User manual CARRIER 69NT40-551-500 SERVICE PARTS LIST REV E

[. . . ] In dehumidification mode, the controller will operate to reduce internal container moisture level. 3. 3 Control Box Units are equipped with either an aluminum material box and may be fitted with a lockable door. 3. 4 Temperature Readout The unit is fitted with suction and discharge temperature sensors. 3. 5 Pressure Readout The unit is fitted with suction and discharge transducers. [. . . ] SV = Suffix SV - added to part number designates service replacement part. T-334PL vi 1 QUICK LIST - CLAMPS, FILTER-DRIER, FUSE, TY-WRAPS, WIRE TERMINALS PART NO. DESCRIPTION 34--00373--51 Clamp, Tube, 1/4 -- SST 34--00373--53 Clamp, Tube, 3/8 -- SST 34--00373--05 Clamp, Tube, 1/2 -- SST 34--00373--07 Clamp, Tube, 5/8 -- SST 34--00373--59 Clamp, Tube, 3/4 -- SST 34--00373--11 Clamp, Tube, 7/8 -- SST 34--00373--65 Clamp, Tube, 1--1/8 -- SST 34--00373--88 Clamp, Tube, 1--1/4 -- SST 34--00373--69 Clamp, Tube, 1--3/8 -- SST 34--00373--71 Clamp, Tube, 1--1/2 -- SST 22--00066--01 Connector, Butt End, Wire Range -- 22 to 16 AWG 22--00066--02 Connector, Butt End, Wire Range -- 16 to 14 AWG 22--00066--03 Connector, Butt End, Wire Range -- 12 to 10 AWG 22--00041--00 Connector, Closed End, Wire Range -- 22 to 14 AWG 22--00041--02 Connector, Closed End, Wire Range -- 18 to 10 AWG 14--00341--04 Filter--Drier 22--02336--02 Fuse, 5 Amp (F1 and F2) 22--02336--04 Fuse, 10 Amp (FEB) 22--02336--08 Fuse, 7. 5 Amp (F3A and F3B) 22--01140--01 Ring Terminal, #6, Wire Range -- 12 to 10 AWG 22--01140--02 Ring Terminal, #10, Wire Range -- 12 to 10 AWG 22--01140--04 Ring Terminal, 3/8, Wire Range -- 12 to 10 AWG 22--00119--04 Ring Terminal, 1/4, Wire Range -- 12 to 10 AWG 22--00120--04 Ring Terminal, #10, Wire Range -- 16 to 14 AWG 22--00120--07 Ring Terminal, 5/16, Wire Range -- 16 to 14 AWG 22--00121--07 Ring Terminal, #10, Wire Range -- 22 to 16 AWG 22--01139--04 Ring Terminal, 3/8, Wire Range -- 16 to 14 AWG 22--01141--01 Spade Terminal, 1/4 X 5/16, Wire Range -- 16 to 14 AWG 22--00595--01 Spade Terminal, 3/8, Wire Range -- 12 to 10 AWG 22--01106--00 Spiral Wrap, 1/4 Diameter X 25 ft. Long 66U1--3803 Tube, Heat Shrink, 1/4 ID X 2--1/8 Long 66U1--3803--1 Tube, Heat Shrink, 1/2 ID X 2--3/4 Long 44--01043--05 Ty--Wraps, 5--1/2 inches Long 44--01043--07 Ty--Wraps, 11. 00 inches Long 22--50007 Series Wire Markers 07--00345--00 Sealant, Pipe (Used to seal fittings on unit with R--134a) 07--00313--00 Cleaner, Coil 1 T-334PL 2 REFRIGERATION UNIT ASSEMBLY 2. 1 REFRIGERATION UNIT - AREA LOCATOR 1 4 2 1 2 3 5 38 6 7 8 9 10 11 12 13 14 15 16 17 18 31 30 29 28 27 26 23 24 25 21 20 22 19 36 37 34 35 33 32 40 39 41 42 T-334PL 2 2. 1 REFRIGERATION UNIT Item Section Number 1 Refer to Section 2. 2 2 Refer to Section 2. 3 3 Refer to Section 2. 4 4 Refer to Section 2. 5 5 Refer to Section 2. 6 6 Refer to Section 2. 7 7 Refer to Section 2. 8 8 Refer to Section 2. 9 9 Refer to Section 2. 10 10 Refer to Section 2. 11 11 Refer to Section 2. 12 12 Refer to Section 2. 13 13 Refer to Section 2. 14 14 Refer to Section 2. 15 15 Refer to Section 2. 16 16 Refer to Section 2. 17 17 Refer to Section 2. 18 18 Refer to Section 2. 19 19 Refer to Section 2. 20 20 Refer to Section 2. 21 21 Refer to Section 2. 22 22 Refer to Section 2. 23 23 Refer to Section 2. 24 24 Refer to Section 2. 25 25 Refer to Section 2. 26 26 Refer to Section 2. 27 27 Refer to Section 2. 28 28 Refer to Section 2. 29 29 Refer to Section 2. 30 30 Refer to Section 2. 31 31 Refer to Section 2. 32 32 Refer to Section 2. 33 33 Refer to Section 2. 34 34 Refer to Section 2. 35 35 Refer to Section 2. 36 36 Refer to Section 2. 37 37 Refer to Section 2. 38 38 Refer to Section 2. 39 39 Refer to Section 2. 40 40 Refer to Section 2. 41 41 Refer to Section 2. 42 42 Refer to Section 2. 43 NS Refer to Section 2. 44 NS Refer to Section 2. 45 NS Refer to Section 3. 1 - AREA LOCATOR (Continued) Area Description Upper Fresh Air Upper Fresh Air -- eAutoFresh Bulkhead Penetration -- Upper Air Exchange Thermometer Port Rain Gutters USDA Control Box -- Door Control Box -- Shield Control Box -- Wiring Control Box -- RMU Receptacle and Switch Panel -- No RM and Internal Views Control Box -- RMU Receptacle and Switch Panel -- External View Control Box -- Remote Monitoring Unit (RMU) Control Box -- Controller Module Section and Software Cards Control Box Preparation Controller Hardware, Clamps and Display -- Facing View Controller Hardware, Clamps and Display -- Details Controller Hardware, Clamps and Display -- Rear View Handles Compressor Transducers / Pressure Switch Compressor, Mounting Components and Guard Compressor Tubing Cable and Compressor Guards Economizer Receiver Water--Cooled Condenser Condenser Coil and Covers Condenser Fan Motor Voltage Cables Autotransformer Cable Restraint Components Interrogator Receptacle Vacuum Relief Valve / Controlled Atmosphere Drain Electronic Temperature Recorder -- Options 9 and P Electronic Temperature Recorder -- Options 12 and 13 Bulkhead Penetration -- Lower Air Exchange Lower Fresh Air Make--up Labels and Decals Evaporator Tubing and Coil Evaporator Fan Assembly Heaters and Sensors Back Panel Assembly Harness -- Low Voltage Harness -- High Voltage DataLine/Data Reader 3 T-334PL 2. 2 UPPER FRESH AIR 10, 8, 9 3 2 4 1 5 7, 8, 9 6 FRONT VIEW FOR TIR EQUIPPED UNITS - LOCATION OPTIONAL SIDE VIEW OPTION 1 T-334PL 4 2. 2 UPPER FRESH AIR (Continued) Item Part Number Description OPTION 1 - ACCESS PANEL ONLY 79-01697-06SV Panel Assembly, Access, Evaporator, White -- Includes: 1 79-01697-17SV Panel Assembly, Access, Evaporator, Orange -- Includes: 2 58-04378-01 Panel, Access 3 42-00327-00 Gasket, 0. 26 x 0. 50 Half-round 4 42-00296-01 Gasket, Evaporator Access Panel 68-11989-00 Cover, Top, Evaporator Access Panel, White 5 68-11989-01 Cover, Top, Evaporator Access Panel, Orange 6 66U1-5562-2 Plug Button 7 34-06154-00 Screw, Hex Head, 1/4-20 x 1. 00 Long - TIR 8 34-06053-13 Washer, Mylar 9 34-06212-12 Washer, Plain - 1/4 10 34-00655-08 Screw, Hex Head, 1/4-20 x 1. 00 Long Qty A/R A/R 1 1 1 A/R A/R 1 A/R 8 8 A/R 5 T-334PL 2. 2 UPPER FRESH AIR (Continued) 3 4 5 13, 14, 19 13, 14, 18 (POSITION OPTIONAL) 2 6 1 BACK OF FRESH AIR PANEL 20 (OPTION 3 ONLY) 9 10 11 12 7 8 OPTIONS 2, 3, and 4 15 16 21 OPTION 5 - VPS 26 25 24 23 3 22 27 28 17 or 29 30 T-334PL 6 2. 2 UPPER FRESH AIR (Continued) Item Part Number Description STANDARD PARTS FOR OPTIONS 2, 3 and 4 1 79-01695-00 Panel Assembly, Access -- Includes: 2 58-04376-03 Panel, Access 3 68-12940-00 Cover, Top, Evaporator Access Panel 4 42-00296-01 Gasket, Evaporator Access Panel 5 42-00327-00 Gasket, 0. 26 x 0. 50 Half-Round 6 66U1-5562-2 Plug Button, 1. 25 Diameter Hole 7 68-12933-00 Disc, 12. 35 Diameter 8 42-00407-00 Gasket, 0. 50 Fresh Air Disc 9 34-06185-01 Screw, Machined, #8-32 x 0. 50 with Nylock 10 66U1-5362-2 Nut, Wing, 5/16-18 - SST 11 66U1-5321-13 Washer, Plain 5/16 W Type A - SST 12 34-06053-19 Washer, Mylar 1. 00 OD x 0. 312 ID 13 34-06053-13 Washer, Mylar, 1/4 ID x 0. 80 OD 14 34-006212-12 Washer, Flat, 1/4 - SST 15 66CH1-1172-2 Trim, Flexible 2. 00 Long 16 58-00969-00 Wire Tie 2. 80 Diameter, Double Loop 17 66U1-8292-1 Cap, Insulating 0. 125 OD Black Qty 1 1 1 1 1 1 1 1 1 1 1 1 8 8 1 1 3 7 T-334PL 2. 2 UPPER FRESH AIR (Continued) Item Part Number Description OPTION 2 - UPPER FRESH AIR INSTALLED WITH STANDARD FASTENERS See Previous Section for Standard Parts and use with Items Below: 18 34-06154-00 Screw, Hex Head, 1/4-20 x 1. 00 Long - TIR 19 34-00655-08 Screw, Hex Head, 1/4-20 x 1. 00 Long OPTION 3 - UPPER FRESH AIR INSTALLED WITH SCREENS See Previous Section for Standard Parts and use with Items Below: 18 34-06154-00 Screw, Hex Head, 1/4-20 x 1. 00 Long - TIR 19 34-00655-08 Screw, Hex Head, 1/4-20 x 1. 00 Long 20 58-04251-00 Screen, Medfly, USDA, 16 x 16 OPTION 4 - UPPER FRESH AIR INSTALLED WITH STAINLESS STEEL FASTENERS See Previous Section for Standard Parts and use with Items Below: 18 34-66627-00 Screw, Hex Head, 1/4-20 x 1. 00 Long - TIR 19 66U1-5361-50 Screw, Hex Head, 1/4-20 x 1. 00 Long Qty 2 6 2 6 2 2 6 T-334PL 8 2. 2 UPPER FRESH AIR (Continued) Item Part Number Description OPTION 5 - VENT POSITIONING SENSOR INSTALLED 79-66626-00 Panel Assembly, Access, White -- Includes: 1 79-66626-01 Panel Assembly, Access, Orange -- Includes: 2 58-04376-05 Panel, Access 68-12940-05 Cover, Top, Evaporator Access Panel, White 3 68-12940-03 Cover, Top, Evaporator Access Panel, Orange 4 42-00296-01 Gasket, Evaporator Access Panel 5 42-00327-00 Gasket, 0. 26 x 0. 50 Half-round 6 66U1-5562-2 Plug Button, 1. 25 Diameter Hole 68-12933-07 Disc, 12. 35 Diameter, White 7 68-12933-05 Disc, 12. 35 Diameter, Orange 8 42-00407-00 Gasket, 0. 50 Fresh Air Disc 9 34-06185-01 Screw, Pan Head, #8-32 x 0. 50 with Nylock 10 66U1-5362-2 Nut, Wing, 5/16-18 - SST 11 66U1-5321-13 Washer, Plain 5/16 W Type A - SST 12 34-06053-19 Washer, Mylar 1. 00 OD x 0. 312 ID 21 66U1-2552-185 Gasket 13 34-06053-13 Washer, Mylar, 1/4 ID x 0. 80 OD 14 34-06212-12 Washer, Flat, 1/4 - SST 15 66CH1-1172-2 Trim, Flexible 2. 00 Long 16 58-00969-00 Wire Tie 2. 80 Diameter, Double Loop 17 66U1-8292-1 Cap, Insulating 0. 125 OD Black (NOT USED IN THIS ASSEMBLY) 18 34-06154-00 Screw, Hex Head, 1/4-20 x 1. 00 Long - TIR 19 34-00655-08 Screw, Hex Head, 1/4-20 x 1. 00 Long 20 58-04251-00 Screen, Medfly, USDA, 16 x 16 (NOT USED IN THIS ASSEMBLY) 22 34-00928-02 Rivet, Blind 0. 125 Diameter 0. 126-0. 187 23 NSS Nut, Self Lock, 1/4-20 24 NSS Plate 25 NSS Bracket, Sensor 26 NSS Sensor, Rotary Position 27 22-01613-10 Plug, 4-Pin 28 22-01613-13 Contact, Socket #16 29 22-01613-11 Lock, 4-Pin - Secondary 30 22-01660-08 Plug, 0. 12 Diameter x 0. 58 Qty A/R A/R 1 A/R A/R 1 1 1 A/R A/R 1 1 1 1 1 1 8 8 1 1 3 2 6 2 2 1 2 2 1 1 3 1 1 9 T-334PL 2. 3 UPPER FRESH AIR - EAUTOFRESH 5 6 7 8 9 10 FOR PANEL ASSEMBLY, SEE PAGE 12-13 11 2 1 12 3 4 10 14 10 13 15 16 17 2 19 20 21 22 23 6 7 34 35 36 37 33 22 10 24 6 25 16 17 18 10 26 27 31 32 3 10 29 30 6 26 28 6 26 38 T-334PL 10 2. 3 UPPER FRESH AIR - EAUTOFRESH (Continued) Item Part Number Description 1 40--00601--05 Tube, Support 1/4 OD X 0. 040 W 2 22--01713--26 Harness, eAutoFresh, ML3 (SEE SECTION 2. 44, OPTION 8) 3 22--01713--20 Harness, Plug (SEE SECTION 2. 44, OPTION 8) 4 58--00065--77 Grommet, 0. 38 ID X 1. 25 OD 5 10--00388--00 Powerpack, Stepper Motor 6 66U1--5371--6 Screw, Mach Hex Head #10--24 X 0. 750 Slotted 7 66U1--5321--8 Washer, Plain #10 Type A 8 66CH1--1172--2 Trim, Flexible 2. 00 Long 9 44--00361--00 Clip, Retaining 0. 88--1. 00 Wire Mtg 10 66U1--3882 Wire Tie 1/16--1--3/4 Selflocking 11 58--04251--01 Screen, 16 X 16 Mesh 12 58--04251--02 Screen, 16 X 16 Mesh 13 22--01713--21 Harness, Plug (SEE SECTION 2. 44, OPTION 8) 14 22--01835--00 Connector, 5 Socket Weatherpack 15 34--06154--00 Screw, Captive Hex Head 1/4--20 X 1. 00 TIR 16 34--06053--13 Washer, Retaining 0. 19 ID X 0. 80 OD (0. 250) 17 34--06212--12 Washer, Plain 1/4 N Type A 18 34--00655--08 Screw, Captive Hex Head 1/4--20 X 1. 00 19 68--14739--00 Bracket, 0. 063 Thick Alum 20 34--00928--03 Rivet, Blind 0. 125 Diameter 0. 188--0. 250 21 58--00065--84 Grommet, 0. 25 X 0. 50 X 0. 187 Panel 22 58--04497--01 Tube, 1/4 OD X 6. 25 L 23 40--00640--00 Union, Bulkhead Double Brb/Comp Align 24 58--04497--04 Tube, 1/4 OD X 7. 75 L 25 68--14738--00 Bracket, Mounting 0. 090 Thk Alum 26 34--00373--07 Clamp, Tube 0. 62 Diameter Cushion 27 KA70PP048 Fitting, Hose 1/8 ID Barb X 1/8 NPT 28 30--00415--01 Filter Assembly, Sample Air, 1/8 NPT 29 40--00297--00 Coupling, 1/8 X 1/8 Pipe Thread 30 40--00108--03 Coupling, Half Union 31 22--01613--08 Receptacle, 4 Pin 32 22--01613--09 Lock, Secondary 4 Pin (R) 33 58--00065--78 Grommet, 0. 25 ID X 1. 25 OD 34 10--00398--00 Sensor Carbon Dioxide -- Includes: 35 22--01613--10 Plug 36 22--01613--11 Lock 37 22--06163--15 Socket 38 22--01777--03 Contact Socket, 20 AWG Qty 1 1 1 1 1 10 4 1 2 11 1 1 1 1 2 8 8 6 1 2 1 2 1 1 1 2 1 1 2 1 1 1 1 1 1 1 1 7 11 T-334PL 2. 3 UPPER FRESH AIR - EAUTOFRESH (Continued) 1 10 11 12 13 14 15 16 13 14 17 18 10 11 23 24 22 13 14 21 20 19 3 4 5 6 7 8 2 FOR SCREENS, SEE PAGES 10 -11 9 T-334PL 12 2. 3 UPPER FRESH AIR - EAUTOFRESH (Continued) Item Part Number Description 79--66643--00 eAutoFresh White Panel Includes: 1 79--66643--01 eAutoFresh Orange Panel Includes: 2 66U1--2552--185 Gasket 3 58--66642--00 Panel Assembly -- Includes: 68--11989--08 Cover, Access, White 4 68--11989--10 Cover, Access, Orange 5 34--00928--09 Rivet, Blind 86--66704--00 Box Assembly, Recess, White 6 86--66704--01 Box Assembly, Recess, Orange 7 42--00296--01 Gasket 8 42--00327--00 Gasket 9 66U1--5562--2 Plug Button 10 58--66640--00 Collar 11 34--00928--06 Rivet, Blind 12 58--66644--00 Rail Top 13 66U1--6651--26 Screw, Machine Pan Head 14 34--00662--08 Washer, Plain 15 79--66640--00 Plate Assembly -- Slide 16 62--66697--00 Label Warning, eAutoFresh 68--14715--00 Grille, White 17 68--14715--01 Grille, Orange 18 58--04026--56 Protector 19 62--66701--00 Label, eAutoFresh 20 79--66642--00 Plate Assembly -- Gasket 21 58--66645--00 Rail Bottom 22 34--66642--09 Screw, Flat Head 79--66641--00 Cup Assembly, White -- Includes: 23 79--66641--01 Cup Assembly, Orange -- Includes: 24 22--02392--03 Connector, Female Qty A/R A/R 1 1 A/R A/R 16 A/R A/R 1 1 1 2 8 1 12 15 1 1 A/R A/R 7 1 1 1 4 A/R A/R 1 13 T-334PL 2. 4 BULKHEAD PENETRATION - UPPER AIR EXCHANGE 3 4 10 11 12 1 5 6 7 8 9 2 OPTION 1 Item Part Number Description OPTION 1 - NOT INSTALLED 1 58--00616--00 Plug, Hole 2. 00 Diameter X 0. 12 Panel 2 66U1--5562--2 Plug Button, 1. 25 Diameter Hole OPTION 2 - STANDARD INSTALLED 3 58--04290--01 Fitting, Bulkhead 4 34--00928--04 Rivet, Blind, 1/8 Diameter, Grip Range 1/4 -- 5/16 5 22--01602--02 Bushing, 0. 625 ID X 0. 88 Long 6 58--04302--01 Grommet, 0. 25 ID X 1. 25 Long 7 69NT35--8258 Disc, 0. 040 Thick Aluminum 8 22--01602--03 Gotcha Ring, 0. 312--0. 375 9 22--01733--01 Nut, Straight (with TIR Holes) 10 34--06154--00 Screw, Captive Hex Head 1/4--20 X 1. 00 TIR 11 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 12 66U1--5321--7 Washer, Plain 1/4 W Type A OPTION 2 Qty 1 1 1 4 1 1 1 1 1 1 1 1 T-334PL 14 2. 5 THERMOMETER PORT 3 4 2 1 Item Part Number OPTION 1 - SUPPLY AIR PORT 1 66U1--8662 Cap and Chain Assembly 2 62--10557--00 Label OPTION 2 - RETURN AIR PORT 3 66U1--8662 Cap and Chain Assembly 4 62--10557--00 Label OPTION B - SUPPLY AND RETURN PORTS 1, 3 66U1--8662 Cap and Chain Assembly 2, 4 62--10557--00 Label 2. 6 RAIN GUTTERS 1 2 Description Qty 1 1 1 1 2 2 3 4 Item Part Number OPTION 1 - BOLTED 1 69NT35--3997--1 2 69NT35--3987 OPTION 4 - RIVETED 3 68--12417--00 4 34--00928--13 Description Gutter, Rain (Bolted, Standard -- Left Side) Gutter, Rain (Bolted, Standard -- Right Side) Gutter, Rain (Riveted -- Right and Left Side) Rivet, Blind 0. 