User manual COLEMAN 9995-B750

[. . . ] Event Grill 9995B Series INSTRUCTIONS FOR USE © 2005 The Coleman Company, Inc. www. coleman. com IMPORTANT Read this manual carefully before assembling, using or servicing this grill. If you have questions about assembly, operation, servicing or repair of this grill, please call Coleman at 1-800-835-3278 or TDD: 316-832-8707. The handling, storage and transportation of gas cylinders must be in accordance with ANSI/NFPA 58, Storage and Handling of Liquified Gases, or CSA B149. 1, Natural Gas and Propane Installation Code. The owner shall post in a prominent location instructions to be followed in the event the user smells gas. This information shall be obtained by consulting the local gas supplier. · 9-volt Battery included · 20# L. P. [. . . ] 26 The storage position for the regulator is above the grease pan. 27) Remove the regulator from the clip attached to the bottom of grill. 28 Attach the regulator to the propane cylinder connection and hand-tighten. 29) Repeat Step 4 and Step 5 to attach the second cylinder on the left side. Fig. 33 Repeat the same order for attaching the Left Side Shelf as you did on the Right Side Shelf. Remove Center Lid and set aside until ready for storage of the grill. Fig. 29 8 To Set Up continued Step 7 Install two Grease Pans from front as shown. Push in and turn on control knobs to release pressure in hose, then return the control knobs to OFF. Stop a leak by tightening the loose joint, or by replacing the faulty part with a replacement part recommended by Coleman. DO NOT attempt to repair the cylinder valve if it should become damaged; the cylinder MUST be replaced. If you are unable to stop a leak, shut off the gas supply at the cylinder valve. Perform a leak test each time the gas supply cylinder is connected to the regulator. Have a dealer check the cylinder for deterioration after 12 years, according to DOT regulations. Immediately replace cylinder if any deterioration is found Step 8 Install 9-Volt Battery with positive (+) terminal as shown on Igniter Module. If there are cuts, damage, excessive abrasion or wear, replace the hoses prior to operating the appliance. gas cylinder, insure that all gas supply hoses are free of kinks and/or damage and are at least 3" away from hot surfaces such as the grill housing. Use only hose replacements specified in the parts list. Leak Testing DANGER TO PREVENT FIRE OR EXPLOSION HAZARD: · NO SMOKING. DO NOT use or permit sources of ignition in the area while doing a leak test. · NEVER perform a leak test with fire or flame. Start-Up Check List WARNING Failure to follow these safety steps before using grill each time could result in a fire that could be hazardous to you, your appliance or property. It is especially important to observe these steps after the grill has been stored, moved or cleaned. If it is evident that there is excessive abrasion or wear, or the hose is cut, it must be replaced prior to the grill being put into operation. Below 40°F the grill performance is reduced by cold temperatures. How to Check for Leaks 1. [. . . ] Check burner, orifices and venturi for blockage (bugs, dirt, cobwebs). Fuel flow is restricted. Excessive yellow flames. 13 Replacement Parts 9995B Series Event Grill Parts List No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 Part No. 9995A2181 9995A1511 9995-2411 9995-1191 9995-2021 9995-1571 9995A2051 9995A5601 9995-5201 9995-5701 9990-5491 9995-2161 9995A1551 9995-3861 9995-5151 9995A2031 9995-1681 9995A1651 9943-1501 Description Center Lid Assembly - Black Cooking Grate (1 pk) Spacer w/hardware (1 pk) Heat Tent w/hardware Burner w/hardware (1 pk) Bumper w/hardware (1 pk) End Lid Assembly - Black (1 pk) Regulator/Hose Assembly - (1 pk) Right Leg Assembly - Black Tank Retainer Straps (1 pk) Castor w/lock (1 pk) Grease Pan (1 pk) Igniter Switch w/wires Igniter Module Left Leg Assembly - Black Drip Pan Assy (1 pk) Latch (for drain pan) (1 pk) Bracket w/hardware (for regulator) (1pk) Control Knobs w/graphics (1 pk) 1 2 3 4 5 19 6 17 16 8 7 18 9 15 10 14 14 13 12 11 Accessories The following accessories are available: · Griddle 9995A350 · Cover 9995-099 Visit us at www. coleman. com or Call us at 1-800-835-3278 15 Warranty Coleman Limited One-Year Warranty The Coleman Company, Inc. ("Coleman") warrants that for a period of one year from the date of original retail purchase, this product will be free from defects in material and workmanship. Coleman, at its option, will repair or replace this product or any component of the product found to be defective during the warranty period. [. . . ]