User manual CHAMBERLAIN 3595 3-4 HP

[. . . ] 845 Larch Avenue Elmhurst, Illinois 60126-1196 www. liftmaster. com ® GARAGE DOOR OPENER Model 3595 3/4 HP For Residential Use Install on Sectional Doors ONLY THIS OPERATOR IS INTENDED FOR USE ONLY WITH I-BEAM RAILS. Owner's Manual Please read this manual and the enclosed safety materials carefully!The door WILL NOT CLOSE unless the Protector System® is connected and properly aligned. The model number label is located under the light lens on the left side panel of your opener. TABLE OF CONTENTS Introduction 2-5 Operation 23-26 Safety symbol and signal word review. . . . . . . . . . . . . . . . . . . . . . . . 2 Preparing your garage door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Tools needed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 Planning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Carton inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Hardware inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 Operation safety instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Using your garage door opener . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23 Using the wall-mounted door control . . . . . . . . . . . . . . . . . . . . . . . . 24 Using the remote control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 The remote control batteries . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 To open the door manually. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 Care of your garage door opener. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 Having a problem?. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26-27 Smart Control PanelTM messages. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28 Assembly 6-7 Attach the rail to the motor unit. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Attach the chain spreader . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Attach chassis support bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 Tighten the chain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Programming 29-30 Installation 7-19 Installation safety instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7 Determine the header bracket location . . . . . . . . . . . . . . . . . . . . . . . 8 Install the header bracket. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9 Attach the rail to the header bracket. . . . . . . . . . . . . . . . . . . . . . . . . 10 Position the opener . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 Hang the opener. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11 Install the door control. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 Install the light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13 Attach the emergency release rope and handle . . . . . . . 13 Electrical requirements. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 Install the Protector System® . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-17 Fasten the door bracket . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18 Connect the door arm to the trolley . . . . . . . . . . . . . . . . . . . . . . . . . . 19 To add or reprogram a hand-held remote control . . . . . 29 To erase all codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 3-Button remotes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29 To add, reprogram or change a Keyless Entry PIN . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 Repair Parts 31-32 Rail assembly parts. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 Installation parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 Motor unit assembly parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32 Accessories Notes Repair Parts and Service Warranty 33 34-35 36 36 Adjustment 20-22 Adjust the UP and DOWN travel limits. . . . . . . . . . . . . . . . . . . . . . 20 Adjust the force . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21 Test the safety reversal system. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 Test the Protector System® . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22 INTRODUCTION Safety Symbol and Signal Word Review This garage door opener has been designed and tested to offer safe service provided it is installed, operated, maintained and tested in strict accordance with the instructions and warnings contained in this manual. When you see these Safety Symbols and Signal Words on the following pages, they will alert you to the possibility of serious injury or death if you do not comply with the warnings that accompany them. [. . . ] After each adjustment, run the opener through a complete travel cycle. Without a properly installed safety reversal system, persons (particularly small children) could be SERIOUSLY INJURED or KILLED by a closing garage door. · Too much force on garage door will interfere with proper operation of safety reversal system. · NEVER increase force beyond minimum amount required to close garage door. · NEVER use force adjustments to compensate for a binding or sticking garage door. · If one control (force or travel limits) is adjusted, the other control may also need adjustment. · After ANY adjustments are made, the safety reversal system MUST be tested. Door MUST reverse on contact with 1-1/2" high (3. 8 cm) object (or 2x4 laid flat) on floor. Force Adjustment Controls 1 1 9 3 7 5 9 3 7 5 KG KG Right Panel Antenna FORCE ADJUSTMENT LABEL 9 7 5 KG 3 1 9 7 5 KG 3 1 Open Force Close Force 21 ADJUSTMENT STEP 3 Test the Safety Reversal System TEST · With the door fully open, place a 1-1/2" (3. 8 cm) board (or a 2x4 laid flat) on the floor, centered under the garage door. ADJUST · If the door stops on the obstruction, it is not traveling far enough in the down direction. Increase the DOWN limit by turning the DOWN limit adjustment screw counterclockwise 1/4 turn. NOTE: On a sectional door, make sure limit adjustments do not force the door arm beyond a straight up and down position. · When the door reverses on the 1-1/2" (3. 8 cm) board, remove the obstruction and run the opener through 3 or 4 complete travel cycles to test adjustment. · If the unit continues to fail the Safety Reverse Test, call for a trained door systems technician. IMPORTANT SAFETY CHECK: Test the Safety Reverse System after: · Each adjustment of door arm length, limits, or force controls. · Any repair to or adjustment of the garage door (including springs and hardware). Without a properly installed safety reversal system, persons (particularly small children) could be SERIOUSLY INJURED or KILLED by a closing garage door. · If one control (force or travel limits) is adjusted, the other control may also need adjustment. · After ANY adjustments are made, the safety reversal system MUST be tested. Door MUST reverse on contact with 1-1/2" high (3. 8 cm) object (or 2x4 laid flat) on the floor. 1-1/2" (3. 8 cm) board (or a 2x4 laid flat) ADJUSTMENT STEP 4 Test The Protector System® · Press the remote control push button to open the door. The door will not move more than an inch (2. 5 cm), and the opener lights will flash. The garage door opener will not close from a remote if the indicator light in either sensor is off (alerting you to the fact that the sensor is misaligned or obstructed). If the opener closes the door when the safety reversing sensor is obstructed (and the sensors are no more than 6" [15 cm] above the floor), call for a trained door systems technician. [. . . ] Enhanced functions include Lock Feature to lock out outside radio signals while you are away from home and turn opener lights on or off from the control panel. Remote Light Control: Enables homeowner to turn on a lamp, television or other appliance from their car with their garage door opener remote or from anywhere in their home with an additional LiftMaster Security® remote. 975LM Laser Park Assist: Laser enables homeowners to precisely park vehicles in the garage. 373P Security® 3-Button Remote Control: Includes visor clip. 990LM 370LM 3-Button Mini-Remote Control with Security®: With key ring and fastening strip. Surge Protector: The Garage Door Opener Surge Protector is designed to protect ® LiftMaster garage door openers against damage from lightning and power surges. 33 NOTES 34 NOTES 35 LIFTMASTER® SERVICE IS ON CALL OUR LARGE SERVICE ORGANIZATION SPANS AMERICA INSTALLATION AND SERVICE INFORMATION IS AS NEAR AS YOUR TELEPHONE. SIMPLY DIAL OUR TOLL FREE NUMBER: HOW TO ORDER REPAIR PARTS Selling prices will be furnished on request or parts will be shipped at prevailing prices and you will be billed accordingly. WHEN ORDERING REPAIR PARTS, ALWAYS GIVE THE FOLLOWING INFORMATION: · PART NUMBER · PART NAME · MODEL NUMBER ADDRESS ORDERS TO: THE CHAMBERLAIN GROUP, INC. Country Club Road Tucson, Arizona 85706 SERVICE INFORMATION TOLL FREE NUMBER: 1-800-528-9131 www. liftmaster. com For professional installation, parts and service, contact your local LIFTMASTER/CHAMBERLAIN dealer. [. . . ]