187 Diameter 0. 126--0. 250 Qty 1 1 2 6 15 T-334PL 2. 7 USDA 9 1 2 3 4 5 6 4 7 8 10 2 OPTIONS D AND V 13 15 14 16 OPTION P 17 OPTION 1 OR 2 11 12 T-334PL 16 2. 7 USDA (Continued) Item Part Number Description OPTION D 1 Receptacle (PR1, PR2, PR3, Cargo Probe 4) (3--Pin) (Refer to Section 2. 44) 2 69NT35--636--1 Tether Assembly 3 22--01660--02 Cap, Dust, (3--Pin Receptacle) 4 22--01660--08 Plug, Sealing 5 66U1--5371--7 Screw, Mach Hex Head, #10--24 X 0. 500 Slotted 6 68--14444--00 Panel Assembly, 0. 063 Thick Alum 7 Receptacle, Interrogator (ICR), 5--Pin (Refer to Section 2. 44) 8 22--01660--05 Cap, Dust (5--Pin Receptacle) 9 34--06142--00 Rivet, 0. 110 Diameter 0. 126--. 250 10 22--02205--00 Connector Splice, Non--insulated NS 66U1--3882 Wire Tie, 1/16--1--3/4 Self--Locking 11 69NT35--6118 Label, USDA 12 62--10902--03 Label, MI3, USDA, Blue OPTION V 1 Receptacle (PR1, PR2, PR3, Cargo Probe 4) (3--Pin) (Refer to Section 2. 44) 4 22--01660--08 Plug, Sealing 5 66U1--5371--7 Screw, Machine Hex Head, #10--24 X 0. 500 Slotted 6 68--14444--01 Panel Assembly, 0. 063 Thick Aluminum 7 Receptacle, Interrogator (5--Pin) (Refer to Section 2. 44) 8 22--02413--00 Cap, Dust, 5--Pin 10 22--02205--00 Connector, Splice, Non--Insulated 2 69NT35--636--1 Tether Assembly 3 22--01660--02 Cap, Dust, 3--Pin Receptacle 9 34--06142--00 Rivet, 0. 110 Diameter 0. 126--. 250 NS 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 11 62--11274--00 Label, USDA OPTION P 13 68--14628--00 Plate 14 34--00928--09 Rivet, Blind, 0. 156 Diameter FIELD INSTALLED KITS (FOR UNITS WITH USDA PROVISIONS) 76--00676--00 Kit, USDA (For field installation, units provisioned for side-mounted -USDA) -- Includes all of OPTION D USDA PROBE KITS OPTION 1 15 12--50089--00 Sensor Assembly, 600" Long (15M) (USDA Probe) -- Includes: 16 22--50127--00 Plug, Socket (PR1, PR2, PR3, Cargo Probe 4) 17 22--01613--15 Contact, Socket, #16 (Used with 22-50127-00 and 22-01660-04) OPTION 2 12--00342--04 Sensor Assembly, Customer Specific, 600" Long (15M) (USDA Probe) -15 Includes: 16 22--50127--00 Plug, Socket (PR1, PR2, PR3, Cargo Probe 4) 17 22--01613--15 Contact, Socket, #16 (Used with 22-50127-00 and 22-01660-04) Qty 5 4 4 7 1 1 25 5 4 1 1 4 7 1 1 4 4 4 25 4 1 1 6 -- A/R 1 A/R A/R 1 A/R 17 T-334PL 2. 8 CONTROL BOX - DOOR - 7 8 13 6 9 10 11 12 3 4 5 17 14 15 16 1 25 26 27 23 24 26 28 29 2 18 19 20 28 30 22 OPTION 4 - FLAT WINDOW - 21 23 24 26 27 29 OPTION 5 - LATCHING DOOR - T-334PL 18 2. 8 CONTROL BOX - DOOR (Continued) Item Part Number Description OPTION 2 - DOOR ASSEMBLY, BLUE, SLOTTED FASTENERS 1 74--66608--00 Door Assembly, Blue, with Slotted Fasteners -- Includes: 2 86--04461--00 Door, Control Box 3 66U1--6811--8 Screw, Retaining 0. 300--0. 625, Slotted 4 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 5 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind, 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 58--04366--00 Window, Controller Door OPTION 3 - DOOR ASSEMBLY, BLUE, WING FASTENERS 1 74--66608--02 Door Assembly, Blue, with Wing Fasteners -- Includes: 2 86--04461--00 Door, Control Box 3 66U1--6811--15 Screw, Retaining 0. 300--0. 625, Wing 4 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 5 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind, 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 58--04366--00 Window, Controller Door Qty 1 2 4 2 1 2 2 4 4 4 4 2 3 1 2 1 1 2 4 2 1 2 2 4 4 4 4 2 3 1 2 1 19 T-334PL 2. 8 CONTROL BOX - DOOR (Continued) Item Part Number Description OPTION 4 - DOOR ASSEMBLY, BLUE, WING FASTENERS AND FLAT WINDOW 1 74--66608--03 Door Assembly, Blue, with Wing Fasteners and Flat Window -- Includes: 2 86--04461--00 Door, Control Box 3 66U1--6811--15 Screw, Retaining 0. 300--0. 625, Wing 4 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 5 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind, 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 NSS Window Assembly, Flat -- Includes: 18 42--00611--00 Foam, Double Coated 19 69NT35--5022--6 Window 20 68--14817--00 Bracket, Mounting 21 34--00795--09 Nut, Self Lock 10--32 22 68--13724--00 Bracket, Mounting OPTION 5 - DOOR ASSEMBLY, BLUE, LATCHES 1 74--66608--04 Door Assembly, Blue, with Latches -- Includes: 2 86--66688--01 Door, Control Box, Latch 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind, 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 58--04366--00 Window 23 58--04026--74 Protector, Latch 24 44--66605--00 Latch 25 66U1--6651--22 Screw, Mach Pan Head 8--32 X 3/4 26 34--00663--08 Washer, Lock 27 66U1--5321--2 Washer, Plain 28 34--66621--04 Washer, Lock 29 66U1--6651--2 Screw, Mach Pan Head 8--32 X 1/2 30 48--66611--00 Pin, Guide Qty 1 2 4 2 1 2 2 4 4 4 4 2 3 1 2 1 1 1 2 6 1 1 1 2 2 4 4 4 4 2 3 1 2 1 2 2 1 4 4 1 3 1 T-334PL 20 2. 8 CONTROL BOX - DOOR (Continued) Item Part Number Description OPTION 6 - DOOR ASSEMBLY, BLUE, PHILLIPS FASTENERS 1 74--66608--01 Door Assembly, Blue, with Phillips Fasteners -- Includes: 2 86--04461--00 Door, Control Box 3 66U1--6811--12 Screw, Retaining 0. 300--0. 625, Phillips 4 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 5 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind, 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 58--04366--00 Window, Controller Door OPTION 6 - DOOR ASSEMBLY, ORANGE, PHILLIPS FASTENERS 1 74--66608--05 Door Assembly, Orange, with Phillips Fasteners -- Includes: 2 86--04461--02 Door, Control Box 3 66U1--6811--12 Screw, Retaining 0. 300--0. 625, Phillips 4 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 5 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 58--04366--00 Window, Controller Door Qty 1 2 4 2 1 2 2 4 4 4 4 2 3 1 2 1 1 2 4 2 1 2 2 4 4 4 4 2 3 1 2 1 21 T-334PL 2. 8 CONTROL BOX - DOOR (Continued) Item Part Number Description OPTION 6 - DOOR ASSEMBLY, WHITE, PHILLIPS FASTENER 1 74--66608--06 Door Assembly, White, with Phillips Fasteners -- Includes: 2 86--04461--20 Door, Control Box 3 66U1--6811--12 Screw, Retaining 0. 300--0. 625, Phillips 4 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 5 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 6 42--00270--02 Gasket, Control Box Door 7 44--00300--00 Hinge Assembly, With Tethered Pin 8 34--01167--01 Nut, Retainer 10--24 X 1. 75 9 66U1--2403--1 Screw, 10--24 X 0. 750 Slotted 10 34--00663--09 Washer, Lock 10 Spring 11 66U1--5321--8 Washer, Plain 10 Type A 12 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 13 58--04101--00 Protector 1. 00 X 2. 63 14 34--06107--00 Rivet, Blind 0. 125 Diameter 0. 188--0. 250 15 58--04389--00 Pocket 16 66U1--3882 Wire Tie, 1/16--1--3/4, Self--Locking 17 58--04366--00 Window, Controller Door Qty 1 2 4 2 1 2 2 4 4 4 4 2 3 1 2 1 T-334PL 22 2. 9 CONTROL BOX - SHIELD 7 8 5 10 6 9 14 15 2 1 3 4 11 13 5 6 9 5 6 9 16 12 Qty 1 2 4 2 2 2 4 2 1 OPTION 1 - HIGH VOLTAGE SHIELD Item Part Number Description 1 69NT43--125--1 Shield, High Voltage -- Includes: 2 NSS Panel, High Voltage 3 44--00343--00 Hinge 4 34--00928--02 Rivet, Blind, 0. 125 Diameter, 0. 126--0. 187 5 34--06139--01 Stud, Retaining, 1/4" 6 34--06139--00 Retainer, Stud, 1/4" 7 AU27JR--131 Washer, Lock 8 66U1--2403 Screw, 10--24 X 0. 50 Inch 9 34--06139--04 Receptacle, Retaining, 1/4" 10 62--03957--04 Decal, Warning High Voltage OPTION 2 - LOW VOLTAGE SHIELD 11 69NT43--124--4SV Shield, Low Voltage -- Includes: 12 NSS Panel, Low Voltage 13 34--06152--00 Fastener, Hook and Lock 14 66U1--3882 Wire Tie 1/16--1--3/4 Self locking 15 69NT35--636--2 Tether Assembly 16" Long 5 34--06139--01 Stud 1/4" Retaining 6 34--06139--00 Retainer 1/4" Stud 9 34--06139--04 Receptacle 1/4" Retaining 16 69NT35--9952 Angle (See Section 2. 17 for EBS bracket) 1 1 2 1 4 4 2 1 23 T-334PL 2. 10 24 14 23 21 22 2 20 16 17 18 19 CONTROL BOX - WIRING 25 26 25 27 4 29 PA PB HR CF ES EF 13 14 15 12 2, 11 6, 7, 8, 9, 10 54 3 1, 2 Contactor Arrangement - Standard Configuration - 30 PA PB S2 HR S1 E1 CH CF PA ES PB HR EF CF E2 Contactor Arrangement Single Fan Capability Contactor Arrangement Three-Phase Evaporator Motors 16 31 16 31 32 34 32 WIRING DETAIL 33 T-334PL 24 2. 10 CONTROL BOX - WIRING (Continued) Item Part Number Description 1 10--00332--06 Transformer Base Unit 2 34--06223--00 Screw, Captive Wash #10--24 X 0. 56 3 66CH1--1172--52 Trim, Flexible 4. 00 Long 4 10--00431--06 Contactors (CF, HR, EF, ES, E1, E2, S1, S2) 5 69NT35--9073--1 Label CB1 (0. 81 X 3. 19) 6 66U1--7842--12 Circuit Breaker 3 Pole, 600 Volt 7 66U1--6651--19 Screw, Mach Pinhead #6--32 X 0. 437 Slotted 8 34--00663--07 Washer, Lock #6 Spring 9 66U1--7842--6 Nut, Hex 10--32 Circuit Breaker 10 66U1--7842--7 Washer, Flat #10--32 11 69NT35--6278 Bracket 0. 080 Thick Aluminum, Plated 12 69NT35--9073 Label, CB1 (0. 56 X 1. 55) 13 34--00655--10 Screw, Cap Hex Head 1/4--20 X 1. 25 14 66U1--5321--7 Washer, Plain 1/4 W Type A 15 34--06053--13 Washer, Retaining 0. 19 ID X. 80 OD (0. 250) 16 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 17 34--00663--09 Washer, Lock #10 Spring 18 66U1--5371--7 Screw, Mach Hex Head #10--24 X 0. 500 Slotted 19 58--04246--00 Ty--Rap Base (#10) Mounting Tab 10--00439--01 Transformer, Current Sensor -- Includes: 20 22--01622--00 Connector 22--01622--03 Terminal 21 66U1--1251--2 O--Ring 3/4 Hub Sealing 22 66U1--7352--3 Connector, Straight, Watertight 23 34--00655--08 Screw, Cap Hex Head 1/4--20 X 1. 00 24 58--00967--00 Spacer Locking (Subpanel) 25 10--00431--07 Contactors (CH, PA, PB) 26 62--11018--00 Label, Contactor Cover 27 10--00431--08 Cover, Contactor 28 34--06243--00 Screws #8--32 X 0. 750, Slotted, SST 29 58--04316--00 Base, Mounting 0. 250 Diameter Mounting Hole 30 34--01178--22 Screw, Hex Head, #8--32 X 1/2 Long -- SST 31 58--04273--00 Grommet Split 0. 69 X 1. 88 X 0. 12 32 44--00361--00 Clip, Retaining 0. 88--1. 00 Wire Mounting 33 66U2--1132--1 Connector, Electric, 16--14 Gage, Non--Insulated 34 66U1--3803 Tube, Heat Shrink 0. 25 X 2. 12 Black Qty 1 10 2 A/R 1 1 4 4 6 12 1 1 1 5 1 52 1 1 1 1 1 4 1 1 4 5 A/R 2 2 2 4 1 2 4 9 9 25 T-334PL 2. 11 13 CONTROL BOX - RMU RECEPTACLE, SWITCH PANEL, NO RMU, INTERNAL VIEWS 12 13 12 13 12 13 12 OPTIONS 1, 2 13 12 13 OPTION 3 12 OPTIONS 4, 5 12 13 OPTIONS 6, 7 9 OPTION 8 OPTION 9 2 3 OPTION 10 1 4 22 23 15 5 6 7 19 18 15 8 17 11 16 14 20 21 10 SEE OPTIONS FOR SPECIFIC PLATE AND LABEL CONFIGURATION T-334PL 26 2. 11 CONTROL BOX - RMU RECEPTACLE, SWITCH PANEL, NO RMU, INTERNAL VIEWS (Continued) Item Part Number Description Qty STANDARD PARTS INCLUDED IN OPTIONS Key Pad Assembly - Includes: 1 1 79--66669--00 2 NSS Plate, Backup Keypad, Composite Box 1 3 NSS Key Pad, Core Micro 1 4 NSS Gasket Keypad, 0. 125 Thick 1 Dot, Indicator (Green) - See NOTE 1 5 NSS 6 34--06212--10 Washer, Plain #10 Type A 6 7 34--66630--00 Screw, Pinhead #10--9 X 0. 75 Long 6 8 34--66629--05 Screw, Machined Thread #10--24 X 0. 750 Slotted 4 9 44--00391--00 Clamp 1 10 66U1--9752 Seal 0. 427/0. 432, Bushing 2 11 42--00608--00 Gasket Switch Plate 1 OPTION 1 - NO REMOTE MONITORING, START SWITCH PLATE See Previous Section for Standard Parts and use with Items Below: 12 68--14796--00 Plate, Switch 1 13 62--10914--00 Switch Label, ST 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 2 OPTION 2 - NO REMOTE MONITORING, START WITH BOOT SWITCH PLATE See Previous Section for Standard Parts and use with Items Below: 12 68--14796--00 Plate, Switch ST 1 13 62--10914--00 Switch Label, ST 1 14 66U2--1081 Boot Toggle Switch 1 OPTION 3 - NO REMOTE MONITORING, CFS SWITCH PLATE See Previous Section for Standard Parts and use with Items Below: 12 68--14796--01 Plate, Switch ST, Compressor Fan Switch 1 13 62--10914--01 Switch Label, ST, CFS 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 2 OPTION 4 - NO REMOTE MONITORING, MANUAL DEFROST SWITCH PLATE See Previous Section for Standard Parts and use with Items Below: 12 68--14796--05 Plate, Switch ST, Manual Defrost 1 13 62--10914--05 Switch Label, ST, MD 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 2 OPTION 5 - NO REMOTE MONITORING, MD WITH BOOT SWITCH PLATE See Previous Section for Standard Parts and use with Items Below: 12 68--14796--05 Plate, Switch ST, Manual Defrost 1 13 62--10914--05 Switch Label, ST, MD 1 14 66U2--1081 Boot Toggle Switch 2 OPTION 6 - NO RM, AMBER DEFROST LIGHT See Previous Section for Standard Parts and use with Items Below: 12 68--14796--02 Plate, Switch ST, DL 1 13 62--10914--02 Switch Label, ST, EMER, DEFROST 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 1 15 22--00518--01 Base Pilot Light 1 16 22--00049--01 Lamp, Incandescent, 24 VDC 1 17 22--00519--03 Jewel Assembly Pilot Light, Amber 1 NOTE If unit is not fitted with a green indicator dot (see Item 5) on upper right corner of the control box door, install dot as illustrated. 27 T-334PL 2. 11 CONTROL BOX - RMU RECEPTACLE, SWITCH PANEL, NO RMU, INTERNAL VIEWS (Continued) Item Part Number Description Qty OPTION 7 - NO RM, RED DEFROST LIGHT See Previous Section for Standard Parts and use with Items Below: 12 68--14796--02 Plate, Switch ST, DL 1 13 62--10914--02 Switch Label, ST, EMER, DEFROST 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 1 15 22--00518--01 Base Pilot Light 1 16 22--00049--01 Lamp, Incandescent, 24 VDC 1 17 22--00519--01 Jewel Assembly Pilot Light, Red 1 OPTION 8 - WITH REMOTE MONITORING, INTERNAL See Previous Page for Standard Parts and use with Items Below: 12 68--14796--03 Plate, Switch ST, RM 1 13 62--10914--03 Switch Label, ST, RM 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 1 18 34--00848--10 Screw, Machined Roundhead #4--40 X 0. 625 4 19 22--02341--01 Cap and Tether Receptacle Assembly 1 20 22--01604--00 Receptacle, 4 Connections 1 21 MS510074 Gasket 1 22 66U1--5321--6 Washer, Plain 0. 125 ID Type A 4 23 34--00667--05 Nut, Self Lock 4--40 4 OPTION 9 - WITH REMOTE MONITORING AND MD SWITCH, INTERNAL See Previous Page for Standard Parts and use with Items Below: 12 68--14796--06 Plate, Switch ST, RM, MD 1 13 62--10914--06 Switch Label, ST, RM, MD 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 1 18 34--00848--10 Screw, Machined Roundhead #4--40 X 0. 625 4 19 22--02341--01 Cap and Tether Receptacle Assembly 1 20 22--01604--00 Receptacle 4 Connections 1 21 MS510074 Gasket 1 22 66U1--5321--6 Washer, Plain 0. 125 ID Type A 4 23 34--00667--05 Nut, Self Lock 4--40 4 OPTION 10 - WITH REMOTE MONITORING AND AMBER DEFROST LIGHT, INTERNAL See Previous Page for Standard Parts and use with Items Below: 12 68--14796--04 Plate, Switch ST, RM, EB, DL 1 13 62--10914--04 Switch Label, ST, RM, EMER, DEFROST 1 14 10--01129--20 Nut, Hex 15/32--32 Un--2B 1 15 22--00518--01 Base Pilot Light 1 16 22--00049--01 Lamp Incandescent, 24 VDC 1 17 22--00519--03 Jewel Assembly Pilot Light Amber 1 18 34--00848--10 Screw, Machined Roundhead #4--40 X 0. 