User manual DAELIM DAYSTAR VL125L

[. . . ] OWNER S MANUAL (VL125L) IMPORTANT NOTICE OPERATOR AND PASSENGER This motorcycle is designed to carry the operator and one passenger. ON-ROAD USE This motorcycle is designed to be used only on the road. READ THIS OWNER'S MANUAL CAREFULLY Pay special attention to statements preceded by the following words: WARNING Indicates a strong possibility of severe personal injury or death if instructions are not followed. CAUTION Indicates a possibility of personal injury or equipment damage if instructions are not followed. NOTE Gives helpful information. This manual should be considered a permanent part of the motorcycle and should remain with the motorcycle when resold or otherwise transferred to a new owner or operator. CONTENTS SPECIFICATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 SAFETY PRECAUTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 CORRECT ATTIRE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ] In case of contact, flush thoroughly with water and call a doctor if your eyes were exposed. KEEP OUT OF REACH OF CHILDREN. ENGINEC STOP In addition, check hose and pipe protective part to sec if they make contact with other parts when you make left or right turn due to vibration during travel. Put main stand in upright position on a flat ground and operate steel wheel, and check fluid when the top of master cylinder cap is level. If fluid significantly low, it may indicate fluid leakage on brake system. If this happens, check fluid leaks or damage on system and inspect joints and clamps for looseness. CAUTION Brake is an important part which protects your life. Make sure to inspect brake prior to daily use. 23 <REPLENISHING BRAKE FLUID> Move steering wheel and set the top of reserve tank level. Clean dust and other foreign matter from around master cylinder and take caution not to allow foreign matter to fall inside master cylinder Open cap screw and remove diaphragm. Replenish recommended brake fluid to upper level inside master cylinder. Tighten cap accurately, paying attention to the direction of diaphragm assembling, and avoid ingress of foreign matter. RECOMMENDED BRAKE FLUID IS DOT 3 CAUTION Do not fill brake fluid above upper level as it may cause brake fluid to leak outside. Exercise full caution, when replenishing brake fluid, not to allow dust or water to mix inside master cylinder. If the amount of brake fluid decreases considerably, it is an indication of brake system trouble. To prevent occurrence of chemical change, do not use brake fluid of different manufacturer. Do not let brake fluid contact vehicle parts because it causes damage to painted parts. 24 [REAR WHEEL] <BRAKE PAD INSPECTION> Operate brake and, if the brake pad wear limit line reaches the brake disc side, it indicates the pad has reached wear limit. Push the brake pedal with hands for resistance and check if the pedal movement appropriate. If brake pedal movement is inappropriate, adjust the pedal free play using the rear wheel brake adjuster nut. After adjustment, push the brake pedal with hands until you feel resistance and verify the pedal free play is within prescribed level. BRAKE PEDAL FREE PLAY : 20~30mm 25 TIRES <BRAKE SHOE INSPECTION> Push brake pedal completely and, if the brake arm arrow and the " " on brake panel match each other, it indicates brake shoe has reached its life limit. <TIRE PRESSURE CHECK> Check for an appropriate level of air pressure by examining how the tire sits on the ground. If you notice any abnormalities in the shape of the tire with regard to the area contacting the ground, use a tire gauge to check tire pressure and adjust the tire pressure to the appropriate level. <TIRE PRESSURE> SIZE 90/90-18 130/90-15 FRONT 2. 00 1 PERSON RIDING REAR 2. 00 FRONT REAR 2. 00 2. 00 <CRACKS/DAMAGE> Check tire tread and sides for cracks and damage. CAUTION In case brake pad or shoe reaches the wear limit line, replace it immediately. Worn brake pad can cause an accident due to lack of power TIRE PRESSURE 2 PERSON FRONT (kg/ ) RIDING REAR <ABNORMAL WEAR> Check tire tread for signs of abnormal wear. 26 BATTERY <FOREIGN MATTER> Check tire tread and sides for nails, rocks, etc. <TREAD DEPTH> Check the wear indicator(wear limit marking) to see if there is an insufficient amount of tread remaining. [. . . ] CAUTION Return the side stand to its original position, keep driving without doing this may cause turnover accident. Also, if the wheel is transformed when advancing directly to the walkway, the vehicle can be overturned resulting in injury of the driver due to the driving unstability. Overspeed driving on the unpaved road can cause the vehicle to be overturned resulting in injury of the driver due to the driving unstability. If any gravel enters the wheel or engine case, the vehicle can be overturned resulting in injury of the driver. [. . . ]