User manual APRILIA TUONO 1000 R

[. . . ] - Noale (VE) First edition: October 2005 Reprint: SAFETY WARNINGS The following precautionary warnings are used throughout this manual in order to convey the following messages: Safety warning. When you find this symbol on the vehicle or in the manual, be careful to the potential risk of personal injury. Non-compliance with the indications given in the messages preceded by this symbol may result in grave risks for your and other people's safety and for the vehicle! If the glove/tool kit compartment cover has been installed (as an alternative to the passenger seat), the transport of passenger, luggage or objects is forbidden. WARNING Racing settings may only be used during official competitions or sports events authorised by the competent authorities and taking place in closed circuits or, anyway, away from public roads. It is strictly prohibited to carry out adjustments for the use of the vehicle on racetracks and then ride it on roads or motorways. Produced and printed by: VALLEY FORGE DECA Ravenna , Modena, Torino DECA S. r. l. [. . . ] Make sure that all documents are in order and the road tax has been paid. Write down your personal data and telephone number in this page, to facilitate the identification of the owner in case of finding after theft. NOTE Very often stolen vehicles are identified thanks to the data written in the use/maintenance manual. IMMOBILISER (if fitted) The vehicle is fitted with an immobiliser antitheft system by that is automatically activated each time the ignition key is removed from the switch. If both keys are lost, you will have to have a number of vehicle components replaced (rather than just the key-operated locks). Embedded in the key grip is a transponder, an electronic device that modulates the radiofrequency signal emitted by a special antenna built into the switch when the key is turned to on. The modulated signal acts as a "password" that tells the control unit whether an authorised key is being used to start the engine. New keys can only be enabled at your Authorised dealer, who has the master key available. An owner who wishes to have a new key enabled, will have to bring all the keys he intends to be using to the Dealer. 1 Immobiliser status is indicated by a light (1) on the instrument panel: -Immobiliser off - light off -Immobiliser on - light blinking -Key not recognised - quick blinking use and maintenance RSV 1000 TUONO R 57 MAINTENANCE WARNING Risk of fire. Keep fuel and other flammable substances away from the electrical components. Before beginning any maintenance operation or any inspection of the vehicle, stop the engine, extract the key from the ignition switch, wait until the engine and the exhaust system have cooled down and if possible lift the vehicle by means of the proper equipment, on firm and flat ground. Before proceeding, make sure that the room in which you are working is properly ventilated. Keep away from the red-hot parts of the engine and of the exhaust system, in order to avoid burns. Do not hold any mechanical piece or other parts of the vehicle with your mouth: the components are not edible and some of them are harmful or even toxic. Routine maintenance operations can usually be carried out by the user, but sometimes specific tools and specific technical skills may be required. In case periodic maintenance operations, assistance or technical advice are needed, contact an aprilia Authorised Dealer, who will ensure you prompt and accurate servicing. Ask your aprilia Authorised Dealer to test the vehicle on the road after a repair or periodic maintenance operation. In any case, personally carry out the "Preliminary checking operations" after any maintenance operation, see page 47 (PRE-RIDE CHECKS CHART). NOTE This vehicle is equipped with an electronic engine control unit capable of detecting abnormal operation in real time and storing faults. Each time the ignition key is set to " ", the word " SERVICE" (1) appears on the right side of the multifunction display for approximately three seconds. LAP Km/h ODO Km °C In many cases the engine keeps running with limited performance; contact an aprilia Authorised Dealer immediately. CAUTION After covering the first 1000 km (625 mi) and every 10000 km (6250 mi) afterwards, the " SERVICE" (1) symbol appears on the right display. In this case have an aprilia Authorised Dealer perform all service operations as indicated in the scheduled maintenance chart, see page 59 (REGULAR SERVICE INTERVALS CHART). CAUTION If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. In case any maintenance operation should be required, it is advisable to use latex gloves. 58 use and maintenance RSV 1000 TUONO R CAUTION If the wording " SERVICE" is displayed during normal engine operation, it means that the Engine Control Unit has detected a fault. REGULAR SERVICE INTERVALS CHART OPERATIONS TO BE CARRIED OUT BY THE aprilia Authorised Dealer (WHICH CAN BE CARRIED OUT EVEN BY THE USER). Key = check and clean, adjust, lubricate or change, if necessary; = clean; = change; = adjust. [. . . ] 5 k Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12 V ­ 10 Ah 30 A 5 A, 15 A, 20 A 12 V ­ 500 W 12 V ­ 55 W H11 x 2 12 V ­ 55 W H11 x 2 12 V ­ 5 W x 2 12 V ­ 10 W AMBER (USA version 12 V - 10 W) 12 V ­ 5 W LED LED LED ELECTRIC SYSTEM BULBS 112 use and maintenance RSV 1000 TUONO R WARNING LIGHTS Neutral. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Immobiliser. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . LED LED LED LED LED LED LED LED use and maintenance RSV 1000 TUONO R 113 LUBRICANT CHART EXTRA RAID 4, SAE 15W - 50 or TEC 4T SAE 15W - 50. As an alternative to recommended oils, top brand oils meeting or exceeding CCMC G-4 A. P. I. [. . . ]