625 4 19 22--02341--01 Cap and Tether Receptacle Assembly 1 20 22--01604--00 Receptacle 4 Connections 1 21 MS510074 Gasket 1 22 66U1--5321--6 Washer, Plain 0. 125 ID Type A 4 23 34--00667--05 Nut, Self Lock 4--40 4 T-334PL 28 2. 12 CONTROL BOX - RMU RECEPTACLE AND SWITCH PANEL, EXTERNAL VIEW 19 27 6 28 29 OPTION 11 12 13 29 30 26 25 24 OPTION 11 - WITH REMOTE MONITORING, EXTERNAL Item Part Number Description 2 58--04456--00 Plate, Backup Keypad, Comp Box (See NOTE) 3 12--00290--04 Key Pad, Core Micro (See NOTE) 4 42--00271--00 Gasket Keypad, 0. 125 Thick (See NOTE) 6 34--06212--10 Washer, Plain #10 Type A 7 34--66630--00 Screw, Pinhead #10--9 X 0. 75 Long (See NOTE) 8 34--66629--05 Screw, Machined Thread #10--24 X 0. 750 Slotted (See NOTE) 9 44--00391--00 Clamp (See NOTE) 10 66U1--9752 Seal 0. 427/0. 432, Bushing (See NOTE) 11 42--00608--00 Gasket Switch Plate (See NOTE) 12 68--14796--00 Plate, Switch ST 13 62--10914--00 Switch Label, ST 19 22--02341--01 Cap and Tether Receptacle Assembly 24 69NT40--222 Bracket Assembly 25 34--00928--03 Rivet, Blind 0. 125 Diameter 0. 188--0. 250 26 66U1--3882 Wire Tie, 1/16--1--3/4 Self--locking 27 22--02205--00 Connector Splice, Non--Insulated 28 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 29 66U1--3882--3 Wire Tie, 1/16--4. 0 Self--locking 30 58--04316--00 Base, Mounting 0. 250 Diameter Mounting Hole Qty 1 1 1 6 6 4 1 2 1 1 1 1 1 4 4 1 2 2 3 NOTE See Section 2. 11 (page 26) for Items 2, 3, 4, 7, 8, 9. 29 T-334PL 2. 13 CONTROL BOX - REMOTE MONITORING UNIT (RMU) - 1 2 3 6 4 5 T-334PL 30 2. 13 CONTROL BOX - REMOTE MONITORING UNIT (RMU) - Continued Item Part Number Description OPTION 2 - COMMUNICATIONS INTERFACE MODULE - HIGH DATA RATE 1 12--00573--01SV Module, Communications Interface -- Includes: 2 66U1--3442--2 Stud, Fastener, 1/4 Turn, 0. 705 Long -- SST 3 66U1--9212--1 Retainer, Push--on 4 34--06223--00 Screw, Captive Washer #10--24 X 0. 56 -- SST 5 58--01184--01 Retainer, Screw 0. 75 OD 6 22--01556--00 Connector (CIA) 7--Pin OPTION 4 - COMMUNICATIONS INTERFACE MODULE - LOW DATA RATE 1 12--00275--19SV Module, Communications Interface -- Includes: 2 66U1--3442--2 Stud, Fastener, 1/4 Turn, 0. 705 Long -- SST 3 66U1--9212--1 Retainer, Push--on 4 34--06223--00 Screw, Captive Washer #10--24 X 0. 56 -- SST 5 58--01184--00 Retainer, Screw 0. 75 OD 6 22--01556--00 Connector (CIA) 7--Pin Qty 1 4 4 2 2 1 1 4 4 4 4 1 31 T-334PL 2. 14 CONTROL BOX - CONTROLLER MODULE SECTION AND SOFTWARE CARDS 15 17 7 1 2 3 4 18 14 12 13 17 11 5 16 6 8 9 10 View - Back of Controller/DataCORDER - T-334PL 32 2. 14 CONTROL BOX - CONTROLLER MODULE SECTION AND SOFTWARE CARDS (Continued) Item Part Number Description 1 12--55009 Module, Controller/DataCORDER -- Includes: 2 66U1--5371--7 Screw, Hex Head, #10--24 X 1/2 Long -- SST 3 69NT35--2692 Washer, Fender, 0. 063 Thick -- SST 4 58--01184--00 Retainer, Screw, 0. 141 ID 5 22--02336--08 Fuse, 7. 5 Amp (F3A and F3B) 6 22--02336--02 Fuse, 5 Amp (F1 and F2) 7 62--02719--00 Label, Controller/DataCORDER Port 8 12--00594 Controller/DataCORDER Operation Software Card (Latest version will be supplied) 9 Connector (EC A--K) (Refer to Section 2. 44) 10 Connector (EC L--Y) (Refer to Section 2. 44) 11 Connector (KA) -- 14--Pin (Refer to Section 2. 45 ) 12 Connector (KB) -- 10--Pin (Refer to Section 2. 45 ) 13 Connector (KD) -- 4--Pin (Refer to Section 2. 45 ) 14 Connector (KE) -- 5--Pin (Refer to Section 2. 44) 15 Connector (MA) -- 12--Pin (Refer to Section 2. 45 ) 16 Connector (MC) -- 8--Pin (Refer to Section 2. 10) NS 09--00375--00 Battery, Real Time Clock, (Within the Controller) 22--01713--06 Wire Harness, Display Module to Controller/DataCORDER Module -Includes: 22--01621--02 Connector (MB) -- 16--Pin (At Display) 17 22--01621--00 Terminal (MB) -- 16--Pin (At Display) 22--01622--02 Connector (MB) -- 16--Pin (At Controller) 22--01622--03 Terminal (MB) -- 16--Pin (At Controller) NS 62--02735--00 Label, Warning, (Don't use 12--00327) -- (Located on the control box behind the Controller/DataCORDER module. ) NS 62--02738--08 Label, Warning, 55xx Series -- (Located on the high and low voltage shields) NS 62--02738--04 Label, Warning, 55xx Series -- (Located on the bottom panel of the control box between the Communications Interface module and the switch panel. ) OPTION R - RECHARGEABLE BATTERY OPTION 18 30--00407--02SV Rechargeable Battery Pack with Connector--Controller/DataCORDER Module OPTION S - SECURE RECHARGEABLE BATTERY OPTION NOTE 76--50149--00 Rechargeable Battery Pack with Connector--Controller/DataCORDER Module Qty 1 1 1 1 3 1 1 1 1 1 1 1 1 1 1 1 1 A/R A/R NOTE Refer to technical manual for battery location. 33 T-334PL 2. 15 CONTROL BOX PREPARATION 1 2 3 4 5 6 7 10 9 8 3 4 19 21 LATCHED DOOR - OPTION 1 18 22 24 OPTION 1 ONLY 4 23 24 20 17 GROUND WIRE 12 11 16 15 11 4 23 14 13 Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 66U1--5562--7 Plug Button, 1. 125 Diameter Hole 2 58--00701--03 Plug Button, 0. 906 Diameter Hole 3 68--15270--00 Bracket, 0. 090 Thick Aluminum 4 34--06223--00 Screw, Captive Wash #10--24 X 0. 56 5 62--10911--00 Label, Warning!6 66U1--2593--19 Gasket, "V" Type 6. 38 Long 7 58--00967--00 Spacer Locking (Subpanel) 8 34--00655--10 Screw, Captive Hex Head 1/4--20 X 1. 25 9 66U1--5321--7 Washer, Plain 1/4 W Type A 10 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 11 69NT41--982--3 Strap Assembly Ground, All Populated 12 66U1--5321--3 Washer, Plain 1/4 N Type A 13 AU27JR--171 Washer, Lock 1/4 Ext Tooth 14 AT39JA--171 Nut, Hex 1/4--20 15 66U1--9592--13 Standoff 1/4--20 X 0. 375 Long 16 34--00667--11 Nut, Self Lock 1/4--20 24, 27 22, 25, 26 LOCKING DOOR - OPTION 5 - 27 25, 26 STANDARD DOOR OPTIONS 2, 3, 4 Qty 1 2 1 3 1 1 2 2 2 4 1 2 10 10 2 2 T-334PL 34 2. 15 CONTROL BOX PREPARATION (Continued) Item Part Number Description OPTION 1 - LATCH FASTENER, BLUE BOX (LATCHING DOOR LOCATED IN SECTION 2. 8) See Previous Page for Standard Parts and use with Items Below: 17 86--04636--00 Control Box, Blue 18 68--66776--01 Bracket, Latch Closure, Blue 19 86--66689--00 Stop, Door Latch, Latch Closure, Blue 20 68--66773--01 Keeper, Latch Closure 21 58--04026--70 Protector, 0. 88 X 2. 93 2 Holes 22 34--00928--02 Rivet, Blind 0. 125 Diameter 0. 126--0. 187 OPTION 2 - SCREW FASTENERS, BLUE BOX See Previous Page for Standard Parts and use with Items Below: 86--04636--00 Control Box, Blue 17 86--04636--02 Control Box, Blue, with EBS 23 69NT35--6272 Bracket, 0. 063 Thick Aluminum, Blue 24 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 25 34--01142--01 Receptacle, #12 Saddle Type 26 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 27 58--04026--32 Protector, 0. 75 X 1. 06 Mylar OPTION 2 - SCREW FASTENERS, ORANGE BOX See Previous Page for Standard Parts and use with Items Below: 17 86--04636--01 Control Box, Orange 23 69NT35--6272--1 Bracket, 0. 063 Thick Aluminum, Orange 24 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 25 34--01142--01 Receptacle, #12 Saddle Type 26 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 27 58--04026--32 Protector, 0. 75 X 1. 06 Mylar OPTION 2 - SCREW FASTENERS, WHITE BOX See Previous Page for Standard Parts and use with Items Below: 17 86--04636--03 Control Box, White 23 69NT35--6272--2 Bracket, 0. 063 Thick Aluminum, White 24 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 25 34--01142--01 Receptacle, #12 Saddle Type 26 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 27 58--04026--32 Protector, 0. 75 X 1. 06 Mylar OPTION 3 - SCREW FASTENER, LOCKING DOOR, BLUE BOX See Previous Page for Standard Parts and use with Items Below: 17 86--04636--00 Control Box, Blue 22 34--00928--02 Rivet, Blind 0. 125 Diameter, 0. 126--0. 187 23 69NT35--2287 Bracket, 12 Gage SST 24 34--06053--11 Washer, 0. 205 ID X 0. 922 OD 25 34--01142--01 Receptacle, #12 Saddle Type 26 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 27 58--04026--32 Protector, 0. 75 X 1. 06 Mylar Qty 1 1 1 1 1 2 1 1 1 2 2 4 2 1 1 2 2 4 2 1 1 2 2 4 2 1 2 1 1 2 4 2 35 T-334PL 2. 16 CONTROLLER HARDWARE, CLAMPS AND DISPLAY - FACING VIEW 9 4 7 8 10 1 2 OR 3 4 11 12 SMV 4 5 6 1 2 TO ICF CONTROL BOX REMOVED FOR CLARITY 13 14 27 1 2 26 ESV LIV 24 25 2 16 17 18 15 20 21 20 STS PROBE 19 SRS PROBE 22 23 14 28 T-334PL 36 2. 16 CONTROLLER HARDWARE, CLAMPS AND DISPLAY - FACING VIEW (Continued) Item Part Number Description 1 58--04316--00 Base, Mounting 0. 250 Diameter Mounting Hole 2 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 3 66U1--3882--3 Wire Tie 1/16--4. 0 Self--locking 4 66U1--5361--25 Screw, Captive Hex Head 1/4--20 X 0. 75 5 34--06053--03 Washer 0. 250 ID X 1. 000 OD 6 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 7 AU27JR--171 Washer, Lock 1/4 Ext Tooth 8 34--06223--00 Screw, Captive Wash #10--24 X 0. 56 9 58--04101--01 Protector 1. 00 X 3. 62 (Hinge) 10 66U1--2552--171 Gasket 0. 62 Thick X 0. 75 X 16. 00 11 66U1--5321--7 Washer, Plain 1/4 W Type A 12 34--06053--00 Washer 0. 250 ID X 0. 800 OD 13 44--00449--00 Clamp Assembly 14 42--00032--00 Insulation Prestite 15 44--00449--01 Clamp Assembly 16 58--04279--00 Cover Plastic, Probe 17 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 18 66U1--5321--8 Washer, Plain #10 Type A 19 12--00395--02 Sensor Assembly (STS and SRS) 20 58--04277--00SV Cap, Probe -- Includes: 21 58--04278--00 Grommet NSS 22 58--04276--00 Holder Supply Probe 23 34--00928--04 Rivet, Blind 0. 125 Diameter 0. 251--0. 312 24 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 Slotted 25 12--00495--02 Sensor, Ambient (AMBS) 26 58--00849--03 Tube, Slit 5/8 ID X 20 Long 27 12--00493--09 Sensor, Compressor Suction (CPSS) 28 12--00493--10 Sensor, Compressor Discharge (CPDS) Qty 5 31 5 8 3 3 2 4 2 1 4 3 1 3 1 1 3 2 2 2 2 1 10 1 1 2 1 1 37 T-334PL 2. 17 CONTROLLER HARDWARE, CLAMPS AND DISPLAY - DETAILS 32 33, 34, 35 (Opt. 3) 29 KEY PAD 11 12 33 49 2 2 50 37 36 30 2 46 44 45 43 47 38 39 40 42 41 1 2 BYPASS MODULE ROUTING EB SWITCH WITH FUSE OPTION 1 42 11 48 T-334PL 38 2. 17 CONTROLLER COMPONENTS AND WIRING - DETAILS (Continued) Item Part Number Description Qty STANDARD PARTS INCLUDED IN OPTIONS 1 58--04316--00 Base, Mounting 0. 250 Diameter Mounting Hole 5 2 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 31 11 66U1--5321--7 Washer, Plain 1/4 W Type A 4 12 34--06053--00 Washer 0. 250 ID X 0. 800 OD 3 29 22--01713--03 Harness Key Pad to Display Module 1 30 34--06223--01 Screw, 10--24 X 0. 625 2 OPTION 1 - STANDARD CONTROLLER WIRING WITHOUT VOLTAGE SHIELD See Previous Section for Standard Parts and use with Items Below: 31 12--00433--00RP Module, LCD Display 1 32 34--06223--01 Screw, Captive Wash #10--24 X 0. 625 4 OPTION 2 - CONTROLLER WIRING WITHOUT VOLTAGE SHIELD, WITH SECURE BATTERY OPTION See Previous Section for Standard Parts and use with Items Below: 31 12--00433--00RP Module, LCD Display 1 32 34--06223--01 Screw, Captive Wash #10--24 X 0. 625 4 33 34--06251--00 Screw, Button Head #10--24 X 0. 75 Torx--Pin 4 34 34--00663--09 Washer, Lock #10 Spring 4 35 69NT35--2692--4 Washer, Fender #10--0. 743--0. 765 OD 4 36 62--11114--00 Tag Controller Software 1 OPTION 3 - CONTROLLER WIRING WITHOUT VOLTAGE SHIELD, WITH EMERGENCY BYPASS SYSTEM See Previous Section for Standard Parts and use with Items Below: 31 12--00433--00RP Module, LCD Display 1 32 34--06223--01 Screw, Captive Wash #10--24 X 0. 625 4 33 34--06251--00 Screw, Button Head #10--24 X 0. 75 Torx--Pin 4 37 62--02738--14 Label, Warning!Software Version 5322 3 38 10--01129--15 Switch, Toggle 1 Pole Off/On 1 39 66U1--3882--2 Wire Tie 1/16--1--3/4 Self--locking 2 40 10--01129--20 Nut, Hex 15/32--32 Un--2B 1 41 62--10781--01 Label, EBS with SW 1 42 34--06224--01 Screw, Captive Wash 1/4--20 X 0. 62 1 43 62--10783--00 Label, EBS with Fuse 1 44 22--02336--04 Fuse, 10 Amp (FEB) 1 45 22--01455--03 Holder Assembly Fuse 1 46 62--10781--00 Label, EBS 1 47 68--14482--00 Bracket 1 48 66U1--9592--18 Standoff 1/4--20 X 3. 93 Long 1 49 10--00446--00 Module, EBS 1 50 58--04246--00 Ty--Rap Base (#10) Mounting Tab 1 OPTION 4 - STANDARD CONTROLLER WIRING WITH VOLTAGE SHIELD See Previous Section for Standard Parts and use with Items Below: 14 42--00032--00 Insulation Prestite 3 31 12--00433--02RP Module, LED Display 1 32 34--06223--01 Screw, Captive Wash #10--24 X 0. 625 4 39 T-334PL 2. 18 CONTROLLER HARDWARE, CLAMPS AND DISPLAY - REAR VIEW 11 17 55 56 57 51 52 2 53 54 58 60 2 59 Item 2 11 17 51 52 53 54 55 56 57 58 59 60 Part Number 66U1--3882 66U1--5321--7 66U1--5371--7 58--00065--46 66U1--1571--14 58--04315--00 58--00969--00 34--06051--32 44--01041--04 66U1--5331--3 34--01178--23 34--01178--22 44--00361--00 Description Wire Tie, 1/16--1--3/4 Self--locking Washer, Plain 1/4 W Type A Screw, Machined Hex Head #10--24 X 0. 500 Slotted Grommet 0. 25 ID X 0. 75 OD X 0. 12 Grommet 0. 50 ID X 1. 50 OD Base, Mounting 0. 250 Diameter Mounting Hole Wire Tie 2. 80 Diameter Double Loop Rivnut 10--24 (0. 020/0. 130) Clamp, Cushioned 0. 250 Diameter Washer, Lock #10 Spring Screw, Hex Head, #8--32 X 3/4 Long -- SST Screw, Hex Head, #8--32 X 1/2 Long -- SST Clip, Retaining 0. 88--1. 00 Wire Mounting Qty 31 4 3 1 1 2 2 1 1 1 1 2 2 T-334PL 40 2. 19 HANDLES 1 4 3 2 1 1 Item Part Number OPTION 2 - TWO SIDE 1 69NT35--8113 2 34--00792--07 3 66U1--5331 4 34--06053--15 2. 20 Description Handle, Fixed Screw, Captive Hex Head 5/16--18 X 0. 88 Washer, Lock 5/16 Spring Washer, Mylar 0. 313 ID X 0. 875 OD Qty 2 4 4 4 COMPRESSOR TRANSDUCERS / PRESSURE SWITCH 2 1 3 4 Item Part Number Description OPTION T - PRESSURE TRANSDUCER 1 12--00352--07 Transducer, Suction (SPT) 2 12--00309--05 Switch, Pressure (HPS) 3 12--00352--00 Transducer, Discharge (DPT) 4 EC39DM070 Core, Check Valve (Used with 40--00604--00 Tee) Qty 1 1 1 3 41 T-334PL 2. 21 COMPRESSOR, MOUNTING COMPONENTS AND GUARD 22 21 2 3 23 24 25 26 24 27 28 29 30 4 5 31 32 33 34 24 26 10 3 18 2 6 7 6 20 13 14 15 16 1 11 12 8 9 19 17 20 T-334PL 42 2. 21 COMPRESSOR, MOUNTING COMPONENTS AND GUARD (Continued) Item Part Number Description 1 18--10134--23 Compressor, Scroll -- Includes: 2 42--00384--01 Seal, Rotolock, 1--14 3 42--00384--02 Seal, Rotolock, 1--1/4--12 4 58--04461--00 Shockmount, Bushing 5 58--04461--01 Shockmount, Ring 6 34--06236--00 Washer, 0. 687 X 1. 50 X 0. 078 -- SST 7 58--04451--00 Mount, Resilient, 80A 8 34--06053--20 Washer, Mylar -- 1. 50 X 0. 65 9 18--00077--40 Plug, Oil Drain NS 07--00427--00 Compressor Oil, Quart 10 66CH1--1172--93 Trim, Flexible 3. 75 Long 11 66U1--3882--3 Wire Tie 1/16--4. 0 Self--locking 12 22--04085--00SV Power Cable / Power Head 13 58--04246--00 Ty--Rap Base (#10) Mounting Tab 14 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 15 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 Slotted 16 34--00663--09 Washer, Lock #10 Spring 17 40--00630--00 Valve Assembly, Scroll, Service 18 34--06277--02 Bolt, Shoulder, 1/2--13 UNC -- SST 19 48--00350--01SV Base, Compressor (Painted) -- Includes: 20 58--04435--00 Protector, Mylar 21 86--04405--00 Bracket Assembly 22 86--04406--00 Bracket Assembly 23 66U1--5361--47 Bolt, Machine Hex Head, 1/4--20 X 1. 