User manual CHAMBERLAIN ATS 2113X

[. . . ] 845 Larch Avenue Elmhurst, Illinois 60126-1196 www. liftmaster. com ® COMMERCIAL DOOR OPENER Model ATS 2113X 1/2 HP For Residential And Light Duty Commercial Use Install on Sectional Doors Only L O W H I G H L A NO R M H I G H L O W L A NO R M WN DO E RC FO UP E RC FO Owner's Manual Please read this manual and the enclosed safety materials carefully!The door WILL NOT CLOSE unless the Protector System® is connected and properly aligned. The model number label is located on the front panel of your opener. TABLE OF CONTENTS Introduction 2-5 Adjustment 20-22 Safety symbol and signal word review. . . . . . . . . . . . . . . . . . . . . . . . 2 Preparing your garage door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Tools needed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Planning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Carton inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Hardware inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Adjust the travel limits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20 Adjust the force . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 Test the safety reversal system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 Test the Protector System® . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 Operation 23-25 Assembly 6-7 Attach the rail to the motor unit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Attach the chain to the sprocket and install the rail support bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Tighten the chain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Operation safety instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Using your garage door opener . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Using the wall-mounted door control . . . . . . . . . . . . . . . . . . . . . . . . 24 To open the door manually. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Care of your garage door opener. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24 Having a problem?. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 Installation 7-19 Programming 26-28 Installation safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Determine the header bracket location . . . . . . . . . . . . . . . . . . . . . . . 8 Install the header bracket. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Attach the rail to the header bracket. . . . . . . . . . . . . . . . . . . . . . . . . 10 Position the opener . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Hang the opener. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Install the door control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Install the light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Attach the emergency release rope and handle . . . . . . . 13 Electrical requirements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Install the Protector System® . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-17 Fasten the door bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 Connect the door arm to the trolley . . . . . . . . . . . . . . . . . . . . . . . . . . 19 3-Button remote controls (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . . 26 To add or change a Keyless Entry PIN (Optional) . . . . 27 Multi-Function door control (Optional). . . . . . . . . . . . . . . . . . . . . . . 28 Repair Parts 29-32 Rail assembly parts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 Installation parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 Motor unit assembly parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 Accessories Repair Parts and Service Warranty 31 32 32 INTRODUCTION Safety Symbol and Signal Word Review This garage door opener has been designed and tested to offer safe service provided it is installed, operated, maintained and tested in strict accordance with the instructions and warnings contained in this manual. WARNING Mechanical CAUTION WARNING WARNING Electrical WARNING CAUTION When you see these Safety Symbols and Signal Words on the following pages, they will alert you to the possibility of serious injury or death if you do not comply with the warnings that accompany them. [. . . ] Do not increase the force beyond the minimum amount required to close the door. Test the UP (open) force · Grasp the door bottom when the door is about halfway through UP (open) travel. If the door is hard to hold or doesn't stop, DECREASE UP (open) force by turning the control counterclockwise. After each adjustment, run the opener through a complete travel cycle. · If the door doesn't open at least 5 feet (1. 5 m), INCREASE UP (open) force by turning the control clockwise. After each adjustment, run the opener through a complete travel cycle. 21 WARNING Without a properly installed safety reversal system, persons (particularly small children) could be SERIOUSLY INJURED or KILLED by a closing garage door. · Too much force on garage door will interfere with proper operation of safety reversal system. · NEVER increase force beyond minimum amount required to close garage door. · NEVER use force adjustments to compensate for a binding or sticking garage door. · If one control (force or travel limits) is adjusted, the other control may also need adjustment. · After ANY adjustments are made, the safety reversal system MUST be tested. Door MUST reverse on contact with 1-1/2" (3. 8 cm) high object (or 2x4 laid flat) on floor. CAUTION Force Adjustment Controls 1 2 3 9 7 5 3 1 9 7 5 3 1 KG KG Back Panel of Opener 9 7 5 3 1 9 7 5 3 1 KG Adjustment Label KG ADJUSTMENT STEP 3 Test the Safety Reversal System TEST · With the door fully open, place a 1-1/2" (3. 8 cm) board (or a 2x4 laid flat) on the floor, centered under the garage door. ADJUST · If the door stops on the obstruction, it is not traveling far enough in the down direction. Increase the DOWN limit by turning the DOWN limit adjustment screw counterclockwise 1/4 turn. NOTE: On a sectional door, make sure limit adjustments do not force the door arm beyond a straight up and down position. · When the door reverses on the 1-1/2" (3. 8 cm) board, remove the obstruction and run the opener through 3 or 4 complete travel cycles to test adjustment. IMPORTANT SAFETY CHECK: Repeat Adjustment Steps 1, 2 and 3 after: · Each adjustment of door arm length, limits, or force controls. · Any repair to or adjustment of the garage door (including springs and hardware). · Any repair to or adjustment of the opener. WARNING Without a properly installed safety reversal system, persons (particularly small children) could be SERIOUSLY INJURED or KILLED by a closing garage door. · If one control (force or travel limits) is adjusted, the other control may also need adjustment. · After ANY adjustments are made, the safety reversal system MUST be tested. [. . . ] SIMPLY DIAL OUR TOLL FREE NUMBER: HOW TO ORDER REPAIR PARTS Selling prices will be furnished on request or parts will be shipped at prevailing prices and you will be billed accordingly. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFORMATION: · PART NUMBER · PART NAME · MODEL NUMBER ADDRESS ORDERS TO: THE CHAMBERLAIN GROUP, INC. Country Club Road Tucson, Arizona 85706 SERVICE INFORMATION TOLL FREE NUMBER: 1-800-528-2817 HOURS: (Central Std. - Sunday www. liftmaster. com For professional installation, parts and service, contact your local LIFTMASTER/CHAMBERLAIN dealer. [. . . ]