User manual APRILIA SR50 DITECH DEALER INSTRUCTION 2001

[. . . ] aprilia DEALER INSTRUCTION SHEET SR 50 DITECH aprilia SR 50 DITECH DEALER INSTRUCTION SHEET 3 2 1 7 2 4 1 ASSEMBLING SPRAY GUARDS · To fit the spray guards (1) fit the washer (2) and secure with the screw TBEI M 5x20 (3) and the selflocking nut M 5 (4). · Position the license plate light (5) and secure with two self-blocking nuts M 5 (6). NSTRUCTIONS FOR REMOVING MOTORCYCLE FROM CRATE SAFETY MESSAGES The following warning messages are used on all the instruction sheets to draw your attention to the situations described below. [. . . ] Read the instructions in the sheets to avoid breakages or incorrect assembly. After removing the nailed-on supports and crosspieces from the crate (used for transport purposes), push the motor cycle off the bottom of the crate and position it on the stand. NB: The instructions for the battery, wing mirrors and spray guards are inside the helmet compartment under the saddle. 6 7 DANGER Risk of serious injury or death. CAUTION Possible risk of slight injury or damage to motor cycle. IMPORTANT The word "IMPORTANT"is written before any important information on the instruction sheet. aprilia part #8202293 - 04/01 - USA Pag. 1 aprilia DEALER INSTRUCTION SHEET 2 1 6 SR 50 DITECH aprilia 3 SR 50 DITECH DEALER INSTRUCTION SHEET 2 1 4 3 4 5 5 2 Do not tip the vehicle too much, or tip the battery too much, to avoid electrolyte leaking out. FITTING THE MIRRORS Fit the mirrors as follows. 1 CAUTION The battery liquid is corrosive. When the battery has been removed it must be placed in a safe place out of the reach of children. INITIAL BATTERY CHARGING · To fit the right wing mirror position the gasket (1) marked "DX" and the mirror (2), then tighten with screw TCEI M 8x35 (3). Screw (3) tightening torque: 18, 44 ftlb (25 Nm) · Close the hole in the mirror with the rubber plug (4). · Do the same for the righthand mirror. A 4 5 B 3 6 CAUTION BATTERY Battery electrolyte is toxic, caustic and the contact with the skin may cause serious burns, since it contains sulfuric acid. Wear protective clothing, a face shield and/or tight fitting goggles when working around the battery. In case of contact with the skin, flush immediately with plenty of water. In case of contact with the eyes, flush with plenty of water for at least 15 minutes. If the electrolyte is accidentally swallowed, drink large quantities of water or milk, and then milk of magnesia or vegetable oil. The battery gives off noxious and explosive gases; keep it away from cigarettes, flames, sparks and any other source of heat. [. . . ] · Tighten the two screws TCEI M 6x20 (7) of the wheel pin terminal to 8. 85 ftlb (12 Nm). CAUTION · Make sure the ignition key is in the " " position. · First connect the positive cable (+ red) then the negative (- blue). · Fit the tool kit carrier and cover. IMPORTANT IMPORTANT To fit the front wheel, you may require a helper. Pag. [. . . ]