25 Long -- SST 24 66U1--5321--7 Washer, Plain 1/4 -- SST 25 58--04463--00 Protector, Mylar 26 34--06053--00 Washer, Mylar 0. 250 ID X 0. 800 OD 27 34--00667--11 Nut, Self Lock 1/4--20 -- SST 28 34--00667--13 Nut, Self Lock 3/8--16 -- SST 29 66U1--5321--5 Washer, Plain 3/8 N Type A -- SST 30 34--06053--02 Washer, Mylar 0. 375 ID X 1. 00 OD 31 34--06060--03 Washer, Snubbing 0. 537 ID X 2. 00 OD 32 58--04026--62 Protector, Mylar 33 34--06277--03 Bolt, Shoulder, 3/8--16 UNC -- SST 34 34--00655--04 Screw, Captive Hex Head 1/4--20 X 0. 50 -- SST Qty -1 2 1 1 8 4 4 1 2 1 1 1 1 1 1 1 1 4 1 2 1 1 1 14 1 9 2 1 1 1 1 1 1 4 43 T-334PL 2. 22 COMPRESSOR TUBING 1 10 2 3 4 36 11 14 13 9 5 6 35 7 8 SUCTION TUBE ASSEMBLY DISCHARGE TUBE ASSEMBLY 34 17 18 30 40 33 32 31 18 27 30 39 18 28 29 12 16 15 ECONOMIZER TUBE ASSEMBLY 17 18 19 20 21 36 20 37 38 22 23 24 25 18 26 27 35 20 VIEW WITH FITTINGS VIEW WITH VALVES T-334PL 44 2. 22 COMPRESSOR TUBING (Continued) Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 56--08496--00 Tube 1--1/8 OD X 0. 050 Wall Cu 2 14--00353--00 Valve SMV (Sporlan) without Tap -- Includes: 3 14--00353--20 Piston and Motor Assembly 4 14--00353--21 Gasket 5 DE40BA--927 Tee 1--3/8 X 1--1/8 X 5/8 6 56--08495--00 Tube 1--1/8 OD X 0. 050 Wall Cu 7 14--00176--04 Strainer 40 Mesh, 1 1/8" OD 8 DE21BA--701 Elbow, 90 Street 1--1/8 Fitting X 1--1/8C Sr 9 56--08525--00 Tube 5/8 OD X 0. 040 Wall Cu 10 40--01124--00 Valve Body 11 56--07657--00 Tube, Discharge 7/8 OD X 0. 045 Wall Cu 12 56--08527--00 Tube, Discharge 7/8 OD X 0. 045 Wall Cu 13 DE40BA--303 Tee, Reducing 5/8 X 5/8 X 3/8 14 56--07669--00 Tube 5/8 OD X 0. 040 Wall Cu 15 40--00605--01 Fitting 5/8 ID, Rotalock 16 56--08526--00 Tube 5/8 OD X 0. 040 Wall Cu 17 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 Slotted 18 34--06053--05 Washer 0. 205 ID X 0. 600 OD 19 34--00373--69 Clamp, Tube 1. 38 Diameter Cushion 20 42--00032--00 Insulation Prestite 21 42--00667--16 Insulation, Tube Pre--Taped 22 42--00384--01 Seal 1--14, Rotalock 23 40--00542--00 Elbow Adapter, Low Pressure, R134A 24 40--00520--02 Cap M8 X 1. 0--6G 25 34--06295--00 Washer, Fender #10--1. 690--2. 000 OD 26 66U1--3632--20 Clamp, Tube 0. 88 Diameter Cushion 27 66U1--5371--10 Screw, Machined Hex Head #10--24 X 1. 00L Slotted 28 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 29 34--00373--07 Clamp, Tube 0. 62 Diameter Cushion 30 66U1--5321--8 Washer, Plain #10 Type A 31 42--00384--02 Seal 1 1/4--12, Rotalock 32 58--04026--26 Protector 7. 50 X 7. 50 33 42--00667--15 Insulation, Tube, Pre--Taped 34 42--00667--14 Insulation, Tube, Pre--Taped OPTION S - WITH SERVICE VALVES 35 40--00622--01 Valve, Service 1 1/8 ID, Rotalock 36 40--00583--05 Valve, Service 7/8 ID, Rotalock 37 40--00542--01 Elbow Adapter High Press. , R134A 38 40--00520--03 Cap M10 X 1. 0--6G 68--15269--00 Bracket, White 0. 090 Thick Aluminum 39 68--15269--01 Bracket, Orange 0. 090 Thick Aluminum 68--15331--00 Bracket, White 0. 125 Thick Aluminum 40 68--15331--01 Bracket, Orange 0. 125 Thick Aluminum OPTION SS - WITH SERVICE FITTINGS 35 40--00605--05 Fitting, 1 1/8 ID, Rotalock 36 40--00605--00 Fitting, 7/8 ID, Rotalock 39 68--15269--00 Bracket, White 0. 090 Thick Aluminum 40 68--15331--00 Bracket, White 0. 125 Thick Aluminum Qty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 8 12 2 10 1 1 1 1 1 1 3 1 1 8 2 1 1 1 1 1 1 1 A/R A/R A/R A/R 1 1 1 2 Change 11/10 45 T-334PL 2. 23 CABLE AND COMPRESSOR GUARDS 1 2 3 4 9 6 10 11 6 10 11 21 6 10 11 21 6 10 11 6 7 8 11 16 17 18 10 12 13 ITEM 23 REMOVED FOR CLARITY 23 14 10 12 13 6 7 8 11 6 10 11 10 12 13 19 5 6 10 19 16 17 18 22 6 10 11 15 5 6 10 19 16 17 18 6 10 11 20 14 T-334PL 46 2. 23 CABLE AND COMPRESSOR GUARDS (Continued) Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 58--04316--00 Base, Mounting, 0. 250 Diameter Mounting Hole 2 66U1--3882 Wire Tie, 1/16--1--3/4 Self Lock 3 34--06136--01 Nut, Lock, 3/4" NPT 4 66U1--1251--2 O--Ring, 3/4 Hub Sealing 5 58--04026--07 Protector, 1. 63 X 3. 00 Long 6 66U1--5321--7 Washer, Plain 1/4 W Type A 7 66U1--5361--11 Screw, Captive, Hex Head 1/4--20 X 1. 50 8 34--00667--11 Nut, Self Lock 1/4--20 OPTION 1 - 460V CABLE, STANDARD GUARD See Previous Section for Standard Parts and use with Items Below: 9 66U1--7352 Connector, Straight, Watertight 10 66U1--5361--25 Screw, Captive, Hex Head 1/4--20 X 0. 75 11 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 12 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 13 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 14 68--15105--00 Cover, White, 0. 063 Thick Aluminum 15 68--15213--00 Guard, White, 0. 080 Thick Aluminum 16 66U1--5371--6 Screw, Machined, Hex Head #10--24 X 0. 750 Slotted 17 66U1--5321--8 Washer, Plain #10 Type A 18 34--06053--05 Washer 0. 205 ID X 0. 600 OD 19 68--14456--00 Cable Clamp, Cable Cutter 20 68--15118--00 Brace, Support 0. 06 Thick Aluminum OPTION 1 - 460V CABLE, STANDARD GUARD, ORANGE See Previous Section for Standard Parts and use with Items Below: 9 66U1--7352 Connector, Straight, Watertight 10 66U1--5361--25 Screw, Captive, Hex Head 1/4--20 X 0. 75 11 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 12 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 13 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 14 68--15105--01 Cover, Orange 0. 063 Thick Aluminum 15 68--15213--01 Guard, Orange, 0. 080 Thick Aluminum 16 66U1--5371--6 Screw, Machined, Hex Head #10--24 X 0. 750 Slotted 17 66U1--5321--8 Washer, Plain #10 Type A 18 34--06053--05 Washer 0. 205 ID X 0. 600 OD 19 68--14456--00 Cable Clamp, Cable Cutter 20 68--15118--01 Brace, Support, Orange, 0. 06 Thick Aluminum OPTION 2 - TRANSICORD, STANDARD GUARD See Previous Section for Standard Parts and use with Items Below: 9 66U1--7352--3 Connector, Straight, Watertight 10 66U1--5361--25 Screw, Captive, Hex Head 1/4--20 X 0. 75 11 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 12 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 13 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 14 68--15105--00 Cover, 0. 063 Thick Aluminum 15 68--15213--00 Guard, 0. 080 Thick Aluminum Qty 1 1 1 1 1 12 2 2 1 9 10 1 1 1 1 2 2 2 1 1 1 9 10 1 1 1 1 2 2 2 1 1 1 9 10 1 1 1 1 47 T-334PL 2. 23 CABLE AND COMPRESSOR GUARDS (Continued) Item Part Number Description OPTION 2 - TRANSICORD, STANDARD GUARD (Continued) 16 66U1--5371--6 Screw, Machined, Hex Head #10--24 X 0. 750 Slotted 17 66U1--5321--8 Washer, Plain #10 Type A 18 34--06053--05 Washer 0. 205 ID X 0. 600 OD 19 68--14456--01 Cable Clamp, Cable Cutter, 16 Gage 20 68--15118--00 Brace, Support, White, 0. 06 Thick Aluminum OPTION 3 - 460V CABLE, FULL GUARD See Previous Section for Standard Parts and use with Items Below: 9 66U1--7352 Connector, Straight, Watertight 10 66U1--5361--25 Screw, Captive, Hex Head 1/4--20 X 0. 75 11 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 12 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 13 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 14 68--15150--00 Guard, 0. 063 Thick Aluminum 16 66U1--5371--6 Screw, Machined, Hex Head #10--24 X 0. 750 Slotted 17 66U1--5321--8 Washer, Plain #10 Type A 18 34--06053--05 Washer 0. 205 ID X 0. 600 OD 19 68--14456--00 Cable Clamp, Cable Cutter 16 Gage 21 68--14143--00 Bracket, 0. 125 Thick Aluminum 22 68--15286--00 Partition, 0. 090 Thick Aluminum 23 68--14706--01 Guard, 0. 125 Thick Aluminum OPTION 4 - TRANSICORD, FULL GUARD See Previous Section for Standard Parts and use with Items Below: 9 66U1--7352--3 Connector, Straight, Watertight 10 66U1--5361--25 Screw, Captive, Hex Head 1/4--20 X 0. 75 11 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 12 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 13 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 14 68--15150--00 Guard, 0. 063 Thick Aluminum 16 66U1--5371--6 Screw, Machined, Hex Head #10--24 X 0. 750 Slotted 17 66U1--5321--8 Washer, Plain #10 Type A 18 34--06053--05 Washer 0. 205 ID X 0. 600 OD 19 68--14456--01 Cable Clamp, Cable Cutter 16 Gage 21 68--14143--00 Bracket, 0. 125 Thick Aluminum 22 68--15286--00 Partition, 0. 090 Thick Aluminum 23 68--14706--01 Guard, 0. 125 Thick Aluminum Qty 2 2 2 1 1 1 11 10 3 3 1 4 4 4 1 2 1 1 1 11 9 3 3 1 4 4 4 1 2 1 1 T-334PL 48 2. 24 ECONOMIZER 1 2 3 4 5 15 7 8 9 10 1 2 3 4 14 11 6 16 8 12 13 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 Part Number 34--06053--05 66U1--5371 66U1--5321--2 66U1--5331--4 68--15296--00 68--15296--00 68--15170--00 68--15170--01 58--00836--19 34--06053--00 66U1--5321--7 34--00667--11 58--04026--59 34--00373--54 66U1--5371--6 68--15294--00 68--15294--01 81--01539--20 14--00232--31 Description Washer, 0. 205 ID X 0. 600 OD Screw, Machined Hex Head Washer, Plain Washer, Lock Bracket, White Bracket, Orange Bracket, White Bracket, Orange Spacer, Nylon, 0. 50D X 0. 562L Washer, 0. 250 ID X 0. 800 OD Washer, Plain 1/4 W Nut, Self Lock 1/4--20 Protector, Solenoid Valve Clamp, Tube Screw, Machined Hex Head #10--24 X 0. 750 Cover, White Cover, Orange Economizer Valve, Economizer, Thermal Expansion 49 Qty 8 6 6 6 A/R A/R A/R A/R 2 39 34 2 2 1 3 A/R A/R 1 1 T-334PL 2. 25 RECEIVER 1 2 3 4 5 6 7 8 10 9 11 12 13, 14 37 15 36 34 35 14 16 17 18 19 20 21 32 29 31 30 38 39 40 41 23 BRAZED ECONOMIZER ASSEMBLY USV 33 22 24 27 28 LIV ESV 25 26 Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 14--00341--07 Filter Drier, 1/2 Flare, "O" Ring Single -- Includes: 2 14--00284--20 O--Ring, Filter Drier NS 14--00341--07Pk25 Filter Drier, 1/2 Flare, "O" Ring 25 Pack -- Includes: NS 14--00284--20 O--Ring, Filter Drier 3 66U1--5361--25 Screw, Captive Hex Head 1/4--20 X 0. 75 4 66U1--5321--7 Washer, Plain 1/4 W 5 34--06053--00 Washer, 0. 250 ID X 0. 800 OD 6 66U1--5321--8 Washer, Plain #10 7 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 8 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Qty 1 2 1 25 33 34 39 6 8 10 T-334PL 50 2. 25 RECEIVER (Continued) Item Part Number Description 68--15171--00 Bracket, White, 0. 125 Thick Aluminum 9 68--15171--01 Bracket, Orange, 0. 125 Thick Aluminum 10 44--00370--03 Clamp, Cushioned 0. 50 Diameter 11 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 12 66U1--3882--3 Wire Tie, 1/16--4. 0 Self--locking 13 14--01090--02 Coil, Solenoid Valve 14 66U1--3803 Tube, Heat Shrink 0. 25 X 2. 12 Blk 15 58--00969--00 Wire Tie, 2. 80 Diameter Double Loop 16 14--01091--04 Coil Kit, Solenoid Valve -- Includes: 17 NSS Coil, Solenoid 18 NSS O--Ring, Top 19 NSS O--Ring, Bottom 20 NSS Spacer, Brass (Used on ESV Only) 21 NSS Screw, Mounting 68--15170--00 Bracket, White, 0. 125 Thick Aluminum 22 68--15170--01 Bracket, Orange, 0. 125 Thick Aluminum 23 66U1--1571--3 Grommet, 0. 50 ID X 1. 00 OD 24 14--01090--11 Valve, Unloader Solenoid 25 14--00285--00 Valve, Solenoid 0. 36 Port, Norm Open 26 14--01090--12 Valve, Solenoid 27 69NP20--1031 Clamp, Tube 2. 88 Diameter Cushion 28 34--06053--03 Washer, 0. 250 ID X 1. 000 OD 29 66U1--2552--133 Gasket, Neoprene 30 40--00520--01 Coupling, HP, with Cap 68--15172--00 Bracket, White, 0. 125 Thick Aluminum 31 68--15172--01 Bracket, Orange, 0. 125 Thick Aluminum 32 34--00373--07 Clamp, Tube 0. 62 Diameter Cushion 33 58--04026--61 Protector, 5. 63 X 2. 00 with 2 Slots OPTION 1 - STANDARD RECEIVER See Previous Section for Standard Parts and use with Items Below: -79--01785--01 Receiver Assembly -- Includes: 34 65--00185--01 Receiver, With Brass Connections 35 14--00221--03 Indicator, Moisture and Liquid 36 14--01032--14 Plug, Fusible 3/8 NFPT 37 14--00220--04 Sight Glass 38 14--00222--02 Valve, King (R--134A) OPTION 2 - SMALL RECEIVER, WITHOUT KING VALVE See Previous Section for Standard Parts and use with Items Below: -79--01785--02 Receiver Assembly -- Includes: 34 65--00177--05 Receiver, With Brass Connections 35 14--00221--03 Indicator, Moisture and Liquid 36 14--01032--14 Plug, Fusible 3/8 NFPT 37 14--00220--04 Sight Glass 38 14--00222--02 Fitting, King (R--134A) 39 66U1--5361--7 Screw, Cap Hex Head 3/8--16 X 1. 00 40 34--00662--13 Washer, Plain, 3/8 Medium 0. 062 Thick 41 34--06053--02 Washer, 0. 375 ID X 1. 00 OD Qty A/R A/R 2 3 7 1 4 2 2 1 1 1 1 1 A/R A/R 1 11 1 1 1 2 1 1 A/R A/R 1 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 51 T-334PL 2. 26 WATER-COOLED CONDENSER 17 18 3 19 21 20 22 24 23 25 26 4 REAR VIEW OF WATERCOOLED CONDENSER 23 15 16 27 12 13 14 31 2 1 48 10 11 46 47 45 44 8 9 41 5 42 6 43 7 40 39 38 4 32 33 34 35 36 37 BRAZED ECONOMIZER ASSEMBLY 28 USV LIV ESV 29 30 Item -1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 17 18 19 Part Number 76--00734--00 69NT42--954--4 14--00220--00 14--00215--05 66U1--3803 40--01129--00 42--50000--00 66U2--1152 66U2--1142 66U1--2763--5 66U2--1132--1 12--01071--02SV 66U1--5361--25 66U1--5321--7 34--06053--00 34--06053--03 69NP20--1031 14--00341--07 14--00284--20 14--00341--07Pk25 14--00284--20 66U1--2552--133 Description Condenser/Receiver Assembly for Field Installation -- Includes: Condenser -- Includes: Sight Glass, 1/2--14 NPT Rupture Disc 3/8 NPT Tube, Heat Shrink 0. 25 X 2. 12 Blk Coupling, Self--Draining -- Includes: Seal, O--Ring Cap, Dust Socket Cap, Dust Plug Coupling Assembly, Water In Connector, Electric 16--14 Gauge Switch, Pressure 1/4 Female OPTION W Screw, Captive Hex Head 1/4--20 X 0. 75 Washer, Plain 1/4 W Washer, 0. 250 ID X 0. 800 OD Washer, 0. 250 ID X 1. 000 OD Clamp, Tube 2. 88 Diameter Cushion Filter Drier, 1/2 Flare, "O" Ring Single -- Includes: O--Ring, Filter Drier Filter Drier, 1/2 Flare, "O" Ring 25 Pack -- Includes: O--Ring, Filter Drier Gasket Qty 1 1 1 1 8 1 1 1 1 1 2 1 31 32 37 2 1 1 2 1 25 1 T-334PL 52 2. 26 WATER-COOLED CONDENSER (Continued) Item Part Number Description 20 68--15171--00 Bracket, 0. 125 21 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 22 44--00370--03 Clamp, Cushioned 0. 50 Diameter 23 66U1--3882--3 Wire Tie 1/16--4. 0 Self--locking 24 66U1--5321--8 Washer, Plain #10 25 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 26 14--01091--02 Coil, Unloader Solenoid Valve 27 58--00956--00 Protector, Mylar 28 14--01090--11 Valve, Unloader Solenoid (USV) 29 14--00285--00 Valve, Solenoid (LIV), 0. 36 Port, Normally Open 30 14--01090--12 Valve, Solenoid (ESV) 31 58--00969--00 Wire Tie, 2. 80 Diameter Double Loop 32 14--01091--04 Coil Kit, Solenoid Valve -- Includes: 33 NSS Coil, Solenoid 34 NSS O--Ring, Top 35 NSS O--Ring, Bottom 36 NSS Spacer, Brass (Used on ESV Only) 37 NSS Screw, Mounting 38 68--15170--00 Bracket, 0. 125 39 66U1--1571--3 Grommet 0. 50 ID X 1. 00 OD 40 58--00957--00 Protector 41 66U1--5361--7 Screw, Captive Hex Head 3/8--16 X 1. 00 42 34--00662--13 Washer, Plain 3/8 43 34--06053--02 Washer 0. 