User manual APRILIA RSVMILLE DEALER INSTRUCTION 2002

[. . . ] RSV mille RSV mille R RSV mille RSV mille R INSTRUCTIONS FOR THE DEALER RSV mille RSV mille RSV mille R RSV mille R INSTRUCTIONS FOR REMOVING MOTORCYCLE FROM CRATE SAFETY MESSAGES The following warning messages are used on all the instruction sheets to draw your attention to the situations described below. When you see this symbol on the motorcycle or instruction sheets, beware of potential injury hazards. Failure to observe the instructions following these symbols may affect your safety, the safety of others and that of the motor cycle! [. . . ] 1 RSV mille RSV mille R RSV mille RSV mille R INSTRUCTIONS FOR THE DEALER 1 3 4 3 INSTRUCTIONS FOR THE DEALER 2 DANGER Battery electrolyte is toxic, caustic and the contact with the skin may cause serious burns, since it contains sulfuric acid. Wear protective clothing, a face shield and/or tight fitting goggles when working around the battery. In case of contact with the skin, flush immediately with plenty of water. In case of contact with the eyes, flush with plenty of water for at least 15 minutes. If the electrolyte is accidentally swallowed, drink large quantities of water or milk, and then milk of magnesia or vegetable oil. The battery gives off noxious and explosive gases; keep it away from cigarettes, flames, sparks and any other source of heat. During the recharging or the use, make sure that the room is properly ventilated and avoid inhaling the gases released during the recharging. Do not tip the vehicle too much, or tip the battery too much, to avoid electrolyte leaking out. BATTERY INITIAL BATTERY CHARGING 1 2 CAUTION FITTING THE RETROREFLECTOR w Place the retroreflector (2) on the mudguard and secure with a self-tightening flanged nut (1) M5. FITTING THE LICENSE PLATE HOLDER w Place the license plate holder (3) on the mudguard (4) and secure with 3 screws M6 and 3 flanged nuts. w Remove the saddle, by unscrewing the screws (1). FITTING THE BATTERY w Make sure the ignition key is in the position. REFITTING THE BATTERY AFTER FIRST RECHARGE CAUTION Wait 5-10 minutes after recharging and then fit the battery, since it continues to produce gas for a period after recharging. CAUTION The battery liquid is corrosive. When the battery has been removed it must be placed in a safe place out of the reach of children. The battery is very dangerous and may cause serious injury or death. Pag. [. . . ] Screw (5 - 6) tightening torque: 16, 22 ftlb (22 Nm). CAUTION When fitting the front wheel, check the direction against the arrow on the hub. w Fit the wheel and pin (1). 5 w Fit the screws (5) of the left-hand rod terminal to prevent the pin rotating. w Remove the stand. CAUTION The spacer (2) must be fitted on the right of the vehicle between the wheel and wheel pin terminal. Pag. [. . . ]