User manual COLEMAN 9995A700

[. . . ] Event Grill 9995A Series INSTRUCTIONS FOR USE © 2004 The Coleman Company, Inc. www. coleman. com IMPORTANT Read this manual carefully before assembling, using or servicing this grill. If you have questions about assembly, operation, servicing or repair of this grill, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. The handling, storage and transportation of gas cylinders must be in accordance with ANSI/NFPA 58, Storage and Handling of Liquified Gases, or CSA B149. 1, Natural Gas and Propane Installation Code. The owner shall post in a prominent location instructions to be followed in the event the user smells gas. This informatin shall be obtained by consulting the local gas supplier. · 9-volt Battery included · 20# L. P. [. . . ] Attach Regulators to Propane Cylinder Connections and hand-tighten. 7 To Set Up continued Step 6 LEFT LID (SHELF) CENTER LID RIGHT LID (SHELF) To Set Up continued Step 7 Install two Grease Pans from front as shown. Unlock Right Side Lid. Release flaps to form Right Side Shelf. LID FLAPS Step 8 Install 9-Volt Battery with positive (+) terminal as shown on Igniter Module. IMPORTANT: Always remove Lids in this order: Right Lid first. Center Lid last. · · · Carefully insert Shelf Lip on Right Side Shelf into Top Channel, while at the same time making sure the Notches on the side Flaps fit into the Flanges on the grill body. SHELF LIP DETAIL "A" Igniter Module SHELF LIP Leak Testing TOP CHANNEL DANGER TO PREVENT FIRE OR EXPLOSION HAZARD: · NO SMOKING. DO NOT use or permit sources of ignition in the area while doing a leak test. · NEVER perform a leak test with fire or flame. TOP CHANNEL NOTCH NOTCH DETAIL "B" How to Check for Leaks 1. Make a soapy solution of equal parts mild liquid dishwashing detergent and water. Turn cylinder valve knob counterclockwise (right to left) one rotation. If bubbles appear at these areas, a leak is indicated. FLANGE FLANGE 15 Repeat the same order for attaching the Left Side Shelf as you did on the Right Side Shelf. Remove Center Lid and set aside until ready for storage of the grill. 8 Fixing a Fuel Leak If you detect a leak: 1. Push in and turn on control knobs to release pressure in hose, then return the control knobs to OFF. Stop a leak by tightening the loose joint, or by replacing the faulty part with a replacement part recommended by Coleman. DO NOT attempt to repair the cylinder valve if it should become damaged; the cylinder MUST be replaced. If you are unable to stop a leak, shut off the gas supply at the cylinder valve. Perform a leak test each time the gas supply cylinder is connected to the regulator. Have a dealer check the cylinder for deterioration after 12 years, according to DOT regulations. Immediately replace cylinder if any deterioration is found Lighting the Grill WARNING THE FOLLOWING RULES MUST ALWAYS BE FOLLOWED IN THIS ORDER : 1. gas cylinder, turn the top cylinder valve knob counterclockwise to open. DO NOT stand with head or arms over grill. WARNING This procedure MUST be performed OUTDOORS only!Read and follow directions on the cylinder and fuel hose safety tags. CAUTION In the connection process, the grill side of the connection will seal on the back-check in the valve, resulting in a slight resistance. The connection requires about one-half to three-quarters additional turn to complete the connection. DO NOT use tools. CAUTION Inspect the gas supply hoses before each use. If there are cuts, damage, excessive abrasion or wear, replace the hoses prior to operating the appliance. [. . . ] Check burner, orifices and venturi for blockage (bugs, dirt, cobwebs). Fuel flow is restricted. Excessive yellow flames. 13 Replacement Parts 9995 Event Grill Parts List No. 1 2 3 4 5 6 7 8 9 10 11 12 13 Part No. 9943-1501 9990-5481 9995-1191 9995-1511 9995-1551 9995-1571 9995-2021 9995-2051 9995-2161 9995-2181 9995-3861 9995-5601 9995-3911 Description Control Knobs w/graphics Castors w/lock (2) Heat Tent w/hardware Cooking Grate Igniter Switch w/wires Bumpers w/hardware Burner w/hardware End Lid Grease Pan Center Lid Assembly Igniter Module Hose/Regulator Assembly Hose Assembly 10 4 3 7 8 13 1 12 5 12 9 11 6 2 14 Notes 15 Warranty Coleman Limited One-Year Warranty The Coleman Company, Inc. ("Coleman") warrants that for a period of one year from the date of original retail purchase, this product will be free from defects in material and workmanship. Coleman, at its option, will repair or replace this product or any component of the product found to be defective during the warranty period. [. . . ]