375 ID X 1. 000 OD 44 40--00520--01 Coupling, with Cap 45 68--15172--00 Bracket, 0. 125 46 34--00373--07 Clamp, Tube 0. 62 Diameter Cushion 47 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 48 58--04026--52 Protector Qty 1 8 1 10 6 10 1 2 11 1 1 3 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 3 1 53 T-334PL 2. 27 CONDENSER COIL AND COVERS 8 9 7 4 5 6 10 7 11 12 4 5 6 3 4 5 2 1 13 4 5 6 14 3 4 5 15 25 5 22 23 24 6 20 21 4 5 6 19 20 21 4 5 6 18 17 16 T-334PL 54 2. 27 Item 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 CONDENSER COIL AND COVERS (Continued) Part Number Description 81--01855--22SV Coil Assembly, Condenser 58--04026--08 Protector, Coil Cover 34--00655--04 Screw, Cap Hex Head, 1/4--20 X 0. 50 66U1--5321--7 Washer, Plain, 1/4 34--06053--00 Mylar Washer, 0. 250 ID X 0. 800 OD 66U1--5361--25 Screw, Cap Hex Head, 1/4--20 X 0. 75 58--04026--50 Protector, Tube Sheet 58--04026--57 Protector, Center Tube Sheet 58--04026--03 Protector, Tube Sheet 68--15210--03 Cover, Orange 68--15210--01 Cover, White 68--15285--01 Baffle, Orange 68--15285--00 Baffle, White 34--00928--02 Rivet 58--04026--35 Protector 68--13355--00 Bracket, Scroll Condenser Coil 58--04026--21 Protector 58--04026--41 Protector, Coil Cover 58--04026--42 Protector, Coil Cover 58--04026--44 Protector, Coil Cover 34--00655--08 Screw, Cap Hex Head, 1/4--20 X 1. 00 34--01181--02 Washer, Flat 34--06053--22 Mylar Washer, 0. 195 ID X 1. 125 OD 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 69NT35--2692--4 Washer, Fender 68--14546--06 Cover, Condenser Coil, Orange 68--14546--05 Cover, Condenser Coil, White 69NT35--8693--11 Protector Qty 1 1 7 34 39 33 2 2 2 A/R A/R A/R A/R 2 1 1 1 2 2 2 1 2 2 10 4 A/R A/R 6 55 T-334PL 2. 28 CONDENSER FAN MOTOR 1 17 15 2 3 4 3 14 13 6 7 8 10 11 12 5 9 18 19 20 21 22 24 25 26 19 20 27 16 30 18 16 19 20 21 22 23 16 28 29 28 16 23 BOLTED CONDENSER FAN GRILLE OPTION B HINGED CONDENSER FAN GRILLE OPTION H T-334PL 56 2. 28 CONDENSER FAN MOTOR (Continued) Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 38--00585--00 Fan, Condenser (17--1/2 Diameter) -- Composite 2 34--00667--12 Locknut, 5/16--18 -- SST 3 34--01181--01 Washer, Flat, 5/16 -- SST 4 34--06053--02 Washer, Mylar, 1. 0 OD X 3/8 ID 5 69NT35--6112 Protector, Condenser Fan Motor Mounting 6 54--00586--20 Motor, Condenser Fan -- Includes: 7 04--50027--00 Bearing 8 22--50088--02 Capacitor, 15 uF 9 PL Key, 3/16 Square X 1--3/8 Long -- SST 10 22--04018--00 Connector 11 22--01997--05 Pin 12 22--01997--10 Pin, Grounding 13 66U1--5361 Screw, Hex Head, 5/16--18 X 1--1/4 Long -- SST OPTION B - BOLTED CONDENSER FAN GRILLE See Previous Section for Standard Parts and use with Items Below: 14 PL Set Screw, Square Head, 5/16--24 X 5/8 Long -- SST 15 62--02785--00 Label, CE (European Comm. ) 76--00704--01 Grille and Venturi Assembly, Blue -- Includes: 16 76--00704--02 Grille and Venturi Assembly, White -- Includes: 17 66U1--8912 Label, Rotation 18 34--06051--36 Rivnut 1/4--20 (0. 027/0. 165) 19 34--06053--03 Washer, Mylar, 1/4 ID X 1. 00 OD 20 69NT35--2692--1 Washer, Fender 1/4 -- SST 21 34--00663--11 Washer, Lock, 1/4 -- SST 22 66U1--5361--25 Capscrew, Hex Head, 1/4--20 X 3/4 Long -- SST 23 34--00928--07 Rivet, Blind 0. 156 Diameter 0. 063--0. 125 OPTION H - HINGED CONDENSER FAN GRILLE See Previous Section for Standard Parts and use with Items Below: 14 34--06283--00 Screw, Set Square Head 5/16--24 X 0. 75 Long 15 62--02785--00 Label, CE (European Comm. ) 76--00704--01 Grille and Venturi Assembly, Blue -- Includes: 76--00704--02 Grille and Venturi Assembly, White -- Includes: 16 79--01937--00 Grille and Venturi Assembly, Orange -- Includes: 17 66U1--8912 Label, Rotation 19 34--06053--03 Washer, Mylar, 1/4 ID X 1. 00 OD 20 69NT35--2692--1 Washer, Fender 1/4 -- SST 23 34--00928--07 Rivet, Blind 0. 156 Diameter 0. 063--0. 125 24 34--01142--01 Receptacle #12 Saddle Type 25 34--00928--02 Rivet, Blind 0 0. 125 Diameter 0. 126--0. 187 26 34--06169--00 Washer, Retaining -- SST -76--50075--00 Hinge Kit -- Includes: 66U1--6811--8 Screw, Retaining -- SST 27 66U1--6811--12 Screw, Retaining (Phillips Head) -- SST 28 34--06179--00 Screw, Hex Head, #10--24 X 7/16 Long -- SST 29 44--00374--00 Hinge 30 58--04101--07 Protector, Mylar Qty 1 4 8 4 2 1 2 1 1 1 A/R A/R 4 2 A/R A/R A/R 1 4 4 2 4 4 8 A/R A/R A/R A/R A/R 1 4 2 8 2 4 2 1 2 2 8 2 4 57 T-334PL 2. 29 VOLTAGE CABLES 10 7 8 9 1 2 3 4 5 6 Item Part Number Description CLAMPS ON BACK WALL AND CABLE CUTTERS 69NT35--6412--2 Clamp, Cable Cutter, 8 AWG cable 68--14456--00 Clamp, Cable Cutter, 10 AWG cable 1 68--14456--01 Clamp, Cable Cutter, 11 AWG cable 2 58--04026--07 Protector, Mylar 3 66U1--5361--11 Screw, Machined Hex Head, 1/4--20 X 1--1/2 Long -- SST 4 34--00667--11 Locknut, Hex Head, 1/4--20 -- SST 5 66U1--5321--7 Washer, Flat, 1/4 -- SST 6 34--06053--03 Washer, Mylar, 0. 25 ID X 1. 00 OD 460V CABLES STANDARD PARTS FOR ALL 460V CABLES 22--02324--01 Bushing (Used with Standard Cable) 7 22--02324--05 Bushing (Used with Transicord) 8 66U1--2583 Heat Shrink Tube (Coil Label) -- "460V" OPTION 1 9 66U1--9782 Cable, Power -- Yellow, 10/4 10 22--02378--00 Plug, Power OPTION 2 9 22--01551--00 Cable, Power -- Yellow, 33 Amp, 11 AWG 10 22--02378--00 Plug, Power OPTION 3 9 66U1--9782 Cable, Power -- Yellow, 10/4 10 22--01891--00 Plug, Power OPTION 4 9 22--01551--00 Cable, Power -- Yellow, 33 Amp, 11 AWG 10 22--01891--00 Plug, Power Qty 1 1 1 A/R A/R A/R A/R A/R 4 4 1 A/R 1 A/R 1 A/R 1 A/R 1 T-334PL 58 2. 29 VOLTAGE CABLES (Continued) Item Part Number Description OPTION 5 9 22--01551--00 Cable, Power -- Yellow, 33 Amp, 11 AWG 10 22--01883--00 Plug, Power OPTION 6 9 22--01551--00 Cable, Power -- Yellow, 33 Amp, 11 AWG 10 22--01891--00 Plug, Power OPTION 7 9 66U1--9782 Cable, Power -- Yellow, 10/4 10 22--01891--00 Plug, Power OPTION 8 9 66U1--9782 Cable, Power -- Yellow, 10/4 10 22--01932--00 Plug, Power OPTION 9 9 66U1--9782 Cable, Power -- Yellow, 10/4 10 22--02232--00 Plug, Power 230V CABLES STANDARD PARTS FOR ALL 230V CABLES 8 66U1--2583--1 Heat Shrink Tube (Coil Label) -- "230V" 7 22--02324--02 Bushing (Used with 8 AWG) 9 66U1--9782--1 Cable, Power -- Black, 35 amps, 8 AWG OPTION 1 10 22--02188--00 Plug, Power OPTION 2 10 22--02375--00 Plug, Power OPTION 3 10 66U1--6782--3 Plug, Power OPTION 4 10 22--01744--00 Plug, Power OPTION 5 10 22--02322--00 Plug, Power OPTION 6 10 22--01884--00 Plug, Power OPTION 7 10 66U1--6782 Plug, Power OPTION 8 10 22--01931--00 Plug, Power OPTION 9 10 22--01906--00 Plug, Power Qty A/R 1 A/R 1 A/R 1 A/R 1 A/R 1 1 4 A/R 1 1 1 1 1 1 1 1 1 59 T-334PL 2. 30 AUTOTRANSFORMER 1 2 3 6 7 13 12 11 98 31 10 9 8 4 5 35 32 33 34 39 36 40 42 41 43 30 27 28 29 24 37 23 22 38 21 20 19 18 17 16 15 14 Qty 7 5 7 1 1 26 25 15 Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 66U1--5321--7 Washer, Plain, 1/4 W Type A 2 34--06053--00 Washer, Mylar, 0. 250 ID X 0. 800 OD 3 AA06JA--170 Screw, Hex Head, 1/4--20 X 1. 00 Long 4 58--04026--07 Protector, Mylar 5 68--14456--02 Cable Cutter OPTION 1 - AUTOTRANSFORMER WITHOUT CB2 See Previous Section for Standard Parts and use with Item Below -76--00667--04 Transformer Kit, Field Installation, without CB2 -- Includes: 6 58--04026--25 Protector 1. 00 X 6. 62 with 2 Slots 7 69NT35--2086 Spacer 0. 25 Thick Aluminum 8 34--00667--12 Nut, Self Lock 5/16--18 9 34--01181--01 Washer, Flat 0. 320/0. 330ID 10 34--06053--02 Washer 0. 375 ID X 1. 000 OD 11 69NT40--914--4 Transformer Assembly 12 58--04026--17 Protector 2. 00 X 13. 0 with 2 Holes 13 69NT43--374 Bracket Assembly DV Transformer Module 1 1 1 6 6 4 1 2 1 T-334PL 60 2. 30 AUTOTRANSFORMER (Continued) Item Part Number Description 14 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 15 66U1--5321--8 Washer, Plain #10 Type A 16 34--06053--05 Washer 0. 205 ID X 0. 600 OD 17 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 Slotted 18 22--01679--00 Receptacle 32 Amp/Bryant 19 69NT41--892 Cover Assembly Transformer Module, Receptacle 20 42--00328--00 Gasket 0. 094 Thick X 3. 60 X 5. 74 21 69NT43--282 Box Assembly Transformer Module, CB2 22 34--06053--10 Washer 0. 138 ID X 0. 343 OD 23 66U2--1531--3 Screw, Machined Roundhead #6--32 X 0. 375 Long SS 24 AU27JR--171 Washer, Lock 1/4 Ext Tooth 25 66U1--5321--3 Washer, Plain 1/4 N Type A 26 34--00667--11 Nut, Self Lock 1/4--20 27 22--01778--00 Terminal, Block Three Terminal 28 34--00795--09 Nut, Self Lock 10--32 29 34--00928--02 Rivet, Blind 0. 125 Diameter 0. 126--0. 187 30 22--02319--05 Connector, Straight 3/4 Hub 31 22--02319--06 Connector, Straight, 0. 590/1. 00 Diameter 32 69NT43--270--1 Box Assembly, Weld DV Transformer Module 33 34--06136--01 Nut, Lock 3/4 NPT 34 34--06136--02 Nut, Lock 1. 00 NPT 35 42--00366--00 Gasket 0. 094 Thick, 3. 20 X 3. 200 36 68--13832--00 Plate Assembly, 0. 090 Thick Aluminum OPTION 2 - AUTOTRANSFORMER WITH CB2 See Previous Page for Standard Parts and use with Items Below -76--00667--03 Transformer Kit, Field Installation, with CB2 -- Includes: 6 58--04026--25 Protector 1. 00 X 6. 62 with 2 Slots 7 69NT35--2086 Spacer 0. 25 Thick Aluminum 8 34--00667--12 Nut, Self Lock 5/16--18 9 34--01181--01 Washer, Flat 0. 320/0. 330 ID 10 34--06053--02 Washer 0. 375 ID X 1. 000 OD 11 69NT40--914--4 Transformer Assembly 12 58--04026--17 Protector 2. 00 X 13. 0 with 2 Holes 13 69NT43--374 Bracket Assembly DV Transformer Module 14 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 15 66U1--5321--8 Washer, Plain #10 Type A 16 34--06053--05 Washer 0. 205 ID X 0. 600 OD 17 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 Slotted 18 22--01679--00 Receptacle 32 Amp/Bryant 19 69NT41--892 Cover Assembly Transformer Module, Receptacle 20 42--00328--00 Gasket 0. 094 Thick X 3. 60 X 5. 74 21 69NT43--282 Box Assembly, Transformer Module, CB2 22 34--06053--10 Washer 0. 138 ID X 0. 343 OD 24 AU27JR--171 Washer, Lock 1/4 Ext Tooth 25 66U1--5321--3 Washer, Plain 1/4 N Type A 26 34--00667--11 Nut, Self Lock 1/4--20 29 34--00928--02 Rivet, Blind 0. 125, Diameter 0. 126--0. 187 Qty 4 8 4 4 1 1 1 1 4 4 1 1 1 1 2 3 1 1 1 1 1 1 1 1 1 1 6 6 4 1 2 1 4 8 4 4 1 1 1 1 6 1 1 1 3 61 T-334PL 2. 30 AUTOTRANSFORMER (Continued) Item Part Number Description 30 22--02319--05 Connector, Straight 3/4 Hub 23 66U2--1531--3 Screw, Machined, Roundhead #6--32 X 0. 375 Long, SST 31 22--02319--06 Connector, Straight, 0. 590/1. 00 Diameter 32 69NT43--270 Box Assembly, Weld DV Transformer Module 33 34--06136--01 Nut, Lock 3/4 NPT 34 34--06136--02 Nut, Lock 1. 00 NPT 37 69NT35--1076 Label, On/Off (0. 35 X 1. 55) 38 69NT35--1076--1 Label, CB2 230V On/Off 39 66U2--1531--1 Boot 2. 66 X 2. 97, Black 40 68--13961--00 Boot, Frame 0. 090 Thick Aluminum 41 10--00083--06 Circuit Breaker, 70A--250 VAC--50/60Hz 42 10--00083--07 Nut, Hex 1/4--20 43 10--00083--08 Washer, Flat 1/4 (Circuit Breaker) Qty 1 6 1 1 1 1 1 1 1 1 1 6 12 T-334PL 62 2. 31 CABLE RESTRAINT COMPONENTS OPTION 3 - J- -HOOK 1 2 6 7 5 1 2 3 4 8 9 10 11 12 13 OPTION 2 - LEFT SIDE BUNGY CORD - OPTION R - DUMMY RECEPTACLE Qty 2 2 2 2 2 2 1 1 2 2 1 1 1 2 2 2 4 4 Item Part Number Description OPTION 1 - DOOR OR L. BUNGY CORD PROVISIONING 1 66U1--5321--7 Washer, Flat, 1/4 -- SST 2 66U1--5361--25 Screw, Captive, Hex, Head, 1/4--20 X 0. 75 Long -- SST 3 34--06053--03 Washer, Mylar, 0. 25 ID X 1. 00 OD OPTION 2 - LEFT SIDE BUNGY CORD ONLY 1 66U1--5321--7 Washer, Flat, 1/4 -- SST 2 66U1--5361--25 Screw, Captive, Hex, Head, 1/4--20 X 0. 75 Long -- SST 3 34--06053--03 Washer, Mylar, 0. 25 ID X 1. 00 OD 4 69NT35--5992 Cable Restraint, SST 5 66U1--2603 Strap, Tie Down OPTION 3 - J- -HOOK 1 66U1--5321--7 Washer, Flat, 1/4 -- SST 2 66U1--5361--25 Screw, Captive, Hex, Head, 1/4--20 X 0. 75 Long -- SST 6 69NT35--8382 Cable Restraint, J--Hook 7 58--04026--22 Protector, Mylar OPTION R - DUMMY RECEPTACLE 8 22--01679--03 Receptacle 9 66U1--5321--7 Washer, Flat, 1/4 -- SST 10 66U1--5361--25 Screw, Captive, Hex, Head, 1/4--20 X 0. 75 Long -- SST 11 34--06053--03 Washer, Mylar, 0. 25 ID X 1. 00 OD 12 66U1--5321--8 Washer, Flat, #10 SST 13 66U1--5371--6 Screw, Captive, Hex, Head, 10--24 X 0. 75 Long -- SST 63 T-334PL 62---02458---00 REV C 2. 32 INTERROGATOR RECEPTACLE 9 10 1 OPTION 1 OPTION 4 2 3 4 8 5 6 7 OPTION 3 T-334PL 64 2. 32 INTERROGATOR RECEPTACLE (Continued) Item Part Number Description OPTION 1 - INTERROGATOR - LEFT MOUNT 1 22--01660--05 Cap, Dust 2 66U1--5321--8 Washer, Plain, #10 Type A 3 66U1--5371--7 Screw, Machine, Hex Head, #10--24 X 0. 500 Slotted 4 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 69NT41--192--1 Bracket Assembly, Orange 5 69NT41--192 Bracket Assembly, White 6 58--01097--00 Cord, Nylon, 0. 085 OD 7 22--02205--00 Connector, Splice, Non--insulated 8 34--06142--00 Rivet, 0. 110 Diameter, 0. 126--0. 250 Connector, Interrogator (Refer to Section 2. 44) OPTION 3 - INTERROGATOR - BOX MOUNT 1 22--01660--05 Cap, Dust, 5--Pin 6 58--01097--00 Cord, Nylon, 0. 085 OD 7 22--02205--00 Connector, Splice, Non--insulated 8 34--06142--00 Rivet, 0. 110 Diameter, 0. 126 --0. 250 9 22--01660--03 Connector, 5--Pin 10 22--01613--14 Pin OPTION 5 - INTERROGATOR - LEFT MOUNT 1 22--01660--05 Cap, Dust 2 34--06212--10 Washer, Plain, #10 Type A 3 34--66628--03 Screw, Machine, Hex Head, #10--24 X 0. 500 Slotted 4 34--06053--05 Washer, 0. 205 ID X 0. 600 OD 5 69NT41--192 Bracket Assembly, Straight Mount 6 58--01097--00 Cord, Nylon, 0. 085 OD 7 22--02205--00 Connector, Splice, Non--insulated 8 34--06142--00 Rivet, 0. 110 Diameter, 0. 126 -- 0. 250 Connector, Interrogator (Refer to Section 2. 44) Qty 1 2 2 2 A/R A/R 1 2 4 1 A/R 2 4 1 5 1 2 2 2 1 1 1 4 65 T-334PL 2. 33 VACUUM RELIEF VALVE / CONTROLLED ATMOSPHERE OPTION 2 3 8 OR 10 7 4 5 4 5 9 11 13 14 17 6 SIDE VIEW 1 FRONT VIEW 12 Item Part Number Description COMMON PARTS 1 58--04127--06 Elbow, Schedule 80 2 58--04127--00 Tube, Flanged -- Plastic 3 58--04127--07 Collar 4 66U1--5321--7 Washer, Plain 1/4 5 66U1--5361--25 Screw, Hex Head 1/4--20 X 0. 75 6 58--00065--72 Grommet 7 58--04127--05 Coupling, Schedule 80 OPTION 1 - VACUUM RELIEF VALVE ONLY 8 40--66615--00 Valve, Vacuum Relief 9 34--06053--00 Washer, Plain 0. 25 ID X 0. 80 OD OPTION 2 - WITH NITROGEN-FED CONTROLLED ATMOSPHERE 10 58--04127--03 Valve, Pressure Relief 11 58--00989--03 Mylar Protector 12 58--04170--01 Tube Assembly, Nitrogen Feed 13 69NT35--8012 Bracket 14 Gauge SST 2B 14 34--00928--13 Rivet, Blind, 0. 187 Diameter 0. 126--0. 250 15 66U1--5321--8 Washer, #10 16 66U1--5371--10 Screw, Machine, Hex Head, Slotted #10--24 X 1. 00 17 58--00065--71 Grommet, Nitrogen Atmosphere 15 16 Qty 1 1 1 A/R A/R 1 1 1 8 1 4 2 2 4 4 4 2 T-334PL 66 2. 34 DRAIN 6 7 6 8 9 6 7 3 4 5 3 1 2 10 11 Item 1 2 3 4 5 6 7 8 9 10 11 Part Number 68--15028--00 68--15028--01 34--00928--03 58--04696--00 66U1--5371--6 66U1--5321--8 58--04316--00 66U1--3882 58--00969--00 58--04539--07 68--15053--00 68--15053--01 34--00928--02 Description Channel, 0. 