User manual APRILIA RSV MILLE R 2002

[. . . ] - Noale (VE) First edition: august 2002 Reprint: Produced and printed by: DECA s. n. c. +39 - 0545 35235 Fax +39 - 0545 32844 E-mail: deca@decaweb. it www. decaweb. it On behalf of: aprilia s. p. a. +39 - 041 58 29 111 Fax +39 - 041 44 10 54 www. aprilia. com Indicates a potential hazard which may result in serious injury or even death. Indicates a potential hazard which may result in minor personal injury or damage to the vehicle. The word "NOTE" in this manual precedes important information or instructions. The adjustments for the use of the vehicle on racetracks must be carried out exclusively in case of organized races or events that take place on isolated circuits, away from public roads and with the consent of the competent authorities. [. . . ] Before proceeding, make sure that the room in which you are working is properly ventilated. Keep away from the red-hot parts of the engine and of the exhaust system, in order to avoid burns. Do not hold any mechanical piece or other parts of the vehicle with your mouth: the components are not edible and some of them are noxious or even toxic. Routine maintenance operations can usually be carried out by the user, but sometimes specific tools and specific technical skills may be required. In case periodic maintenance operations, assistance or technical advice are needed, contact an aprilia Official Dealer, who will ensure you prompt and accurate servicing. Ask your aprilia Official Dealer to test the vehicle on the road after a repair or periodic maintenance operation. In any case, personally carry out the "Preliminary checking operations" after any maintenance operation, see p. 49 (PRELIMINARY CHECKING OPERATIONS). NOTE This vehicle is set so that any anomaly can be detected in real time and stored by the electronic unit. Whenever the ignition switch is brought to position "B", the writing "efi" (1) appears on the right side of the multifunction display for approximately three seconds. If not expressly indicated otherwise, for the reassembly of the units repeat the disassembly operations in reverse order. In case any maintenance operation should be required, it is advisable to use latex gloves. If the writing "efi" (1) is displayed during the normal operation of the engine, this means that the electronic unit has detected an anomaly. In many cases, the engine keeps running with reduced performance levels; immediately contact an aprilia Official Dealer. After the first 1000 km and successively every 7500 km, the word "SERVICE" (2) appears on the right display. In this case contact an aprilia Official Dealer, who will carry out the operations indicated in the regular service intervals chart, see p. To make the writing "SERVICE" disappear, press the "LAP" push button (3) and then the push button S (4) and keep them pressed for about five seconds. use and maintenance RSV mille !- RSV mille R ! 59 REGULAR SERVICE INTERVALS CHART OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer (WHICH CAN BE CARRIED OUT EVEN BY THE USER). = check and clean, adjust, lubricate or change, if necessary; " = clean; # = change; $ = adjust. Component Spark plugs (*) Air cleaner Engine oil filter (*) Engine oil filter (on oil tank) Fork Light operation/direction Light system Safety switches Clutch fluid Brake fluid Coolant Engine oil Tyres Tyre pressure (**) Engine idling rpm Engine oil pressure warning light LED Drive chain tension and lubrication Brake pad wear After running-in (1000 km) Every 7500 km or 12 months !! NOTE Perform the maintenance operations with doubled frequency if the vehicle is used in rainy or dusty areas, on uneven surfaces or on racetracks. (**) = Check every two weeks or according to the intervals indicated. # !every 1000 km: ! ! before every trip and every 2000 km: ! 60 use and maintenance RSV mille !- RSV mille R ! OPERATIONS TO BE CARRIED OUT BY THE aprilia Official Dealer. = check and clean, adjust, lubricate or change, if necessary (according to workshop manual specifications); " = clean; # = change; $ = adjust. Component Rear shock absorber Gearbox (***) Transmission cables and controls Rear suspension linkage bearings Steering bearings and steering clearance Wheel bearings Brake discs General running of the vehicle Adjusting the valve clearance Braking systems Cooling system Clutch fluid Brake fluid Coolant Fork oil (**) Fork oil seals " Fork oil seals # Brake pads Wheel/Tyres Nut, bolt, screw tightening Cylinder synchronization Suspensions and attitude Final transmission (chain, crown and pinion) Fuel pipes Clutch wear (*) Pistons (***) After running-in (1000 km) Every 7500 km or 12 months Every 15000 km or 24 months ! every 10000 km: !every 2 years: 3 after the first 7500 km and successively every 22500 km : # after the first 30000 km and successively every 22500 km: # !- RSV mille R ! NOTE Perform the maintenance operations with doubled frequency if the vehicle is used in rainy or dusty areas, on uneven surfaces or on racetracks. (***) = Only in case of: ­ intense use on racetracks; ­ participation in competitions. !every 4 years: # 61 JOINTS WITH CLICK CLAMPS AND WITH SCREW CLAMPS click clamp, since it is unusable. [. . . ] 12 V ­ 10 Ah 30 A 15 A 12 V ­ 400 W 12 V ­ 55 W H7U 12 V ­ 55 W H7U 12 V ­ 5 W 12 V ­ 10 W 12 V ­ 5/21 W 12 V ­ 2 W 12 V ­ 2 W 12 V ­ 2 W 12 V ­ 3 W 12 V ­ 3 W 12 V ­ 3 W 12 V ­ 3 W 12 V ­ 3 W LED LED ELECTRIC SYSTEM BULBS WARNING LIGHTS use and maintenance RSV mille !- RSV mille R ! 113 LUBRICANT CHART Engine oil (recommended): EXTRA RAID 4, SAE 15W - 50 or TEC 4T, SAE 15 W - 50. As an alternative to the recommended oil, it is possible to use high-quality oils with characteristics in compliance with or superior to the CCMC G-4, A. P. I. If you need an oil with intermediate characteristics in comparison with the F. A. [. . . ]