SAFE DRIVING PREPARATION BEFORE DRIVING < Performing daily inspection < Putting on the protective gears (Helmet, glove, goggles, etc. ) < Bringing the driver's licence < Determinating the path to the desired destination 42 -fiۿ~ 2005. 12. 29 5:15 PM á^43 PRECAUTION WHEN DRIVING < Secure the safe distance. < < < < < < < < If any abnormality is found, stop driving and contact service center to inspect the vehicle. < Restart the vehicle after 2~3 min when it is turned over. Do not drive exce ssively long distance and take enough break. 43 -fiۿ~ 2005. 12. 29 5:16 PM á^44 DRIVING METHOD DRIVING POSITION The appropriate driving position is the most important thing to driving safely. Arms : Relieve the tension and bend arms to inside and let them act as the spring. [. . . ]