063 Thick Aluminum, White Channel, 0. 063 Thick Aluminum, Orange Rivet, Blind, 1/8 Diameter, Grip Range 3/16--1/4 Drain Screw, Machined Hex Head #10--24 X 0. 750 Slotted Washer, Plain #10 Type A Base, Mounting Wire Tie, 1/16 -- 1 3/4 Self--locking Wire Tie, 2. 80 Diameter, Double Loop Tube, Flexible, 69" Long Shield, 0. 063 Thick Aluminum Shield, 0. 063 Thick Aluminum, Orange Rivet, Blind, 1/8 Diameter, Grip Range 1/8--3/16 Qty A/R A/R 2 1 2 2 5 4 1 1 A/R A/R 2 67 T-334PL 2. 35 ELECTRONIC PARTLOW TEMPERATURE RECORDER- OPTION 9 AND OPTION P 1 2 3 4 7 7 8 9 3 5 6 Item Part Number Description OPTION 9 - NO TEMPERATURE RECORDER 68--12658--01 Recorder Cover, Blue 68--12658--20 Recorder Cover, White 1 68--12658--04 Recorder Cover, Orange 2 66U1--5321--7 Washer, Flat, 1/4 -- SST 3 66U1--5361--25 Screw, Captive Hex Head, 1/4--20 X 0. 75 Long -- SST 4 34--06053--13 Washer, Retaining, 0. 195 ID X 0. 80 OD -- Mylar 5 69NT35--2692--1 Washer, Fender, 1/4 ID X 0. 993--1. 015 OD 6 34--06053--03 Washer, 0. 25 ID X 1. 00 OD -- Mylar Qty A/R A/R A/R 2 4 2 2 2 T-334PL 68 2. 35 ELECTRONIC PARTLOW TEMPERATURE RECORDER- OPTION 9 AND OPTION P (Continued) Item Part Number Description Qty OPTION P - TEMPERATURE RECORDER PROVISION 1 68--12658--01 Recorder Cover, Blue 1 2 66U1--5321--7 Washer, Flat, 1/4 -- SST 2 3 66U1--5361--25 Screw, Captive Hex Head, 1/4--20 X 0. 75 Long -- SST 4 4 34--06053--13 Washer, Retaining, 0. 195 ID X 0. 80 OD -- Mylar 2 5 69NT35--2692--1 Washer, Fender, 1/4 ID X 0. 993--1. 015 OD 2 6 34--06053--03 Washer, 0. 25 ID X 1. 00 OD -- Mylar 2 7 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 4 8 22--01713--16 Harness ML3; E--Record 1 9 22--01713--18 Harness, E--Record Connection 2 69 T-334PL 2. 36 ELECTRONIC PARTLOW TEMPERATURE RECORDER - OPTION 12 AND OPTION 13 1 32 31 2 34 26 35 3 33 30 32 31 31 36 30 LATCH FASTENERS 29 ONLY 6 22 24 7 8 9 2 4 5 38 37 10 39 23 22 26 13 12 11 15 14 27 28 LATCH FASTENERS ONLY 16 17 18 19 25 20 21 14 11 T-334PL 70 2. 36 ELECTRONIC PARTLOW TEMPERATURE RECORDER - OPTION 12 AND OPTION 13 (Continued) Item Part Number Description Qty STANDARD PARTS INCLUDED IN OPTIONS 1 66U1--5321--7 Washer, Plain 1/4 W Type A 2 2 66U1--5361--25 Screw, Captive Hex Head 1/4--20 X 0. 75 4 3 34--06053--13 Washer, Retaining 0. 19 ID X 0. 80 OD (0. 250) 2 4 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 2 5 34--06053--03 Washer 0. 250 ID X 1. 000 OD 2 6 42--01098--01 Gasket, Door 0. 68 X 10. 43 X 20. 23 1 7 69NT35--5352--1 Foam, Double Coated 0. 03 X 8. 37 X 10. 63 1 8 69NT35--5022--5 Window 0. 12 X 8. 37 X 10. 63 1 9 68--13724--00 Bracket, Mounting Window, 0. 090 Thick Aluminum 2 10 34--00795--09 Nut, Self Lock 10--32 4 11 58--04101--07 Protector 0. 010 Thick X 0. 75 X 2. 63 4 12 44--00374--00 Hinge Recorder Door 2 13 34--06179--04 Screw, Hex Head Sems #10--24 X 5/16 4 14 34--06179--00 Screw, Hex Head Sems #10--24 X 7/16 8 15 34--06053--05 Washer 0. 205 ID X 0. 600 OD 4 16 22--01713--16 Harness ML3; E--Record 1 17 58--04246--00 Ty--Rap Base (#10) Mounting Tab 2 18 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 4 19 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 4 20 58--00616--02 Plug, Hole 0. 50 Diameter X 0. 12 Panel 2 21 58--00065--77 Grommet 0. 38 ID X 1. 25 OD 1 OPTION 12 - SPECIAL TEMPERATURE RECORDER INSTALLED See Previous Page for Standard Parts and use with Items Below -76--00701--10 Partlow Recorder Kit, Special -- Includes: Recorder, Box and Door Assem1 OPTION 12 blies (For field installation, units provisioned for - Refer to online matrix) 22 34--06053--00 Washer 0. 250 ID X 0. 800 OD 4 23 66U1--6811--8 Screw, Retaining 0. 300--0. 625 Panel 2 24 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 2 25 12--00464--07 Recorder, Temp Electronic Partlow 1 26 86--04217--02 Box Assembly Welded (Universal) 1 27 34--01142--01 Receptacle #12 Saddle Type 2 28 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 4 29 69NT43--256 Door Assembly 1 71 T-334PL 2. 36 OPTION 12 AND OPTION 13 - ELECTRONIC PARTLOW TEMPERATURE RECORDER (Continued) Item Part Number Description Qty OPTION 13 - STANDARD TEMPERATURE RECORDER INSTALLED See Previous Section for Standard Parts and use with Items Below -76--00701--11 Partlow Recorder Kit, Standard -- Includes: Recorder, Box and Door Assem1 OPTION 13 blies (For field installation, units provisioned for - Refer to online matrix) 22 34--06053--00 Washer 0. 250 ID X 0. 800 OD 4 23 66U1--6811--8 Screw, Retaining 0. 300--0. 625 Panel 2 24 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 2 25 12--00464--08 Recorder, Temp Electronic Partlow (Standard) 1 26 86--04217--01 Box Assembly Welded 1 27 34--01142--01 Receptacle #12 Saddle Type 2 28 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 4 29 69NT43--256 Door Assembly 1 OPTION 13 - STANDARD TEMPERATURE RECORDER INSTALLED, WITH WING SCREWS See Previous Page for Standard Parts and use with Items Below -76--00701--11 Partlow Recorder Kit, Standard -- Includes: Recorder, Box and Door Assem1 OPTION 13 blies (For field installation, units provisioned for - Refer to online matrix) 22 34--06053--00 Washer 0. 250 ID X 0. 800 OD 4 23 66U1--6811--16 Screw, Retaining 0. 300--0. 625 Pnl (Wing) 2 24 34--06169--00 Washer, Retaining 0. 185 ID X 0. 62 OD 2 25 12--00464--08 Recorder, Temp Electronic Partlow (Standard) 1 26 86--04217--01 Box Assembly Welded (Saginomiya) 1 27 34--01142--01 Receptacle #12 Saddle Type 2 28 34--00928--01 Rivet, Blind 0. 125 Diameter 0. 063--0. 125 4 29 69NT43--256 Door Assembly 1 T-334PL 72 2. 36 OPTION 12 AND OPTION 13 - ELECTRONIC PARTLOW TEMPERATURE RECORDER (Continued) Item Part Number Description Qty OPTION 13 - STANDARD TEMPERATURE RECORDER INSTALLED, WITH LATCH FASTENERS 25 12--00464--07 Recorder, Temp Electronic Partlow 1 26 86--04217--02 Box Assembly Welded (Universal) 1 29 69NT43--256 Door Assembly 1 30 34--06053--14 Washer, Retaining 0. 165 ID X 0. 500 OD 2 31 66U1--5321--2 Washer, Plain #8 Type A 6 32 34--00663--08 Washer, Lock #8 Spring 5 33 34--66635--00 Screw, Machined Pinhead #8--32 X 0. 375 Long 5 34 44--66605--00 Latch 2 35 58--04026--74 Protector Latch 2 36 48--66611--00 Pin, Guide Machined 1 37 68--86032--00 Keeper Recorder 2 38 58--04026--73 Protector Electronic, Latch 2 39 34--00928--09 Rivet, Blind 0. 156 Diameter 0. 126--0. 250 4 73 T-334PL 2. 36 OPTION 12 AND OPTION 13 - ELECTRONIC PARTLOW TEMPERATURE RECORDER (Continued) 26 27 28 16 17 18 19 20 21 11 14 DOOR ASSEMBLY 76--00701--13 1 34--06179--04L 2 44--00374--00 3 42--01098--01 4 69NT35--5022--5 5 69NT35--5352--1 6 68--13724--00 7 34--00795--09 8 86--66695--00 9 44--66605--00 10 58--04026--74 11 34--00663--08 12 66U1--5321--2 13 34--66635--00 14 48--66611--00 15 34--06053--14 BOX ASSEMBLY 1 86--04217--03 2 34--06179--00 3 58--04101--07 4 68--86032--00 5 58--04026--73 6 34--00928--09 Door Assembly -- Includes: Screw, Hex Head Sems #10--24 X 5/16 Hinge, Recorder Door Gasket, Door, 0. 68 X 10. 43 X 20. 23 Window, 0. 12 X 8. 37 X 10. 63 Foam, Double Coated, 0. 03 X 8. 37 X 10. 63 Bracket, Mounting, Window, 0. 090 Thick Alum Nut, Self Lock, 10--32 Door Assembly Eg, Latch Latch Protector, Latch Washer, Lock, #8 Spring Washer, Plain, #8 Type A Screw, Machine, Pan Head, #8--32 X 0. 375 Long Pin, Guide Machined Washer, Retaining, 0. 165Id X 0. 500 Od Box Assembly -- Includes: Screw, Hex Head, Sems #10--24 X 7/16 Protector Keeper, Recorder Protector Rivet, Blind 4 2 1 1 1 2 4 1 2 2 5 6 5 1 2 1 4 2 2 2 4 T-334PL 74 2. 37 BULKHEAD PENETRATION - LOWER AIR EXCHANGE - 1 2 Item Part Number OPTION 2 - STANDARD INSTALLED 1 58--04162--01 Duct, Elbow Fresh Air 2 69NT35--8258 Disc, 0. 040 Thick Aluminum Description Qty 1 1 75 T-334PL 2. 38 LOWER FRESH AIR MAKE-UP 21 22 5 23 2 3 4 1 OPTION 1 -- NOT INSTALLED 6 2 3 4 7 8 14 9, 10 11, 12, 24 18 15 19 16 17 11, 24 18 37 38 33 20 9, 10 18 34 35 36 27 28 29 30 31 32 26 25 18 13 OPTION 4 -- WITH VPS AND SCREEN Qty A/R A/R A/R 3 3 3 1 1 1 1 1 2 2 OPTION 2 -- INSTALLED Item Part Number Description OPTION 1 - LOWER FRESH AIR (NONE) 69NT35--4047 Panel, Blank, Blue 69NT35--4047--1 Panel, Blank, Orange 1 69NT35--4047--20 Panel, Blank, White 2 66U1--5361--25 Screw, Hex Head, 1/4--20 X 3/4 Long -- SST 3 34--06053--18 Washer, Mylar, 1/4 ID X 1. 00 OD 4 66U1--5321--3 Washer, Flat, 1/4, Type A-- SST 5 69NT43--307 Bracket, Panel 6 42--00465--00 Gasket 7 69NT35--2692--1 Washer, Fender 1/4 -- SST OPTION 2 - INSTALLED -69NT41--852--3 Cover, Fresh Air Makeup -- Includes: 8 69NT41--257--2 Assembly, Slide 9 34--06092--00 Nut, Hex, 1/4--20 UNC--2B -- SST 10 34--06053--03 Washer, 0. 250 ID X 1. 000 OD T-334PL 76 2. 38 LOWER FRESH AIR MAKE-UP (Continued) Item Part Number Description OPTION 2 - INSTALLED -69NT40--976--3 Cover Assembly, Air Bleed -- Includes: 11 42--00233--01 Gasket, Air Exchange 12 69NT35--6922 Cover, 0. 090 Thick Aluminum 13 42--00295--01 Gasket, Cover 14 42--00295--00 Gasket, Cover 15 69NT35--2692--1 Washer, Fender 1/4 -- 0. 993--1. 015 OD 16 66U1--5362--1 Nut, Wing, 1/4--20 Type A -- SST 17 58--00836--19 Spacer, Nylon, 0. 50 D X 0. 562 L 76--50116--03 Label Kit -- Includes: 62--10540--04 Label, Air Exchange, CMH -- English 66CH1--1002--33 Label, Arrow 76--50116--00 Label Kit -- Includes: 69NT35--1417 Label, Air Exchange, CMH -- English (Maersk Specification) 66CH1--1002--33 Label, Arrow (Maersk Specification) 76--50116--01 Label Kit -- Includes: 69NT35--9238 Label, Air Exchange, CFM -- English/Spanish 18 66CH1--1002--33 Label, Arrow 76--50116--02 Label Kit -- Includes: 62--10540--00 Label, Air Exchange, CMH -- English/Spanish/Chinese 66CH1--1002--33 Label, Arrow 76--50116--04 Label Kit -- Includes: 62--10540--00 Label, Air Exchange, CMH -- English/Spanish/Chinese (NYK Specification) 62--10381--00 Label, Arrow (NYK Specification) 19 69NT41--782 Bushing 20 69NT35--7012 Label, Fresh Air 21 69NT35--8348 Baffle, Unpainted 22 34--00928--09 Rivet, Blind, 0. 156 Diameter, Grip Range -- 3/16--1/4 69NT35--1287--1 Label, Fresh Air Exchange, CMH -- English (Maersk Specification) 69NT35--9228 Label, Fresh Air Exchange, CFM -- English/Spanish 23 62--10537--00 Label, Fresh Air Exchange, CMH -- English/Japanese/Chinese 62--10381--00 Label, Fresh Air Exchange, CMH -- English OPTION 4 - INSTALLED WITH SCREENS AND VPS - USE ALL OF OPTION 2 PLUS ITEM BELOW 24 58--04263--01 Screen Assembly, Medfly 25 76--50136--00 Assembly, Vent Position Sensor -- Includes: 26 79--01925--00 Sensor Assembly -- Includes: 27 48--00377--00 Gear, Auto Lower Fresh Air 28 34--06262--00 Screw, Set #8-- 32 X 0. 156 Long 29 34--06287--00 Nut, Hex Jam 3/ 8-- 32 30 34--06286--00 Washer, Lock 3/ 8-- 32 31 68--14955--00 Bracket, 0. 063 Thick SST 32 10--00455--00 Sensor, LVPS, Potentiometer 33 66U1--5371--7 Screw, Hex Head 10--24 X 1/2 Long SST 34 34--00666--09 Nut, Hex, 10--24 UNC--2B -- SST 35 66U1--5321--8 Washer, Flat, 1/2, Type A-- SST 36 34--06053--04 Washer, Mylar 37 62--10984--00 Label, LVPS, Air Exchange 38 79--01934--00 Assembly, Slide 77 Qty 2 2 2 1 1 2 2 2 1 2 3 1 2 3 1 2 3 1 2 3 1 2 3 2 1 1 4 1 1 1 1 2 1 1 1 1 1 1 1 1 2 2 2 2 1 1 T-334PL 2. 39 LABELS AND DECALS (Not Applicable to All Units) 12 1 17 11 10 13 VIEW -- INSIDE CONTROL BOX DOOR 9 VIEW -- INSIDE CONTROL BOX 2 or 3 4 8 7 18 15 5 16 6 Item Part Number STANDARD LABELS 62--10754--00 1 62--10754--01 2 69NT35--3867 3 69NT20--1893--1 4 62--10799--02 5 62--02444--01 6 62--02458--01 7 62--02863--01 8 62--02530--01 9 62--10356--00 10 66CH1--1002--33 11 62--10926--00 12 62--66678--01 Description Decal, Carrier EliteLine Decal, Carrier EliteLine Label, Economy Mode Label, Degrees --C to Degrees --F Label, Function Code -- English Label, Charge with R--134a Label, POE Compressor Oil Label, Fan Warning Label, R--134a -- Ozone Protection, Umbrella Only Label, No Medfly Label, ">" (Arrow) Label, Cmh--Cfm Conversion Label, Refrigeration System Qty 1 1 1 1 1 1 1 1 1 1 1 1 1 14 19 T-334PL 78 2. 39 LABELS AND DECALS (Continued) Item Part Number Description OPTION 1 - ENGLISH 13 62--10904--00 Label, Welding Precautions -- English 62--02743--16 Label, Operating Instructions (Electronic Partlow with Supply and Return Air) 14 62--02743--18 Label, Operating Instructions (No Recorder) 15 62--11009--00 Label, Compressor Removal -- English 16 62--11139--00 Label, Warning Compressor Power--Up -- English 62--02723--00 Label, Fresh Air Makeup -- English 62--02723--03 Label, Fresh Air Makeup (with Full CMH) -- English 17 62--02723--10 Label, Fresh Air Makeup (with Full CMH + CFM) -- English OPTION 2 - ENGLISH/SPANISH 13 62--10904--02 Label, Welding Precautions -- English/Spanish 62--02743--01 Label, Operating Instructions (Partlow with Return Air) -- English/Spanish 14 62--02743--10 Label, Operating Instructions (No Recorder) -- English/Spanish 16 62--11139--02 Label, Warning Compressor Power--Up -- English/Spanish 62--02723--02 Label, Fresh Air Makeup -- English/Spanish 17 62--02723--04 Label, Fresh Air Makeup (with Full CMH) -- English/Spanish 18 62--10998--00 Label, Secure Cable with Tie Wrap -- English/Spanish OPTION 5 - ENGLISH/TRADITIONAL CHINESE 13 62--10904--04 Label, Welding Precautions -- English/Chinese 14 62--02743--19 Label, Operating Instructions (Electronic Partlow with Supply and Return Air) -- English/Chinese 15 62--11009--01 Label, Compressor Removal -- English/Chinese 16 62--11139--01 Label, Warning Compressor Power--Up -- English/Chinese 17 62--02723--06 Label, Fresh Air Makeup -- English/Chinese 19 62--66644--00 Label, Manual Defrost Instructions -- English/Chinese Qty 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 79 T-334PL 2. 40 EVAPORATOR TUBING AND COIL 19 1, 2, 3, 33 17 18 16 15 1 7 8 9 14 20 21 10 11 11 12 13 6 22 27 26 28 5 3 4 11 13 34 OPTION 7 ONLY 20 23 24 13 25 30 56 31 36 37 32 31 55 49 50 51 52 53 54 32 38 OPTION 7 ONLY 35 29 39 47 48 43 44 45 46 42 41 40 OPTION 7 - STANDARD TXV VIEW - OPTION 8 - TXV BYPASS VIEW - T-334PL 80 2. 40 EVAPORATOR TUBING AND COIL (Continued) Item Part Number Description STANDARD PARTS INCLUDED IN OPTIONS 1 66U1--5321--3 Washer, Plain 1/4 N Type A 2 66U1--5361--25 Screw, Captive Hex Head 1/4--20 X 0. 75 3 34--00663--11 Washer, Lock 1/4 Spring 4 AA06JA--166 Screw, Captive Hex Head 1/4--20 X 0. 50 5 68--15216--00 Bracket, Support 0. 125 Thick Aluminum 6 66U1--7452--3 Screw, Lag 1/4--10 X 2. 00 Hex Head 7 44--01143--05 Clamp, Tube 1/4 and 1/2 Diameter Multiple 8 34--00655--10 Screw, Captive Hex Head 1/4--20 X 1. 25 9 34--00667--11 Nut, Self Lock 1/4--20 10 34--00373--51 Clamp, Tube 0. 25 Diameter Cushion 11 66U1--5381--1 Screw, Hex Head #10--24 X 0. 75 L, Thread Cutting 12 68--14890--00 Bracket 0. 125Thick Aluminum 13 44--00370--03 Clamp, Cushioned 0. 50 Diameter 14 56--08503--00 Tube, Liquid 0. 500 OD X 0. 035 Wall Cu 15 56--08501--00 Tube, Liquid 0. 500 OD X 0. 035 Wall Cu 16 56--08502--00 Tube, Suction 1. 125 OD X 0. 050 Wall Cu 17 58--04664--00 Insulation, Foam Formed, TXV Bulb 18 66U1--3882--3 Wire Tie 1/16--4. 0 Self--locking 19 56--08500--00 Tube, Equalizer 0. 250 OD X 0. 028 Wall Cu 20 34--00928--09 Rivet, Blind 0. 156 Diameter 0. 126--0. 250 21 68--15002--01 Bracket 0. 125 Thick Aluminum 22 42--00667--12 Insulation, Tube Pre--Taped 23 68--14999--00 Bracket 0. 090 Thick Aluminum 24 42--00667--13 Insulation, Tube Pre--Taped 25 66U1--5371--7 Screw, Machined Hex Head #10--24 X 0. 500 Slotted 26 66U1--1571--3 Grommet 0. 50 ID X 1. 00 OD 27 58--00065--46 Grommet 0. 25 ID X 0. 75 OD X 0. 12 28 58--00065--56 Grommet 0. 62 ID X 0. 12 Groove 29 68--14892--00 Plate, Cover, 0. 125 Thick Aluminum 30 62--10980--00 Label, TXV Bulb 31 14--00273--09 Valve Assembly, Expansion Hermetic, Liquid 32 56--08345--00 Tube 0. 625 OD Liquid Qty 12 9 10 1 1 1 1 1 1 1 13 1 3 1 1 1 1 2 1 4 1 1 1 1 1 1 2 1 1 1 1 1 81 T-334PL 2. 40 EVAPORATOR TUBING (Continued) Item Part Number Description OPTION 7 - STANDARD THERMOSTATIC EXPANSION VALVE (TXV) See Previous Section for Standard Parts and Use with Items Below: 81--01925--01 Coil Assembly, Evaporator TXV, with Varnish 33 81--01925--00 Coil Assembly, Evaporator TXV, without Varnish 34 34--00373--59 Clamp, Tube 0. 75 Diameter Cushion 35 68--15015--00 Bracket, TXV 0. 125 Thick Aluminum 36 56--08348--00 Tube 0. 25 OD Equalizer 37 56--08346--00 Tube 0. 375 OD Liquid OPTION 8 - STANDARD THERMOSTATIC EXPANSION VALVE WITH BYPASS ASSEMBLY See Previous Page for Standard Parts and Use with Items Below: 33 81--01925--00 Coil Assembly, Evaporator TXV, without Varnish 38 40--00169--16 Tee, Reducing 5/8 X 5/8 X 3/8 39 56--08588--00 Tube 0. 25 OD X 0. 035 Wall 40 56--08589--00 Tube 3/8 OD X 0. 028 Wall 41 DE40BA--101 Tee, 3/8 42 56--08590--00 Tube, Liquid 3/8 OD X 0. 035 Wall 43 68--15385--01 Bracket, TXV 0. 125 Thick Aluminum 44 66U1--5371 Screw, Machined Hex Head #8--32 X 1/2 Long Slotted 45 66U1--5321--2 Washer, Plain #8 Type A 46 66U1--5331--4 Washer, Lock #8 Spring 47 66U1--3803 Tube, Heat Shrink 0. 25 X 2. 12 Blk 48 66U1--3882 Wire Tie 1/16--1--3/4 Self--locking 49 14--01090--15 Valve, Solenoid 50 14--01091--04 Coil Kit, Solenoid Valve -- Includes: 51 NSS Coil, Solenoid 52 NSS O--Ring, Top 53 NSS O--Ring, Bottom NSS Spacer, Brass (Used on ESV Only) 54 NSS Screw, Mounting 55 66U1--5371--6 Screw, Machined Hex Head #10--24 X 0. 750 Slotted 56 56--08591--00 Tube, Liquid 3/8 OD X 0. 028 Wall Qty A/R A/R 1 1 1 1 1 1 1 1 1 1 1 2 2 2 2 3 1 1 1 1 1 1 1 1 1 T-334PL 82 2. 41 EVAPORATOR FAN ASSEMBLY 7 8 9 8 10 11 13, 14, 15 16, 17, 18, 19, 20 12 5 1 2 3 4 6 + TOP VIEW Item Part Number Description 1 69NT43--295 Mounting Bracket, Evaporator Fan Assembly 2 69NT35--2692--1 Washer, Fender 3 34--00663--11 Washer, Lock, 1/4 -- SST 4 34--06165--08 Screw, Hex Head, 1/4--20 X 1. 00 -- SST (Red) 5 34--00655--08 Screw, Captive Hex Head, 1/4--20 X 1. 00 6 66U1--5321--3 Washer, Flat, 1/4 -- SST 7 34--00795--17 Nut, Self Locking, 5/8--18 -- SST 8 34--00616--06 Washer, Special, 5/8 -- SST 9 38--00557--00 Fan, Evaporator 10 48--00262--00 Stator, Evaporator 11 58--04066--00 Protector -- Mylar 12 66U1--2552--185 Gasket, 0. 75 Thick X 1. 5 X 16. 63 OPTION 1 - EVAPORATOR FAN MOTOR, SINGLE-PHASE 13 54--00585--20 Motor, Evaporator Fan, Single--Phase -- Includes: 14 04--50027--00 Bearing, Front (Shaft End) 15 54--50027--01 Bearing, Back NS 22--50088--00 Capacitor (20 F) High Speed 16 22--01997--11 Cap, Housing 17 22--01997--13 Seal, Wire 18 22--01997--04 Pin 19 22--01997--09 Pin, Grounding 20 22--01997--08 Plug, Sealing Plug Assembly, Motor (Refer to Section 2. 45) OPTION 3 - EVAPORATOR FAN MOTOR, THREE-PHASE 13 54--00615--20 Motor, Evaporator Fan, Three--Phase -- Includes: 14 04--50029--00 Bearing, Front (Shaft End) 15 04--50029--01 Bearing, Back 16 22--01997--19 Cap, Housing 17 22--01997--21 Seal, Wire 18 22--01997--04 Pin 19 22--01997--09 Pin, Grounding 20 22--01997--08 Plug, Sealing Plug Assembly, Motor (Refer to Section 2. 45) 83 Qty 4 8 8 8 4 8 2 4 2 2 2 1 2 1 1 1 1 1 6 1 2 1 1 1 1 8 1 3 T-334PL 2. 42 HEATERS AND SENSORS (REAR PANELS REMOVED) 1 (RTS and RRS) 17 13 14 15 16 18 4 5 6 4 7 8 9 10 2 3 12 11 (INSIDE) T-334PL 84 2. 42 HEATERS AND SENSORS (Continued) Item Part Number Description HEATERS 1 12--00500--01SV Sensor Assembly (RRS and RTS) 2 12--00495--02SV Sensor, Thermistor, Defrost (DTS) 3 34--01178--22 Screw, Hex Head, #8--32 X 1/2 Long -- SST 4 AU11JR--171 Washer, Lock, 1/4 -- Spring 5 66U1--5361--25 Screw, Cap, Hex Head, 1/4--20 X 3/4 Long -- SST 6 66U1--5321--3 Washer, Flat, 1/4 -- SST 7 68--13600--00 Retainer (For Heaters) 8 69NT35--6532 Clip (For Heaters) 9 69NT35--2692--1 Washer, Fender 1/4--0. 993--1. 015 OD 10 66U1--5371--13 Screw, Hex Head, #10--24 X 1. 25 Long -- SST 11 12--00170--08 Thermostat, Heat Termination (HTT) 12 24--00006--02 Heater, Evaporator Coil OPTION X - DEHUMIDIFICATION INSTALLED -76--00675--01 Kit, Humidity Sensor (Field installation, units provisioned for) Includes: 13 10--00413--00 Sensor, Humidity (HS) 14 66U1--5371--10 Screw, Hex Head, #10--24 X 1. 00 Long -- SST 15 66U1--5321--8 Washer, Flat, #10 -- SST 16 68--13181--00 Bracket Assembly, Humidity Sensor OPTION P - NO DEHUMIDIFICATION INSTALLED OR PROVISION FOR DEHUMIDIFICATION 17 66U1--8292--1 Cap, Insulating 0. 125 OD Black 18 58--04026--67 Protector 1. 50 X 9. 75 with 2 Holes Qty 1 1 3 10 9 A/R 3 4 2 2 1 6 -1 4 2 1 3 1 85 T-334PL 2. 43 BACK PANEL ASSEMBLY 1, 2, 3 13 20 INTERIOR VIEW OF PANELS 10 9 19 18 4 7 8 5 6 11 12 17 16 OPTION 2 14 15 T-334PL 86 2. 43 BACK PANEL ASSEMBLY (Continued) Item Part Number Description OPTION 1 - ALUMINUM BOLTED 1 34--00928--03 Rivet, Blind, 1/8 Diameter, Grip Range -- 3/16--1/4 2 68--14373--00 Plate, 0. 063 Thick Aluminum 3 58--04624--00 Drain, Condensate 4 76--00746--06 Panel Assembly, Upper -- Includes: 5 68--15275--00 Panel Assembly, Back 6 68--15013--00 Drain Pan, Center (Location -- Behind Upper Panel -- Top) 7 68--15014--00 Drain Pan, Side (Location -- Behind Upper Panel) 8 34--00928--02 Rivet, Blind 1/8 Diameter, Grip Range -- 1/8--3/16 9 42--00174--34 Gasket 0. 25 T X 1. 5 W X 64. 25 10 42--00334--00 Gasket 1. 22 X 68. 75 V--Type 11 69NT35--2692 Washer, Fender, #10 X 1. 00 OD -- SST 66U1--2403 Screw, Machine, Truss Head, #10--24 X 1/2 Long -- SST 12 66U1--7982--2 Rivet, TIR, 3/16 Diameter, Grip Range -- 5/64--11/64 13 66U1--2593--24 Gasket, 20. 48 Long V--Type 68--86013--00 Panel, Back 0. 125 Thick Aluminum 14 68--14046--00 Panel, Back 0. 080 Thick Aluminum 15 34--00928--04 Rivet, Blind, 1/8 Diameter, Grip Range -- 1/4--5/16 OPTION 4 - HINGED PANEL 1 34--00928--03 Rivet, Blind, 1/8 Diameter, Grip Range -- 3/16--1/4 2 68--14373--00 Plate, 0. 063 Thick Aluminum 3 58--04624--00 Drain, Condensate 4 76--00746--07 Panel Assembly, Upper -- Includes: 5 68--15275--01 Panel Assembly, Back, 0. 080 7 68--15014--00 Drain Pan, Side (Location -- Behind Upper Panel) 6 68--15013--00 Drain Pan, Center (Location -- Behind Upper Panel -- Top) 8 34--00928--02 Rivet, Blind 1/8 Diameter, Grip Range -- 1/8--3/16 9 42--00174--34 Gasket 0. 25 T X 1. 5 W X 64. 25 10 42--00334--00 Gasket 1. 22 X 68. 75 V--Type 13 66U1--2593--24 Gasket, 20. 48 Long V--Type 14 68--14046--00 Panel, Back 0. 080 Thick Aluminum 16 69NT35--3282 Hinge 17 34--00928--09 Rivet, Blind, 5/32 Diameter, Grip Range 1/8--1/4 18 34--01150--06 Stud, Captive 1. 03 1/4 Turn Fastener 19 34--01150--03 Stud, Captive 0. 94 1/4 Turn Fastener 20 34--01150--31 Receptacle, 1/4 Turn Fastener 21 34--01150--30 Washer, Lock, 1/4 Turn Fastener Qty 2 1 1 1 1 1 1 44 1 1 19 19 A/R 2 1 1 6 2 1 1 1 1 1 1 44 1 1 2 1 4 16 6 8 14 14 87 T-334PL 2. 44 HARNESS - LOW VOLTAGE 10 KE 1 EC (A-K) EC (L-Y) 2 3 SMV HPS 4 5 SPT ICF 6 DPT 7 Qty Item Part Number Description OPTION P - PROVISIONED FOR USDA 22--04083--00 Harness, Low Voltage -- Includes: 22--04083--09 Harness, Low Voltage -- Includes: 22--04083--11 Harness, Low Voltage -- Includes: 22--04083--12 Harness, Low Voltage -- Includes: 22--04083--15 Harness, Low Voltage -- Includes: 1 EC (A--K) -- Includes: 22--01777--06 Seal 22--01777--07 O--Ring 66U--6651--24 Bolt, Stainless Steel, 10--24 22--01777--00SV Block 22--01777--03 Terminal 22--50100--00 Pin 2 EC (L--Y) -- Includes: 22--01777--06 Seal 77--01777--07 O--Ring 66U1--6651--24 Bolt, Stainless Steel, 10--24 22--01777--01 Block 22--01777--03 Terminal 22--01777--04 Seal, Plug Connector 1 1 1 1 21 4 1 1 1 1 23 12 T-334PL 88 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number OPTION P - PROVISIONED FOR USDA (Continued) 3 SMV -- Includes: 22--01585--04 Block 22--01566--01 Terminal 22--02394--02 Terminal 4 HPS -- Includes: 22--02392--00 Block 22--02393--01 Terminal 22--02394--00 Cable 5 SPT -- Includes: 22--01944--00 Block 22--01944--10 Gasket 22--01944--05 Cap 22--01777--03 Terminal 6 DPT -- Includes: 22--02448--00SV Block 22--01777--03 Terminal 7 ICF -- Includes: 22--01660--03 Block 22--01613--14 Terminal 10 KE -- Includes: 22--04031--01 Connector 22--04032--00 Terminal Description Qty 1 4 4 1 2 2 1 1 1 3 1 3 1 5 1 5 89 T-334PL 2. 44 HARNESS - LOW VOLTAGE (Continued) - 10 KE 1 EC (A-K) EC (L-Y) 2 USDA A A A A B 3 SMV 9 HPS 4 5 SPT ICF 6 DPT 7 Item Part Number Description OPTION 2 - USDA INSTALLED 22--04083--01 Harness, Low Voltage -- Includes: 22--04083--07 Harness, Low Voltage -- Includes: 1 EC (A--K) -- Includes: 22--01777--06 Seal 22--01777--07 O--Ring 66U--6651--24 Bolt, Stainless Steel, 10--24 22--01777--00SV Block 22--01777--03 Terminal 22--50100--00 Pin 2 EC (L--Y) -- Includes: 22--01777--06 Seal 77--01777--07 O--Ring 66U1--6651--24 Bolt, Stainless Steel, 10--24 22--01777--01 Block 22--01777--03 Terminal 22--01777--04 Seal, Plug Connector T-334PL 90 Qty 1 1 1 1 21 4 1 1 1 1 23 12 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number OPTION 2 - USDA INSTALLED (Continued) 3 SMV -- Includes: 22--01585--04 Block 22--01566--01 Terminal 22--02394--02 Terminal 4 HPS -- Includes: 22--02392--00 Block 22--02393--01 Terminal 22--02394--00 Cable 5 SPT -- Includes: 22--01944--00 Block 22--01944--10 Gasket 22--01944--05 Cap 22--01777--03 Terminal 6 DPT -- Includes: 22--02448--00SV Block 22--01777--03 Terminal 7 ICF -- Includes: 22--01660--03 Block 22--01613--14 Terminal 9 USDA -- Includes: 9A -- Includes: 22--01660--00 Block 22--01613--14 Terminal 22--01614--06 Plug 9B -- Includes: 22--01660--03 Block 22--01613--14 Terminal 10 KE -- Includes: 22--04031--01 Connector 22--04032--00 Terminal Description Qty 1 4 4 1 2 2 1 1 1 3 1 3 1 5 4 8 4 1 5 1 5 91 T-334PL 2. 44 HARNESS - LOW VOLTAGE (Continued) 10 KE A 1 EC (A-K) EC (L-Y) LVPS 2 3 SMV 8 USDA A A A B 9 HPS 6 ICF SPT 5 4 DPT 7 Item Part Number Description OPTION 3 - USDA AND LOWER FRESH AIR WITH VENT POSITIONING SYSTEM INSTALLED 22--04083--02 Harness, Low Voltage -- Includes: 22--04083--05 Harness, Low Voltage -- Includes: 22--04083--06 Harness, Low Voltage -- Includes: 22--04083--13 Harness, Low Voltage -- Includes: 1 EC (A--K) -- Includes: 22--01777--06 Seal 22--01777--07 O--Ring 66U--6651--24 Bolt, Stainless Steel, 10--24 22--01777--00SV Block 22--01777--03 Terminal 22--50100--00 Pin 2 EC (L--Y) -- Includes: 22--01777--06 Seal 77--01777--07 O--Ring 66U1--6651--24 Bolt, Stainless Steel, 10--24 22--01777--01 Block 22--01777--03 Terminal 22--01777--04 Seal, Plug Connector Qty 1 1 1 1 21 4 1 1 1 1 23 12 T-334PL 92 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number Description Qty OPTION 3 - USDA AND LOWER FRESH AIR WITH VENT POSITIONING SYSTEM INSTALLED (Continued) 3 SMV -- Includes: 22--01585--04 Block 1 22--01566--01 Terminal 4 22--02394--02 Terminal 4 4 HPS -- Includes: 22--02392--00 Block 1 22--02393--01 Terminal 2 22--02394--00 Cable 2 5 SPT -- Includes: 22--01944--00 Block 1 22--01944--10 Gasket 1 22--01944--05 Cap 1 22--01777--03 Terminal 3 6 DPT -- Includes: 22--02448--00SV Block 1 22--01777--03 Terminal 3 7 ICF -- Includes: 22--01660--03 Block 1 22--01613--14 Terminal 5 8 LVPS -- Includes: 22--01613--10 Block 1 22--01613--13 Terminal 3 22--01613--11 Lock, Secondary 1 22--01614--06 Plug, Sealing 1 9 USDA -- Includes: 9A -- Includes: 22--01660--00 Block 4 22--01613--14 Terminal 8 22--01614--06 Plug 4 9B -- Includes: 22--01660--03 Block 1 22--01613--14 Terminal 5 10 KE -- Includes: 22--04031--01 Connector 1 22--04032--00 Terminal 5 93 T-334PL 2. 44 HARNESS - LOW VOLTAGE (Continued) - 10 KE 1 EC (A-K) EC (L-Y) 2 3 SMV A B C A A A 8 USDA D A B 9 HPS 5 7 ICF SPT 4 6 DPT Item Part Number Description OPTION 4 - USDA AND EMERGENCY BYPASS SYSTEM INSTALLED 22--04083--03 Harness, Low Voltage -- Includes: 22--04083--04 Harness, Low Voltage -- Includes: 1 EC (A--K) -- Includes: 22--01777--06 Seal 22--01777--07 O--Ring 66U--6651--24 Bolt, Stainless Steel, 10--24 22--01777--00SV Block 22--01777--03 Terminal 22--50100--00 Pin 2 EC (L--Y) -- Includes: 22--01777--06 Seal 77--01777--07 O--Ring 66U1--6651--24 Bolt, Stainless Steel, 10--24 22--01777--01 Block 22--01777--03 Terminal 22--01777--04 Seal, Plug Connector Qty 1 1 1 1 21 4 1 1 1 1 23 12 T-334PL 94 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number Description OPTION 4 - USDA AND EMERGENCY BYPASS SYSTEM INSTALLED (Continued) 3 SMV -- Includes: 22--01585--04 Block 22--01566--01 Terminal 22--02394--02 Terminal 4 SPT -- Includes: 22--01944--00 Block 22--01944--10 Gasket 22--01944--05 Cap 22--01777--03 Terminal 5 DPT -- Includes: 22--02448--00SV Block 22--01777--03 Terminal 6 HPS -- Includes: 22--02392--00 Block 22--02393--01 Terminal 22--02394--00 Cable 7 ICF -- Includes: 22--01660--03 Block 22--01613--14 Terminal 8 8A -- Includes: 22--01585--04 Block 22--01566--01 Terminal 22--02394--02 Seal 8B -- Includes: 22--02392--03 Block 22--02393--01 Terminal 22--02394--02 Seal 8C -- Includes: 22--01613--10 Block 22--01613--15 Terminal 22--01613--11 Secondary Lock 22--01614--06 Sealing Plug 8D -- Includes: 22--01313--22 Block 22--01613--14 Terminal 22--01613--26 Secondary Lock 9 USDA -- Includes: 9A -- Includes: 22--01660--00 Block 22--01613--14 Terminal 22--01614--06 Plug 9B -- Includes: 22--01660--03 Block 22--01613--14 Terminal 10 KE -- Includes: 22--04031--01 Connector 22--04032--00 Terminal 95 Qty 1 4 4 1 1 1 3 1 3 1 2 2 1 5 1 4 4 1 1 4 1 3 1 1 1 8 1 4 8 4 1 5 1 5 T-334PL 2. 44 HARNESS - LOW VOLTAGE (Continued) - 1 EC (A-K) EC (L-Y) A A A A 2 B 9 8 C D USDA A B 3 SMV HPS 5 SPT 4 6 DPT Item Part Number Description OPTION 5 - USDA AND SINGLE EVAPORATOR FAN CAPABILITY INSTALLED 22--04083--10 Harness, Low Voltage -- Includes: 1 EC (A--K) -- Includes: 22--01777--06 Seal 22--01777--07 O--Ring 66U--6651--24 Bolt, Stainless Steel, 10--24 22--01777--00SV Block 22--01777--03 Terminal 22--50100--00 Pin 2 EC (L--Y) -- Includes: 22--01777--06 Seal 77--01777--07 O--Ring 66U1--6651--24 Bolt, Stainless Steel, 10--24 22--01777--01 Block 22--01777--03 Terminal 22--01777--04 Seal, Plug Connector 3 SMV -- Includes: 22--01585--04 Block 22--01566--01 Terminal 22--02394--02 Terminal Qty 1 1 1 1 21 4 1 1 1 1 23 12 1 4 4 T-334PL 96 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number Description OPTION 5 - USDA AND SINGLE EVAPORATOR FAN CAPABILITY INSTALLED (Continued) 4 SPT -- Includes: 22--01944--00 Block 22--01944--10 Gasket 22--01944--05 Cap 22--01777--03 Terminal 5 DPT -- Includes: 22--02448--00SV Block 22--01777--03 Terminal 6 HPS -- Includes: 22--02392--00 Block 22--02393--01 Terminal 22--02394--00 Cable 8 8A -- Includes: 22--01585--04 Block 22--01566--01 Terminal 22--02394--02 Seal 8B -- Includes: 22--02392--03 Block 22--02393--01 Terminal 22--02394--02 Seal 8C -- Includes: 22--01613--10 Block 22--01613--15 Terminal 22--01613--11 Secondary Lock 22--01614--06 Sealing Plug 8D -- Includes: 22--01313--22 Block 22--01613--14 Terminal 22--01613--26 Secondary Lock 9 USDA -- Includes: 9A -- Includes: 22--01660--00 Block 22--01613--14 Terminal 22--01614--06 Plug 9B -- Includes: 22--01660--03 Block 22--01613--14 Terminal Qty 1 1 1 3 1 3 1 2 2 1 4 4 1 1 4 1 3 1 1 1 8 1 4 8 4 1 5 97 T-334PL 2. 44 HARNESS - LOW VOLTAGE (Continued) - 10 KE A 1 EC (A-K) EC (L-Y) LVPS 2 3 SMV 8 OPTION 7 ONLY A A A B USDA 9 HPS 6 SPT 5 4 DPT OPTIONS 6 AND 7 - USDA AND EXPANSION BYPASS VALVE INSTALLED Item Part Number Description OPTION 6 - USDA AND EXPANSION BYPASS VALVE INSTALLED 22--04083--08 Harness, Low Voltage -- Includes: 1 EC (A--K) -- Includes: 22--01777--06 Seal 22--01777--07 O--Ring 66U--6651--24 Bolt, Stainless Steel, 10--24 22--01777--00SV Block 22--01777--03 Terminal 22--50100--00 Pin 2 EC (L--Y) -- Includes: 22--01777--06 Seal 77--01777--07 O--Ring 66U1--6651--24 Bolt, Stainless Steel, 10--24 22--01777--01 Block 22--01777--03 Terminal 22--01777--04 Seal, Plug Connector Qty 1 1 1 1 21 4 1 1 1 1 23 12 T-334PL 98 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number Description Qty OPTION 6 - USDA AND EXPANSION BYPASS VALVE INSTALLED (Continued) 3 SMV -- Includes: 22--01585--04 Block 1 22--01566--01 Terminal 4 22--02394--02 Terminal 4 4 HPS -- Includes: 22--02392--00 Block 1 22--02393--01 Terminal 2 22--02394--00 Cable 2 5 SPT -- Includes: 22--01944--00 Block 1 22--01944--10 Gasket 1 22--01944--05 Cap 1 22--01777--03 Terminal 3 6 DPT -- Includes: 22--02448--00SV Block 1 22--01777--03 Terminal 3 9 USDA -- Includes: 9A -- Includes: 22--01660--00 Block 4 22--01613--14 Terminal 8 22--01614--06 Plug 4 9B -- Includes: 22--01660--03 Block 1 22--01613--14 Terminal 5 10 KE -- Includes: 22--04031--01 Connector 1 22--04032--00 Terminal 5 OPTION 7 - USDA, EXPANSION BYPASS VALVE AND LOWER VPS INSTALLED - INCLUDES ALL OF OPTION 6 AND ITEMS BELOW: 22--04083--14 Harness, Low Voltage -- Includes ALL OF OPTION 6 AND: 8 LVPS -- Includes: 22--01613--10 Block 1 22--01613--13 Terminal 3 22--01613--11 Lock, Secondary 1 22--01614--06 Plug, Sealing 1 99 T-334PL 2. 44 HARNESS - LOW VOLTAGE (Continued) 1 KD 3 4 5 6 SD 2 7 COS EC 9 8 T-334PL 100 2. 44 HARNESS - LOW VOLTAGE (Continued) Item Part Number Description OPTION 8 - EAUTOFRESH 1 22--01713--26 Harness, eAutoFresh -- Includes 2 SD -- Includes: 22--01566--01 Terminal 22--02394--02 Seal 3 58--00848--37 Wire Cover 4 58--04706--00 Grommet 5 66U1--8292--01 Cap, Insulating 6 KD -- Includes: 22--04031--00 Block 22--04032--00 Terminal 7 KOS -- Includes: 22--01613--12 Terminal 8 22--01713--21 Wire Harness -- Includes: 22--02392--03 Block 22--02393--01 Terminal 22--02394--02 Seal 22--01565--01 Plug 9 22--01713--20 Wire Harness -- Includes: 22--01613--10 Block 22--01613--13 Terminal 22--01613--11 Lock 22--01614--06 Plug Qty 1 5 5 1 1 1 1 4 4 1 1 1 3 1 1 1 3 101 T-334PL 2. 45 HARNESS - HIGH VOLTAGE CIC 1 MA CIB 6 2 KA KD 5 3 4 KB T-334PL 102 2. 45 HARNESS - HIGH VOLTAGE (Continued) Item Part Number STANDARD PARTS INCLUDED IN OPTIONS 1 CIC -- Includes: 22--01556--06 Block, CIC 22--02324--09 Terminal 2 CIB -- Includes: 22--01556--04 Block, CIB 22--01735--00 Terminal 3 KD -- Includes: 22--04031--00 Block, KD 22--04032--00 Terminal 4 KB -- Includes: 22--01556--01 Block, KB 22--01735--00 Terminal 5 KA -- Includes: 22--01556--02 Block, KA 22--01735--00 Terminal 6 MA -- Includes: 22--01622--01 Block, MA 22--01622--03 Terminal Description Qty 1 3 1 3 1 4 1 5 1 10 1 5 103 T-334PL 2. 45 HARNESS - HIGH VOLTAGE (Continued) 10 CM EBS 9 7 EM1 EM2 8 T-334PL 104 2. 45 HARNESS - HIGH VOLTAGE (Continued) Item Part Number Description OPTION 1 - SINGLE-PHASE EVAPORATOR MOTORS 91--00373--00 High Voltage Harness -- Single--Phase Evaporator Motor -- Includes: 91--00373--01 High Voltage Harness -- Single--Phase Evaporator Motor -- Includes: 91--00373--03 High Voltage Harness -- Single--Phase Evaporator Motor -- Includes: 91--00373--04 High Voltage Harness -- Single--Phase Evaporator Motor -- Includes: 91--00373--05 High Voltage Harness -- Single--Phase Evaporator Motor -- Includes: 91--00373--06 High Voltage Harness -- Single--Phase Evaporator Motor -- Includes: See Previous Section for Standard Parts and use with Items Below: 7 EM1 -- Includes: 22--01997--12 Plug, EM1 22--01997--06 Terminal 22--01997--08 Sealing Plug 22--01997--13 Wire Seal 22--01997--14 Interface Seal 8 EM2 -- Includes: 22--01997--12 Plug, EM2 22--01997--06 Terminal 22--01997--08 Sealing Plug 22--01997--13 Wire Seal 22--01997--14 Interface Seal 9 EBS -- Includes: 22--01997--16 Plug, EBS 22--01997--06 Terminal 22--01997--17 Wire Seal 22--01997--18 Interface Seal 10 CM -- Includes: 22--01997--01 Plug CM 22--01997--06 Terminal 22--01997--08 Sealing Plug 22--01997--02 Wire Seal 22--01997--03 Interface Seal Qty 1 5 2 1 1 1 5 2 1 1 1 4 1 1 1 3 1 1 1 105 T-334PL 2. 45 HARNESS - HIGH VOLTAGE (Continued) CM 10 9 EBS 7 EM1 8 EM2 T-334PL 106 2. 45 HARNESS - HIGH VOLTAGE (Continued) Item Part Number Description OPTION 2 - THREE-PHASE EVAPORATOR MOTORS 91--00382--00 High Voltage Harness -- Three--Phase Evaporator Motor -- Includes: See Previous Section for Standard Parts and use with Items Below: 7 EM2 -- Includes: 22--01997--20 Plug, EM2 22--01997--06 Terminal 22--01997--08 Sealing Plug 22--01997--21 Wire Seal 22--01997--22 Interface Seal 8 22--01997--20 Plug, EM2 22--01997--06 Terminal 22--01997--08 Sealing Plug 22--01997--21 Wire Seal 22--01997--22 Interface Seal 9 EBS -- Includes: 22--01997--16 Plug, EBS 22--01997--06 Terminal 22--01997--17 Wire Seal 22--01997--18 Interface Seal 10 CM -- Includes: 22--01997--01 Plug CM 22--01997--06 Terminal 22--01997--08 Sealing Plug 22--01997--02 Wire Seal 22--01997--03 Interface Seal Qty 1 7 3 1 1 1 7 3 1 1 1 4 1 1 1 3 1 1 1 107 T-334PL 3 INTERROGATOR ACCESSORIES 3. 1 DATALINE/DATAREADER 2 1 3 4 H. PALMTOP 5 6 7 15 To DataReader or PC 12 9 8 10 DataReader 13 11 14 DataReader Personal Computer T-334PL 108 3. 1 DATALINE/DATAREADER (Continued) Item Part Number Description 1 07--00406--00 Disk Kit, DataLine (SEE NOTE) -- Includes: 2 12--00413--05SV Software, DataLine NSS 3 12--00528--00 Software, DataLine (Scroll) NSS 4 22--01737--02 Cable, H. PalmTop 5 76--50059--00 Kit, Cable, with Adapter -- Includes: 6 22--02418--02 Cable, Interrogator 7 22--02420--00 Adapter 8 76--50058--00 Kit, Battery, with Cable -- Includes: 9 NSS Battery, External, with Battery Charger 10 22--02401--00 Cable 11 No Longer Offered DataReader 12 22--01737--00 Cable, Download 13 22--01737--01 Cable, Adapter 14 22--01743--00 Cable, Upload 15 -Receptacle -- Refer to Section 2. 32 NOTE Kit includes a 3. 5 DS/HD Diskette, Formatted. If a DS/DD Diskette is required, contact a Customer Service Representative. Qty 1 1 1 1 1 1 1 1 1 1 -1 1 1 -- 109 T-334PL 4 TOOLS PART NO. 07--00013--00 07--00013--01 07--00013--02 07--00013--03 07--00015--00 07--00176--11 07--00375--00 07--00408--00 07--00450--00 07--00437--00 07--00228--00 07--00229--00 07--00238--00 07--00243--10 07--00263--00 07--00264--00 07--00277--00 07--00304--00 07--00294--00 07--00294--05 07--00295--00 07--00397--03 07--00397--02 07--00329--00 07--00330--00 07--00370--00 07--00387--00 07--00375--00 07--00391--00 07--00398--00 07--00409--00 07--00410--00 07--00411--00 07--00418--00 DESCRIPTION Temperature Tester (Simpson Meter) Temperature Test Lead (15 Foot) Temperature Test Lead (50 Foot) Adapters, Male (Both Ends) (Use with Temperature Tester) Case, Carrying (Used with 07-00013-00) Vacuum Pump, Dual Voltage/Dual Frequency Stepper Motor Drive Tester Stepper Jumper Assembly Wrench, Compressor Sight Glass Inspection Light with Mirror Volt--Ohmmeter, Digital Amprobe Clamp (Used with 07-00228-00) Wrench, Service Valve Multimeter, Digital (Fluke) Pliers, Crimping (Used for Compressor Terminal Block replacement) Grip, Wire Vise (Used for Compressor Terminal Block replacement) Kit, Static Dissipative (Used for working on electronic components) Ground Strap, Wrist (Used for working on electronic components) Gauge Set, Manifold -- Fahrenheit/PSI Gauge Set, Manifold -- Centigrade/KPa Detector, Leak Extractor, Pin (Used on Fan Motor Plugs and Interrogator Plugs) Crimper, Pin (Used on Fan Motor Plugs and Interrogator Plugs) Extractor, Pin (Used on Controller Module Connectors) Crimper, Pin (Used on Controller Module Connectors) Crimper, Pin (Used on Stepper Valve, HPS) Extractor, Pin (Used on Stepper Valve, HPS) Tester, Portable, Stepper Motor Drive Application Gun (Used with 07--00390--00) Software Card Programmer 1--1/8", 3/8" Drive, Used on Economizer Valve 1--3/8", 3/8" Drive, Used on Suction/Discharge Valve 2--1/8", 3/8" Drive, Used on SMV Torx Driver Bit Refer to Manual 62-03213 T-334PL 110 PART NUMBER INDEX PART NO. 04--50027--00 04--50029--00 04--50029--01 07--00013--00 07--00013--01 07--00013--02 07--00013--03 07--00015--00 07--00176--11 07--00228--00 07--00229--00 07--00238--00 07--00243--10 07--00263--00 07--00264--00 07--00277--00 07--00294--00 07--00294--05 07--00295--00 07--00304--00 07--00313--00 07--00329--00 07--00330--00 07--00345--00 07--00370--00 07--00375--00 07--00387--00 07--00391--00 07--00397--02 07--00397--03 07--00398--00 07--00406--00 07--00408--00 07--00409--00 07--00410--00 07--00411--00 07--00418--00 07--00427--00 PAGE NO. 57, 83 83 83 110 110 110 110 110 110 110 110 110 110 110 110 110 110 110 110 110 1 110 110 1 110 110 110 110 110 110 110 109 110 110 110 110 110 43 PART NO. 07--00437--00 07--00450--00 09--00375--00 10--00083--06 10--00083--07 10--00083--08 10--00332--06 10--00388--00 10--00398--00 10--00413--00 10--00431--06 10--00431--07 10--00431--08 10--00439--01 10--00446--00 10--00455--00 10--01129--15 10--01129--20 12--00170--08 12--00275--19SV 12--00290--04 12--00309--05 12--00342--04 12--00352--00 12--00352--07 12--00395--02 12--00413--05SV 12--00433--00RP 12--00433--02RP 12--00464--07 12--00464--08 12--00493--09 12--00493--10 12--00495--02 12--00495--20SV 12--00500--01SV 12--00528--00 12--00573--01SV PAGE NO. 110 110 33 62 62 62 25 11 11 85 25 25 25 25 39 77 39 27, 28, 39 85 31 29 41 17 41 41 37 109 39 39 71, 73 72 37 37 37 85 85 109 31 PART NO. 12--00594 12--01071--02 12--50089--00 12--55009 14--00176--04 14--00220--00 14--00220--04 14--00221--03 14--00222--02 14--00232--31 14--00273--09 14--00284--20 14--00285--00 14--00341--04 14--00341--07 14--00341--07Pk25 14--00353--00 14--00353--20 14--00353--21 14--01032--14 14--01090--02 14--01090--11 14--01090--12 14--01090--15 14--01091--02 14--01091--04 18--00077--40 18--10134--23 22--00041--00 22--00041--02 22--00049--01 22--00066--01 22--00066--02 22--00066--03 22--00119--04 22--00120--04 22--00120--07 22--00121--07 PAGE NO. 33 52 17 33 45 52 51, 52 51 51 49 81 50, 52 51, 52, 53 1 50, 52 50, 52 45 45 45 51 51 51, 53 51, 53 82 53 51, 53, 82 43 43 1 1 27, 28 1 1 1 1 1 1 1 Index--1 T-334PL PART NUMBER INDEX PART NO. 22--00518--01 22--00519--01 22--00519--03 22--00595--01 22--01106--00 22--01107--00 22--01139--04 22--01140--01 22--01140--02 22--01140--04 22--01141--01 22--01313--22 22--01455--03 22--01551--00 22--01556--00 22--01556--01 22--01556--02 22--01556--04 22--01556--06 22--01565--01 22--01566--01 PAGE NO. 27, 28 28 27, 28 1 1 1 1 1 1 1 1 95, 97 39 58, 59 31 103 103 103 103 101 89, 91, 93, 95, 96, 97, 99, 101 89, 91, 93, 95, 96, 97, 99 14 14 28 11 11 9, 11, 93, 95, 97, 99, 101 9, 11, 93, 95, 97, 99, 101 101 9, 93, 99, 101 22--01660--05 22--01660--08 22--01679--00 22--01679--03 22--01713--03 22--01713--06 22--01713--16 22--01713--18 22--01713--20 22--01713--21 22--01713--26 22--01731--00 22--01731--01 22--01733--01 22--01735--00 22--01737--00 22--01737--01 22--01737--02 22--01743--00 22--01744--00 22--01613--15 22--01613--26 22--01614--06 22--01621--00 22--01621--02 22--01622--00 22--01622--01 22--01622--02 22--01622--03 22--01660--00 22--01660--02 22--01660--03 PART NO. 65, 89, 91, 93, 95, 97, 99 17, 95, 97 95, 97 91, 93, 95, 97, 99, 101 33 33, 95, 97 25 103 33 25, 33, 103 91, 93, 95, 97, 99 17 65, 89, 91, 93, 95, 97, 99 17, 65 9, 17 61 63 39 33 69, 71 69 11, 101 11, 101 11, 101 58 58 14 103 109 109 109 109 59 22--01777--04 22--01777--06 22--01777--07 22--01778--00 22--01835--00 22--01883--00 22--01884--00 22--01891--00 22--01906--00 22--01931--00 22--01932--00 22--01944--00 22--01944--05 22--01944--10 22--01964--02 22--01997--01 22--01997--02 22--01997--03 22--01997--04 22--01997--05 22--01997--06 22--01997--08 22--01997--09 22--01997--10 22--01997--11 22--01997--12 22--01997--13 22--01997--14 PART NO. 88, 90, 92, 94, 96, 98 11, 88, 89, 90, 91, 92, 93, 94, 95, 96, 97, 98, 99 88, 90, 92, 94, 96, 98 88, 90, 92, 94, 96, 98 88, 90, 92, 94, 96, 98 61 11 59 59 59 59 59 59 89, 91, 93, 95, 97, 99 89, 91, 93, 95, 97, 99 89, 91, 93, 95, 97, 99 92 105, 107 105, 107 105, 107 83 57 105, 107 83, 105, 107 83 57 83 105 83, 105 105 22--01585--04 22--01602--02 22--01602--03 22--01604--00 22--01613--08 22--01613--09 22--01613--10 22--01613--11 22--01613--12 22--01613--13 T-334PL Index--2 PART NUMBER INDEX PART NO. [. . . ] 69NT35--1287--1 69NT35--1417 69NT35--2086 69NT35--2287 69NT35--2692 69NT35--2692--1 PAGE NO. 77 77 60, 61 35 33, 87 37, 47, 48, 57, 68, 69, 71, 76, 77, 83, 85 39, 55 87 78 15 15 76 71, 74 20 71 63 57 17 35 35 35 25 17 23 58 58 85 77 77 66 41 14, 75 77 63 55 25 25 T-334PL Index--8 PART NUMBER INDEX PART NO. 69NT35--9228 69NT35--9238 69NT35--9952 69NT40--222 69NT40--914--4 69NT40--976--3 69NT41--192 69NT41--192--1 69NT41--257--2 69NT41--782 69NT41--852--1 69NT41--892 69NT41--982--3 69NT42--954--4 69NT43--124--4SV 69NT43--125--1 69NT43--256 69NT43--270 69NT43--270--1 69NT43--282 69NT43--295 69NT43--307 69NT43--374 74--66608--00 74--66608--01 74--66608--02 74--66608--03 74--66608--04 74--66608--05 74--66608--06 76--00667--03 76--00667--04 76--00675--01 76--00676--00 76--00701--10 76--00701--11 76--00701--13 76--00704--01 76--00704--02 76--00734--00 PAGE NO. 77 77 23 29 60, 61 77 65 65 76 77 76 61 34 52 23 23 71, 72, 73 62 61 61 83 76 60, 61 19 21 19 20 20 21 22 61 60 85 17 71 72 74 57 57 52 PART NO. [. . . ]